1996 JEEP CHEROKEE Complaints

MY MOTHER-N-LAW PURCHASED A 1996 CHEROKEE, AND THE CHECK ENGINE LIGHT WAS ON . SO SHE TOOK IT TO THE EMISSION PLACE TO GET IT CHECKED AND IT FAILED THE TEST, SO SHE TOOK THE EMISSION PAPERS AND THE VEHICLE TO THE AUTO SHOP , AND THE MECHANIC STATED THAT THE CAR SHOULD HAVE NEVER BEEN SOLD TO HER , SO WHAT SHOULD SHE DO AT THIS POINT. *TR

1. EARLY THIS YEAR, JUST AFTER THE NEW YEAR HOLIDAY, '09, OUR '96 JEEP CHEROKEE (152K IN EXCELLENT CONDITION) BEGAN SHAKING OR WOBBLING VIOLENTLY AT SPEEDS BETWEEN 52 TO 56 MPH. ON INQUIRING IN A HANDFUL OF WEB SITES ON THE INTERNET ABOUT THIS PROBLEM I LEARNED THAT THIS IS AN EXTREMELY COMMON PROBLEM WITH A TREMENDOUS AMOUNT OF JEEP CHEROKEE OWNERS AND OWNERS OF OTHER JEEP MODELS IN A BROAD RANGE OF MANUFACTURE DATES BETWEEN '86 AND AS RECENT AS '05. ALSO LEARNED THAT THIS DANGEROUS CONDITION IS COMMONLY REFERRED TO AS THE "DEATH WOBBLE" OR "DEATH SHAKE". ADDITIONALLY, IN MY INTERNET RESEARCH, MANY JEEP OWNERS ATTEMPTING TO REMEDY THIS PROBLEM HAVE TAKEN THEIR VEHICLES TO PROFESSIONAL MECHANICS INCLUDING CHRYSLER-JEEP DEALER/SERVICE CENTERS TO HAVE THE PROBLEM RESOLVED, SPEND HUNDREDS, IN SOME CASES WELL OVER A THOUSAND $, ONLY TO HAVE THEIR VEHICLE RETURNED WITH NO IMPROVEMENT IN THE WOBBLE CONDITION. 2. WITH OUR JEEP, THIS WOBBLE HAS NOT SUBSIDED. IT HAPPENS ON EVERY OCCASION WHEN DRIVING ON THE HIGHWAYS WHILE MERGING INTO TRAFFIC AS WE ACCELERATE UP TO THE 55 MPH RANGE. UPON ACCELERATION, AT APPROXIMATELY 51 TO 52 MPH A VIBRATION BEGINS, THEN UPON ACCELERATING AT 53 TO 55 MPH THE VIBRATION BECOMES A VIOLENT WOBBLE TO THE EXTREME THAT WE HAVE HAD INSTANCES WHEN WE HAD TO DECELERATE DOWN TO APPROXIMATELY 35 MPH OR LESS IN ORDER TO REGAIN CONTROL WHILE ON THE HIGHWAY. IF THERE IS A SAVING GRACE OUT OF THIS PROBLEM, IT IS THAT WE CAN ACCELERATE OUT OF THE WOBBLE BY GETTING BEYOND 55 MPH AS QUICKLY AS POSSIBLE, BUT IN PHOENIX HIGHWAY DRIVING, THIS IS NOT ALWAYS A POSSIBILITY. THOUGH' NOT IN EVERY INSTANCE AS DURING ACCELERATION, THE SAME CONDITION EXISTS @ 55 DURING DECELERATION AS WE EXIT THE HI-WAY. 3. THUS FAR, AS WE'VE READ AND HEARD OF SO MANY JEEP OWNERS SPENDING HUNDREDS OF DOLLARS AT A PROF. AUTO REPAIR CENTER WITH NO RESOLUTION, THE POSSIBLE REMEDY, AND AVOIDING HIGHWAY DRIVING AS MUCH AS POSSIBLE. *TR

TL*THE CONTACT OWNS A 1996 JEEP CHEROKEE. WHILE DRIVING APPROXIMATELY 45 MPH AROUND A CURVE, THE CONTACT HEARD A POPPING SOUND FROM THE FRONT PASSENGER SIDE OF THE VEHICLE. HE EXPERIENCED DIFFICULTY MANEUVERING THE STEERING WHEEL WHILE MAKING A RIGHT TURN. IN ADDITION, THE TIRE SEPARATED FROM THE RIM. SUDDENLY, THE VEHICLE SWAYED OFF THE ROAD AND FLIPPED OVER. THE CONTACT WAS SEVERELY INJURED. THE AMBULANCE AND POLICE DEPARTMENT WERE CALLED TO THE SCENE AND A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO THE COLLISION CENTER AND WAS LABELED AS DESTROYED. THE CONTACT WAS CONCERNED OF THE SAFETY RISK INVOLVED. THE FAILURE AND CURRENT MILEAGES WERE 106,000.

