1992 ISUZU TROOPER Complaints

TL*THE CONTACT OWNS A 1992 ISUZU TROOPER. THE CONTACT NOTICED OIL LEAKING ONTO THE INTAKE MANIFOLD. HE NOTICED THE ISSUE WHEN HEAVY SMOKE APPEARED FROM THE ENGINE WHILE DRIVING APPROXIMATELY 55 MPH. THE DEALER STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 94V132000 (ENGINE AND ENGINE COOLING:ENGINE). THE MANUFACTURER INITIALLY STATED THAT THE VIN WAS NOT INCLUDED IN THE RECALL, BUT LATER STATED THAT THE VEHICLE HAD PREVIOUSLY BEEN REPAIRED ACCORDING TO THE RECALL. THE CURRENT MILEAGE WAS 192,031 AND FAILURE MILEAGE WAS APPROXIMATELY 188,000.

I HAD BEGUN HEARING A GRINDING SOUND COMING FROM THE BRAKES, KNEW IT WAS TIME TO CHANGE THE PADS. DROVE VEHICLE TO THE PARTS STORE TO OBTAIN NEW DISC BRAKE PADS TO PERFORM THE REPAIRS. WHILE DRIVING HOME FELT A SLIGHT GIVE IN THE BRAKE PEDAL WHEN COMING TO THE STOP, ALSO THERE WAS THE GRINDING PRESENT-PADS WERE PAD. WHEN I ARRIVED HOME AND BEGAN TO PERFORM REPAIRS I REMOVED THE LEFT REAR(DRIVERS SIDE) TIRE AND FOUND THAT THE COMPLETE BRAKE PAD HAD BEEN SHELLED OUT OF THE CALIPER AND THAT ALL THAT WAS STOPPING THE VEHICLE WAS THE CALIPER PISTON. I WOULDN'T REALLY BE TOO CONCERNED, ALTHOUGH I AM NOT SURE HOW IT WAS ABLE TO SHELL THE PAD COMPLETELY OUT(NOT JUST THE LINING BUT THE WHOLE PAD,BACKING AND ALL), BUT I HAVE A FRIEND WHO HAS A 94 TROOPER AND HE HAS EXPERIENCED THE SAME TROUBLE, JUST CURIOUS IF THIS DEFECT WITHIN THE TROOPER OF JUST AM ISOLATED COINCIDENCE. SEARCHED ALL YOUR DATA BASES(RECALLS,COMPLAINTS ETC..) AND DIDN'T SEE ANY SIMILAR COMPLAINTS,SO NOT REALLY SURE BUT THOUGHT IT MIGHT BEAR INVESTIGATION. *JB

WHILE DRIVING ALL ELECTRICAL LIGHT APPEARED ON THE DASHBOARD AND REMAINED ON. VEHICLE STALLED. CONSUMER DROVE THE VEHICLE TO THE DEALER FOR INSPECTION, AND MECHANIC STATED THAT THE VEHICLE HAD TO BE PLACED ON A DIAGNOSTIC MACHINE FOR RESULTS. CONSUMER INFORMED THE MECHANIC THAT THIS PROBLEM OCCURRED MORE THAN ONCE. MECHANIC ADVISED CONSUMER THAT THE PROBLEM COULD NOT BE DETERMINED AT THIS TIME.

STEERING LINKAGE IS LOOSE; CLICKS BACK AND FORTH WHEN DRIVEN ON A STRAIGHT ROAD.

