2016 HYUNDAI VELOSTER Complaints

When changing vehicle oil it has been noticed that there is contaminants appearing to be metal bits/glittery could possibly be rod bearing material. Also have noticed fluctuating idle

I was instructed by Hyundai USA to tow my Veloster to West Palm Beach Hyundai dealership specifically for the rod bearing diagnostic after I reported huge amount of smoke coming from the engine, engine oil leak, failed thermostat, and failed water pump, all while I was driving to work. I have repeatedly asked for Hyundai USA to send me a copy of the technician's notes, oil pressure test results, and bearing clearance measurements, part of Hyundai's TSB 21-GI-009H. Hyundai USA continues to refuse to release to me the technical rod bearing diagnostic report completed on my 2016 Veloster. Since rod bearing failure is a safety recall issue (stalling), I am listing your help to explicitly request the Service Manager's diagnostic report and photos of the rod bearing clearance test. I can't get to work with my Veloster because it is unsafe to drive and has been at the dealership since January 17, 2026. My safety is at risk.

As I was driving to work one day my 2016 Veloster suddenly lost power on the expressway at expressway speeds. Now that in itself is very dangerous seeing as how there were big rigs around me. Luckily I managed to make it off of the expressway traveling slower than I turtle.i was almost rear ended on various occasions. I parked right away and left to work. I came back later that day and cranked her over and it started,but now with the check engine light blinking. So I attempted to drive it a little and it worked but now I've come to find out that it is in protect mode.I took it to my local Hyundai dealership (Hyundai of pharr) in pharr Texas and was told that Hyundai would not honor their extended warranty because whatever is wrong with it is not covered according to them. So a while back there was a class action lawsuit in California against the Hyundai Corporation of which I was a part of. When it was time for settlement I had a choice of monetary gain or and overly extended warranty on my 2016 Veloster that covered engine and transmission for I believe was 10 more years. So I chose the warranty but Hyundai still won't cover it. I guess I have to wait for my car to catch on fire before they submit the warranty and even then they will blame something else. So here I am,telling my story.

The climate control knob and AC system failed due to an apparent wiring defect. This is a known issue affecting hundreds or thousands of Hyundai Veloster owners. The failure causes loss of climate control and creates a safety issue due to a lack of defrosting and cabin airflow, as well as electrical fires. I have spent thousands of dollars trying to get this fixed, and mechanics are turning me away.

On March 2024, I had my veloster towed to a certified Hyundai service dealer because it suddenly began losing power, the oil light came on, the engine light flickered, and it began making a whining noise, and then the engine died and wouldn’t crank again. It took them weeks to diagnose it, and they told me the turbo was out in it, and quoted me an absurd amount to replace it. I had the turbo replaced, as well as some gaskets, the coils and spark plugs. It ran fine after that until June 2025 when the oil and check engine light came on and the engine died again while we were coming home from a vacation, 2 hours south of where we live in a tiny town that had no dealership or rental company within 100 miles. We found a small mechanic who said it needed a lower fuel pump. He put one in it and we got back on the road, but it still wasn’t running as well as it should. It don’t have quite as much power, but no dash lights came on. When I got home I took it to another local certified Hyundai service dealer, who said it needed new coils and spark plugs again, so they replaced them. Again it ran fine for a while until the day after thanksgiving this year, 11/25, when the oil light came on again at the end of my road. I took it to another local certified auto parts store who read the codes and found no suggested fix. No certified dealers were open that day, so I took it to Pep Boys where the engine light came on when I pulled in, and who said they thought it needed new timing solenoids, and put them in it. When they finished, they drove it and told me they felt like the turbo was going out and advised I take it to the dealer again. I had it towed to a certified Hyundai service dealer on Monday 12/01/25. They diagnosed it as needing a new turbo (again), a lower oil pan, and an oil switch. Quoted $3550. Over a week later today they told me that after putting it all in and tiring it on that the oil light came back on. They have now diagnosed it as needing an oil pump.

The contact owns a 2016 Hyundai Veloster. While the contact’s wife was driving at an undisclosed speed, the vehicle suddenly lost power, with the check engine warning light illuminated. The contact stated that the vehicle then stalled at a stoplight. The vehicle was restarted and immediately driven to the local dealer, who diagnosed the vehicle and determined that the engine compression was abnormal and advised the contact that the engine needed to be replaced. The vehicle was not repaired. The contact stated that while at the dealer, the service and diagnostic guidelines were not followed regarding the NHTSA Action Number: EA21003 (ENGINE), and the coverage was denied. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 125,367.

While driving my 2016 Hyundai Veloster (VIN: [XXX] ) on the highway, the vehicle suddenly lost acceleration. I went from 60 mph down to 20 mph with no throttle response, and the car only continued moving briefly from momentum. I was forced to stop in unsafe highway conditions and had the vehicle towed home. Prior to this complete failure, the car had recurring transmission/drive issues: it would start, but when placed in reverse it moved backward, and when shifted into drive it still only moved backward. Despite repeated repair attempts, the problems persisted. A certified mechanic later inspected the vehicle and confirmed severe internal engine damage, including metallic noises, blue smoke, oil leakage from worn piston rings, and complete compression loss. The mechanic concluded the vehicle requires deep engine repair or replacement. These failures are consistent with widespread reports of Hyundai Veloster engine defects, which pose serious safety risks to drivers. My vehicle is now inoperable despite responsible maintenance and repeated attempts to fix the issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

King Hyundai hung up/refused free Recall 198 inspection despite confirmed defect (rod bearing/crank damage). VIN [XXX] . Case #1824300. Safety risk—stall/fire. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My vehicle has been burning through oil for 2 years now. It started with me having to get oil changes every 3 months, then 2, then 1, now I am forced to go get oil top offs every 2-3 weeks or the check oil light comes on and car drives very rough. I have been reaching out and opening cases with Hyundai and working with my local dealer for a year now and still nothing is being resolved. I need my engine replaced and they refuse, wanting me to jump through hoops and doing various tests only to tell me that even after I pay thousands for the tests, there’s no guarantee they can replace the engine. This is a known issue when you search online and thousands of people’s Hyundais are being affected. This vehicle is less than 10 years old it should not be having these issues. Hyundai is at fault for creating faulty vehicles and they are refusing to do anything about it.

Greetings, I went in for an oil change and was notified that my car airbags did not work and/or have not worked for an indeterminant time. The dealership ordered a part which still has not arrived. It’s been nearly 3 weeks, and I am unable to collect my car unless I pay $2,000. I’ve been paying out of pocket for a rental during that time, and as a college student have missed some classes. Currently, my car is still at the dealership unable to be driven safely. They say the seat sensor went bad and disabled my entire airbag system. There’s no telling how long my family and I have been at great risk of injury or death driving this car. I’m afraid to pay or pickup the vehicle as I’m unsure if it’s safe. I have been denied warranty coverage from corporate Hyundai and from the dealership. Im not sure how to proceed.