2022 HYUNDAI TUCSON Complaints

The rocker arm of the engine has failed, causing a repair for a full engine replacement. The car has always undergone maintenance timely, and upon inspection by the dealership technician, the report state the vehicle was up to adequate level. There were no symptoms before the issue occurred, only the sudden catastrophic engine failure.

this recall still hasn’t been resolved. why hasn’t the manufacturer found a fix for this problem I have owned the vehicle for 4 years they should have known about this and fixed it by now. NHTSA recall number: 25V-893 Hyundai recall number: 290

The issue involves the vehicle’s drivetrain and hybrid/electronic control system, where the car suddenly jerked forward in stop-and-go traffic on the freeway as if it had been struck from behind. Immediately following this event, the vehicle would not accelerate beyond approximately 40 mph, indicating a loss of normal power. This created a significant safety risk, as the sudden jerking could have led to a rear-end collision, and the inability to accelerate properly made it difficult to keep up with traffic on the freeway. I was barely able to safely pull off the freeway while surrounding traffic continued at higher speeds, increasing the risk to myself and other drivers. The problem appeared to resolve after turning the vehicle off and then back on; however, this raises concern about intermittent failure. The vehicle was taken to a dealership for inspection, but they were unable to reproduce or identify the issue. The vehicle remains available for inspection upon request. The vehicle has been inspected by a dealer but not by the manufacturer, police, or insurance representatives. Prior to the failure, there were no warning lights, messages, or noticeable symptoms indicating an issue. Based on similar reported experiences, this event may be consistent with a “limp mode” condition or a malfunction in the transition between the electric motor and gasoline engine, potentially involving the transmission or hybrid control system.

Check engine light appeared, Car began shaking and struggling to accelerate. Independent mechanic and OReileys test stated cylinder 3 misfirw. Dealership stated GDI fuel injectors were leaking and is a known issue in several 2022 Hyundai Tuscon and needed to be replaced.

The contact owns a 2022 Hyundai Tucson. The contact stated that while maneuvering into a handicap parking space, the vehicle suddenly accelerated on its own while the brake pedal was depressed. The vehicle climbed over a concrete parking bollard and struck a handicap sign, resulting in unintended acceleration. The vehicle was damaged in the undercarriage. No air bags were deployed. No injuries were reported. Property damage was a handicap sign. The vehicle was occupied by 2; the driver and passenger. A police report was filed. The vehicle was taken to the dealer, but has not been diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 26,100.

At a slow speed the car lurched, paused, in traffic. The engine light is on. It could be dangerous.

1st Incident: Merging on to the freeway car started to stall but was able to safely make it off the freeway at next exit. Less than 2 miles was unable to accelerate to properly merge on freeway. A slow merge & slow driving on to a freeway is extremely dangerous. 2nd Incident: 6 months later, Nov. 2023. Driving about 65-70 MPH on the freeway with my son, the car started to stall again. I was able to safely move from the 2nd lane, to the shoulder. Waited over 2 hours in the dark for AAA to safely move us. 1st time documented issues with Hyundai dealership. Fuel injector was main issue and was replaced. No check eng light. 3rd Incident: May 2024 was driving about 75MPH in the fast lane when the car stalled. I was unable to move fully out of the lane as the car just died. I was half in the shoulder and the fast lane. I was crying with fear while I had to wait for CHP to move me. Multiple times feared other cars would hit me at 80MPH+ while I waited 30mins+ for CHP to stop traffic and move me to the shoulder. Took the car to the dealership for the second time to be "fixed" for the same issue as Nov. 2023. Fuel injector, and catalytic converter were "replaced". This now being the second time for the fuel injector issue. No check eng light. 4th Incident: April 2026 driving on a school night home from dinner with my son at about 9:45pm. It was raining and was traveling at about 55MPH on the highway. Car started to stall/ shut down again. Was able to go about15MPH to a safe spot and waited for assistance late at night. This happened on a highway where people tend to drive recklessly and try to pass other vehicles which causes a lot of head on collisions, [XXX] . Vehicle was towed to Hyundai dealership for the 3rd time & 3rd time documented for the fuel injector and 2nd for the catalytic converter. The vehicle's main purpose is to safely transport and I've had nothing but nightmares and put in extremely dangerous situations with my son. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B

I PURCHASED THIS 2022 TUCSON LIMITED HYUNDAI NEW. IT HAS 25,000 MILES ON IT. THE CAR CHECK ENGINE LIGHT CAME ON AND A POWER REDUCTION BEGAN ALONG WITH SHAKING OF THE CAR. I WAS ABLE TO CLEAR THE INTERSECTION SAFELY. I WAS ABLE TO TURN INTO A SAFE SPOT AND SHUT DOWN THE CAR. IT WAS TOWED TO THE DEALER WHO THEN INFORMED ME THAT IT WAS AN INJECTOR KNOW ISSUE FOR THIS YEAR AND WOULD BE COVERED UNDER THE 5 YEAR WARRANTY. HOWEVER, AS THIS IS A ENGINE/POWERTRAIN PROBLEM, IT SHOULD BE COVERED ON THE 100,000/TEN YEAR WARRANTY. A TSB (23-FL-002H-1) ALERT HAD ALREADY BEEN ISSUED, BUT NOT A RECALL. MANY OWNERS HAVE REPORTED HAVING THIS PROBLEM REPEATEDLY, AS A SAFETY ISSUE AND A KNOWN MFG DEFECT. WHEN IS THE GOVERNMENT GOING TO STEP UP AND DEMAND A REAL FIX BE DONE BEFORE SOMEONE IS KILLED? OWNER ARE CURRENT LEFT FIGHTING WITH THE DEALERS OVER THE WARRANTY LIMITS OR TAKING LEGAL ACTION. IF YOU GOOGLE THIS PROBLEM, YOU CAN FIND OUT THE NATIONAL LEVEL OF THIS PROBLEM, FROM ACCIDENTS WHICH CAUSED FIRES OR ACCIDENTS FROM POWER LOSS. MY CAR IS STILL AT THE DEALER WAITING ON PARTS. ITS TIME TO FORCE A RECALL! I WILL BE DEMANDING THAT IT IS COVERED FOR THE 10 YEAR WARRANTY PERIOD AND CONSIDERING TAKING ACTION UNDER THE LEMON LAWS. IF THE GOVERNMENT FAILS TO ACT ON THIS SOON, THAN THEY ARE JUST AS LIBEL AS THE MANUFACTURER. YOUR IMMEDIATE ATTENTION TO THIS ISSUES IS REQUESTED.

When braking my 2022 Hyundai Tucson to come to a stop, the vehicle continues to accelerate. I have to release the brake and re-apply the brake to fix the acceleration problem. I check the internet on this problem. They internet says it is a software problem. The vehicle shows no code and the dealer says they don't have a problem. The dealer has not check for the problem since there is no code. No warning lamps or messages show up on dash. This happened 4 times in the last few months. Latest date was 4-4-2026

Car is a Gas Hybrid (not plugin). 3 occurrences over the last couple of months. Car emits a warning sound and a message on the dash says "Check Hybrid System. Stop Safely". Basically right after this message the car starts losing power and stops. Doesn't matter if on freeway or not. You need to find a place to pull over or you stop traffic wherever you are. Looks like Hybrid Battery is completely drained. Can not be re-created. Dealer has it now for the 3rd time. Dealer in the past have not been able to find cause/cure since this issue is not posting any errors to the onboard diagnostic system. Temporary 'fix' is to power off car, and power back on. Looks like this is a 'known' issue though as its being reported by quite a few people online.