WHILE DRIVING ON THE HIGHWAY ALL OF A SUDDEN SPEEDOMETER GOES TO ZERO. THIS IS AN INTERMITTENT PROBLEM WHICH CAUSES THE SPEEDOMETER AND ODOMETER TO STOP WORKING. CONTACTED THE DEALER. THERE IS A SPEED SENSORY THAT IS MOUNTED ON THE TRANSMISSION THAT FAILS. *AK

THE VEHICLE'S TAIL PIPE SEPARATED FROM THE MUFFLER'S DISCHARGE FLANGE WHICH IS TURNED 90 DEGREES UP, CAUSING THE HOT EHHAUST GASES TO HIT THE FLOOR DECK ON THE LEFT SIDE OF THE VEHICLE, JUST BEHIND THE BACK SEAT. THE RESULT WAS BURNING THE UNDERCOATING OFF, SETTING FIRE TO THE CARPET PADDING AND SETING FIRE TO A DUFFEL BAG CONTAININ CLOTHING THAT WAS PLACED OVER THAT LOCATION. THIS RESULTED IN FLAMES INSIDE THE VEHICLE, WHICH WERE PUT OUT BEFORE ANY OTHER DAMAGE COULD OCCUR. LOOKING AT NEWER TROOPER'S ISUZU CONTINUES TO USE THE SAME MUFFLER WITH NO HEAT SHIELD ABOVE THE FLANGE. IN A SIX MILE DRIVE THE THE DEALER WITH THE PIPE BROKEN ENOUGH, HEAT WAS GENERATED TO STARE THE MATTING SMOKING AGAIN. IN MY MIND THIS IS A SERIOUS DEFECT IN DESIGN THAT COULD CREATES A MAJOR FIRE HAZARD GIVEN THE FAILURE RATE OF EXHAUST COMPONENTS OVER TIME. *AK

PRESENT MILAGE GIVEN IS APPROXIMATE. IT HAS NOT BEEN DRIVEN IN MONTHS AND I DON'T REMEMBER THE READING. OUR VEHICLE WAS IN THE DEALER'S SHOP FOR WARRANTY WORK ON THE AIRCONDITIONER AND WATERPUMP. WITHOUT TELLING US, THEY PERFORMED AN OIL PUMP RELIEF VALVE REPLACEMENT AND CAM JOURNAL PLUG RETAINERS. UP TO THIS POINT, THE MOTOR HAD NEVER EXHIBITED ANY OILING PROBLEMS WHATEVER. PRIOR TO REPAIR COLD OIL PRES=100 PSI HOT=50 PSI. UPON RETURN OF THE VEHICLE, COLD OIL PRES=55 PSI, HOT=10 PSI. WITHIN A MONTH THE MOTOR WOULD NOT MAINTAIN PROPER OIL PRESSURE CAUSING EXCESSIVE VALVE NOISE DUE TO COLLAPSED HYDRAULIC ADJUSTERS. WARRANTY RETURN ON THE JOB WAS DECLINED BY THE DEALER. WE HAVE HAD TO DRIVE IT IN THIS CONDITION AND IT HAS GOTTEN STEADILY WORSE TO THE POINT THAT IT IS NOT DRIVEN AT ALL LEAST IT SUFFER TERMINAL FAILURE.

A VALVE IN THE NUMBER 1 CYLINDER OF THE V6 ENGINE IN THE TROOPER BURNT OUT AT APPROXIMATELY 60000 MILES.

TOOK VEHICLE FOR 90,000 CHECKUP & HAD TIMING CHAIN BELT REPLACED. LATER, NOTICED LEAKS UNDER VEHICLE. TOOK TO MECHANIC & WAS INFORMED ENGINE TWO HEAD GASKETS WERE LEAKING A LOT OF OIL. PROBLEM WAS NOT NOTICE AT TIME OF CHECK UP. *AK

ACCELERATOR PETAL STICKS TO FLOOR. RAPID ACCELERATION THEN OCCURS. PROBLEM WAS DEFECTIVE RUBBER BOOT AT THE END OF CABLE LINKAGE LOCATED IN THE ENGINE COMPARTMENT. RUBBER BOOT DETERIOATED AND WAS GRIPPING CENTER CABLE. THIS WOULD PREVENT THE GAS PETAL FROM RETURNING TO NORMAL OR IDLE POSITION. THIS OCCURED SEVERAL TIMES, ESPECIALLY WHEN THE ENGINE WAS COLD AND DRIVEN IMMEDIATELY. THE RUBBER BOOT WAS REMOVED AND CABLE CLEANED, PROBLEM FIXED.