1998 JEEP WRANGLER Complaints

CONSUMER WAS TRAVELING 60MPH ON HIGHWAY AND THERE WAS A LOUD BANG. THEN, VEHICLE VEERED TO LEFT. A CLICKING NOISE CAME ABOUT AFTER INCIDENT. DEALERSHIP WAS AWARE OF PROBLEM. *AK

DUE TO THE DESIGN OF SUSPENSION IT IS RUBBING AGAINST RADIATOR HOSE, PUNCTURING THE HOSE WHICH CAUSED A LEAK. CONSUMER HAS CONTACTED DEALER. PLEASE PROVIDE ANY FURTHER DETAILS. *AK

ORIGINAL BATTERY EQUIPMENT: WHEN ATTEMPTING TO START VEHICLE, BATTERY EXPLODED WHICH CRACKED THE BATTERY. BATTERY WAS REPLACED WITH ANOTHER TYPE. *AK

TREAD SEPARATED FROM TIRE AT HIGHWAY SPEED. THE EXACT PROBLEM THAT HAS CAUSED RE-CALL BY MANUFACTURER OF THIS TIRE IN DIFFERENT SIZE. THIS TIRE ONLY HAD APPROXIMATELY 25,000 MILES WHEN IT SEPARATED. *AK( DOT NUMBER: YD66A12247 TIRE SIZE: 30X9.50R15 )

AIRBAG LIGHT SPEEDOMETER AND RAM GAUGE FAIL DUE TO WATER ENTERED THE DASH BELOW THE WINDSHIELD. THE LEAK IS A COMMON SEAL FAILURE, WHIDSHIELD IS CAPABLE OF LAYING FLAT AND THE SEAL DOES NOT WORK, IT APPEARS TO CAUSE WATER DAMAGE.

IN TANK ELECTRIC FUEL PUMP GASKET FAILURE. I FILLED THE FUEL TANK ON A 1998 JEEP WRANGLER ON A SUNDAY NIGHT, THE VEHICLE SAT IN MY DRIVEWAY OVER NIGHT AND INTO THE FOLLOWING AFTERNOON. UPON RETURNING HOME FROM WORK I NOTICED A VERY STRONG ODOR OF GASOLINE, UPON FURTHER INVESTIGATION I FOUND THE FUEL RUNNING AT A STEAY STREAM ONTO MY DRIVEWAY FROM THE JEEP I HAD FILLED UP THE PREVIOUS EVENING. I ATTEMPTED TO LOCATE THE SOURCE OF THE LEAK AND STOP IT, HOWEVER I WAS UNABLE TO LOCATE THE SOURCE OF THE LEAK. I REMOVED THE FUEL TANK FROM THE VEHICLE AND FOUND THE FUEL TO BE LEAKING AROUND THE RETAINING RING FOR THE FUEL PUMP THAT IS INSTALLED IN THE FUEL TANK. I CHECKED THE SCREW ON RETAINING RING FOR TIGHTNESS AND FOUND IT TO BE SECURE AND SNUG ON THE TANK. THE RING IS A SCREW ON TYPE COLLAR MADE OF HARDENED PLASTIC, WHICH HOLDS THE FUEL PUMP IN THE TANK, THE FUEL PUMP SITS ON A FLAT RUBBER GASKET WHICH SITS ON THE LIP OF THE PLASTIC GAS TANK. UPON REMOVING THE RETAINING RING AND LIFTING THE FUEL PUMP OUT OF THE TANK I NOTICED THE GASKET WAS CRIMPED AND TORN ON THE TOP FLAT PORTION OF THE GASKET. I CONTACTED THE OWNER TO DISCUSS POSSIBLE CAUSES FOR THE GASKET TEAR, THE OWNER CLAIMED TO HAVE HAD THE VEHICLE IN FOR A FAULTY FUEL LEVEL INDICATOR A COUPLE MONTHS EARLIER. WHICH WAS INLINE WITH WHAT I HAD ASSUMED SEEING AS THE FUEL TANK HAD GREASE PENCIL WRITING ON TOP OF THE TANK INDICATING A TECHNICIANS INITIALS, DATE AND MILEAGE. THIS PROBABLY EXPLAINS THE TORN GASKET, HOWEVER UPON OBTAINING A NEW GASKET AND ATTEMPTING TO REINSTALL THE NEW GASKET IN THE TANK WITH THE FUEL PUMP I NOTICED THE REASON THE GASKET PROBABLY TORE, THE RETAINING RING HAS A TENDENCY TO GRAB THE GASKET AND TURN IT AS THE RING SEATS ITSELF. I WAS VERY CAREFUL AND CAUTIOUS WHILE INSTALLING THIS RING AND GASKET CONSIDERING I DID NOT HAVE ANOTHER GASKET AND I DID NOT WANT TO TEAR THIS REPLACEMENT PART. I NEED MORE ROOM TO FINISH. PLEASE EMAIL ME AT [email protected] THANKS. IM OUT OF ROOM.

