2022 HYUNDAI TUCSON Complaints

Trailing arm bushings on both sides appear to generate considerable noise indicating wear (has been since delivery but getting much worse over this year). Dealer's solution was to simply lubricate them. The owner manual says nothing of this, and I think this is a simple "go away" band-aid solution. Attempted to reach Hyundai corporate, who asked me to confirm with the dealer if that is proper. That seems like a question for engineering, not the dealer who applied the band-aid fix. It is apparent that the bushings they affixed to the vehicle are defective and could possibly cause larger issues down the line -- far enough down the road when Hyundai can claim they are a wear item and need to be replaced.

Check engine light and error message popped up on screen "A possible condition with your Engine Control System has been detected. A full system check is recommended to be done when convenient. Please contact your local dealership to schedule an appointment." Roughly 46500 miles. Contacted BlueLink and they could not help because dealerships were already closed.

Vehicle was parked for an hour facing south. When vehicle was started, forward safety and blind spot monitoring warnings came on and many other systems tied to forward camera were disengaged. Mileage: 123k. Power steering was unresponsive and brakes felt spongy. Disconnected battery and let sit for a day. Reconnected and issue went away. A week later, was parked at hospital facing south for 4 hours. Issue came back, this time disconnecting battery did not fix issue. Dealer currently has the vehicle and they are claiming it shows rear end damage even though the car hasn’t been in an accident since I was rear ended and car was repaired. Dealer reported over 80 body codes including blind spot monitoring radar.

Vehicle has experienced, unexpected, slight and brief, acceleration 3 times at highway speeds up to 60 mph. The 4th incident was an uncontrolled acceleration when parking behind another parked vehicle. Car accelerated into the backend of parked vehicle. Operator was at a complete stop and needed to pull forward a few feet. They took foot off of brake and lightly pressed the gas peddle. The car unexpectedly surged forward hitting parked car. 1 day later we received an email from Hyundai Blue Link stating that "a possible condition with your Engine Control System has been detected" and recommends bringing in for service for a full system check. Both cars were damaged and Tuscon had to be towed to a repair shop.

After dark, the headlights will randomly switch from auto to parking lights to headlights on or completely off. When using the selector sometimes takes a few seconds to switch from auto to off and sometimes won’t switch off. This just started three days ago. It happens while it’s parked and while driving the lights will shut off. You can use the switch to turn them on but both auto and off take a while to be selected.

While driving the car the engine died, locking up both the gas and brake pedals. The car had to come to a stop on its own, my wife could not depress the gas or brake to stop the car. She was going through an intersection and narrowly avoided a major accident! The battery light came on, the check engine light and the car started to fill up with a smell of burning plastic and gas. When trying to turn the car back on after turning it off it would start with a major shake and bang then turn back off. All warning lights stayed on. Battery was fully charged still. Autobody shop found engine issues in their pre scan before sending it to Hyundai to warranty it as it only has 6,626 miles and is 2 years old. There was a warning of low battery while we were on vacation and the car was sitting for a few days. And a sluggish start when it sat for few days like the battery was low, but it wasn’t based on the volt meter.

At 37,430 mileage while driving on the interstate our vehicle check engine light came on, shortly after, our vehicle began to shake, and would stall if our RPM fell below 2000, placing us at a serious safety risk of breaking down and causing an accident on the interstate driving 80 mph. We were 290 miles from the nearest Hyundai service department, and managed to make it without breaking down. After inspecting our vehicle, the service department reported that our fuel injector for cylinder two needed replacing, but that it would take 3 business days to order the part, leaving us stranded 1600 miles from home for 6 days in total. On our way back home, at around 38,800 mileage, our check engine light came back on and are car began to shake and stall if our RPM fell below 2000 (same as before) while driving on the interstate. We were 140 miles from the nearest Hyundai service department and still 800 miles from home, leaving us stranded once again. The service department replaced our fuel injector for cylinder 1, and confirmed that this is a known issue for the 2022 Hyundai Tucson, but that Hyundai refuses to replace the fuel injectors until they go bad. This is extremely unsafe, and we still have two fuel injectors that will likely need replacing.

Fuel injector failure while driving at highway speeds to only have the car lose power and becoming a danger while attempting to get off the highway. The fuel injectors are a regular problem with this year, make, and model vehicle. The warning lamps didn’t come on until after loss of power. This is the second time that this has happened. First time was on July 12,2024..

I am dealing with my 3rd clogged fuel injector. My car lost power, starting shaking and wouldn’t accelerate. The engine light went on when it happened, not before. The first time I was on the highway, second time on a major thoroughfare. Not places where I could just pull over. Very scary. I got the first one fixed in 2023. This happened again a year later with a different fuel injector. I just got my car back 2 weeks ago and it is doing it again. I will have it towed but NOT to the dealer this time. They told me it wasn’t a problem with this car, until I called them out on it. Then she said she misunderstood. They are well aware of the problem. I can’t believe the dealer because they aren’t upfront about the problem. They didn’t even give me the paperwork this second time, just a receipt. I when I get this third one fixed, I will never be comfortable driving it

The component that failed are the visibility with headlights being completely snow packed and covered in a snow storm. The lights themselves did not fail, but the design causes snow to get stuck over all the headlights, which continues building to a point where 99%+ of light blocked. This has occurred numerous times since owning the car, easily 20+ times. VERY dangerous, oncoming cars will flash their headlights because the Tucson headlights are completely covered. Visibility is greatly decreased. Have to pull over multiple times driving in snow storms to break the snow and ice free from the headlights, only to build up again once driving. This puts not only our lives, but other drivers lives at risk. Just imagine driving in winter conditions, at night, with no headlights. Mentioned to dealer, but not documented anywhere and was not given any serious consideration. At that point we were focused on trying to get the power loss/hesitation and extremely rough shifting fixed. Big design flaw with the combination of headlights built into the grill, and with new technology, the lights must not get hot enough to melt the snow. Anyone who thinks that driving in a snow storm, at night, and no headlights isn't a huge safety issue or that this is exaggerated, I invite you to come take a ride with us this winter.