BRAKE FLUID LINE CORROSION. IF IT CORRODES THROUGH, BRAKE FLUID TO LEAK. LOSE REAR BRAKES. NO FAILURE YET. WILL NEED TO REPLACE. *TR

THE STEERING GEAR TO MY 1996 JEEP CHEROKEE COMPLETELY CAME OFF THE FRAME RAIL WHILE MY WIFE WAS DRIVING. LUCKILY SHE WAS ONLY GOING ABOUT FIVE MILES PER HOUR. WHAT HAD HAPPEN IS THAT THE THREE BOLTS THAT HOLD THE STEERING GEAR TO THE FRAME RAIL BROKE OFF. *TR

96 JEEP CHEROKEE HEATER FAN SPEED CONTROL SWITCH FAILED. FOUND SWITCH AND WIRING CONNECTOR TO BE MELTED. REPLACEMENT UNIT FROM JUNK YARD HAD EXACT SAME DEFECT. APPEARS TO BE A COMMON PROBLEM. *TR

THIS COMPLAINT IS FOR A 1996 JEEP CHEROKEE SPORT. IT IS A 2-DOOR VEHICLE WITH 4 WHEEL DRIVE. THE ENGINE MOUNT STUDS SHEARED OFF BETWEEN THE ENGINE MOUNT AND THE ENGINE. THIS IS THE SECOND TIME THAT THIS HAS OCCURRED. THE FIRST INCIDENT OCCURRED WHILE THE VEHICLE WAS STILL UNDER WARRANTY AND THE DEALERSHIP CURED THE ISSUE. THE EVENT TOOK PLACE ON THE BAY BRIDGE BETWEEN OAKLAND, CA AND SAN FRANCISCO, CA. THE SECOND EVENT TOOK PLACE ON A BUSY STREET IN MEMPHIS TENNESSEE. I DROVE OVER AN AREA THAT LOOKED LIKE THE CITY HAD DONE SOME STREET WORK AND HAD FILLED THE AREA BACK IN WITH ASPHALT. THE DIVET FROM THIS WORK WAS INSIGNIFICANT AND CREATED A FEW INCH DIFFERENCE BETWEEN THE OLD STREET CONCRETE AND THE NEW ASPHALT FILL AND THERE WAS NO EDGES. THE REPAIR WORK WAS CURVED. MY SPEED WAS LESS THAN 5 MILES AN HOUR. THE BOLTS SHEERED OFF ON THE RIGHT ENGINE MOUNT AND THE ENGINE AND TRANSMISSION SHIFTED TO THE RIGHT. THIS VEHICLE IS HAS A MANUAL TRANSMISSION AND THE SHIFT CAUSED ME TO NOT BE ABLE TO SHIFT INTO 3RD - 5TH GEAR AND REVERSE. THE ENGINE IS STOCK AND NO AFTERMARKET ADD-ONS HAVE BEEN ADDED TO THE ENGINE. I FEEL THAT THESE INCIDENTS HAVE OCCURRED DUE TO POOR ENGINEERING OR INFERIOR PARTS WERE USED. *TR

AT A SLOW ROLL WHILE THE VEHICLE IS IN GEAR THE ENGINE WILL IDLE DOWN THEN DIE. IT RESTARTS IMMEDIATELY BUT WILL STALL AGAIN UNLESS MORE THROTTLE IS GIVEN. THE PROBLEM IS INTERMITTENT MAKING IT HARD TO PINPOINT THE EXACT CAUSE. *TR

1996 JEEP CHEROKEE STEERING GEAR FAILURE. CONSUMER STATES THAT THE STEERING GEAR FAILED WHILE MAKING A TURN. CONSUMER STATES THAT SHE HAD TO PAY OUT OF POCKET A SECOND TIME TO GET THIS SAME PROBLEM REPAIRED. *KB THE CONSUMER STATED THE PROBLEM SHE EXPERIENCED WAS LISTED AS A RECALL. *JB

TL*THE CONTACT OWNS A 1996 JEEP CHEROKEE. THE CONTACT STATED THAT THE STEERING GEAR BOX FAILED ON NUMEROUS OCCASIONS. IT WAS DISCOVERED THAT THE FRAME WAS CRACKED. THE MANUFACTURER STATED THAT ONLY ONE OF FOUR RECALLS WERE FOUND IN THEIR SYSTEM THAT WERE COMPARABLE TO THEIR RECALLS. WHILE TURNING THE VEHICLE AT AN UNKNOWN SPEED, THE CONTACT HEARD A LOUD POP. SHE HAS REPLACED THIS UNIT THREE TIMES, TOTALING $1,000. THE MANUFACTURER HAS NOT OFFERED ANY ASSISTANCE WITH THE REPAIR COSTS AND STATED THAT THEY DO NOT HONOR THE RECALL. THE NHTSA CAMPAIGN ID NUMBER IS 97V069000 (STEERING:GEAR BOX (OTHER THAN RACK AND PINION)). THE FAILURE MILEAGE WAS 103,000 AND CURRENT MILEAGE WAS 106,797. UPDATED 03/06/08. *LJ