CAR DIED SUDDENLY IN BUSY HWY RUSH-HOUR TRAFFIC,GAGE SHOWED OVER1/4 TANK GAS,ALMOST GOT REAR-ENDED W/SUDDEN LOSS OF POWER,GAS PEDAL NOT RESPONDING,LIGHTS STILL WORKED..TOW-TRUCK DRIVER SAID HE HAD SEEN LOTS OF G.JEEPCHEKEES DIED SUDDENLY W/GAS-GAUGE SHOWING GAS IN TANK&WHEN A BIT OF GAS WAS ADDED,THEY STARTED.WE ADDED QT.GAS AND OUR CAR STARTED,STILL SHOWING +1/4TANK.THIS SUDDEN DEATH COULD HAVE CAUSED SERIOUS ACCIDENT PLUS WE HAD TO LEAVE CAR AND EXIT IN MIDDLE OF VERY BUSY ROAD..MAYBE WRANGLERS HAVE SAME PROBLEM AS GR.CHEROKEE?THIS IS VERY SCARY AND WORRISOME..CAR WAS FINE AND NO WARNING BEFORE IT DIED. *AK

UNDER BODY FIRE ON VEHICLE AFTER DRIVING UNIMPROVED ROAD IN BRUSH. DEBRIS PACKED INTO SKID PLATE UNDER TRANSFER CASE AND CAUGHT FIRE. REDESIGN OF SKID PLATE IS NECESSARY TO PREVENT THE FIRE SITUATION. *AK

BRAKE ROTORS HAD TO BE RE-FINISHED AFTER ONLY 8000 MILES. I QUESTION THE QUALITY OF MATERIALS CHRYSLER IS USING. STEERING WHEEL RUBBING: STEERING COLUMN WOULD MAKE A RUBBING NOISE EVERY TIME IT WAS TURNED. DID THIS EVEN ON THE INITIAL TEST DRIVE NEW OFF THE LOT. THEY SAID IT WAS A SIMPLE LUBRICATION ISSUE. 2 WEEKS LATER, THE NOISE WAS BACK. I BROUGHT IT IN A TOTAL OF 6 TIMES BEFORE THE PROBLEM WAS FINALLY RESOLVED, APPARENTLY WITH SOME NEW SUPER SLICK POLYMER AND ONLY AFTER I PERSONALLY CALLED THE FACTORY TO GET ADVICE. OTHER ISSUES: DRIVER'S SEAT CREAKS LIKE AN OLD TRACTOR. THEY COULDN'T FIX IT. I HAD THE PROBLEM WITH THE GAUGES ON MY DASH GOING OFF. THEY KNEW WHAT THAT WAS AND DIXED IT. EXHAUST MANIFOLD WENT AFTER ONLY 12,000 MILES (MORE SUBSTANDARD PARTS USED BY CHRYSLER). THIS IS WHY I HESITATE TO BUY AMERICAN.

DEFECTIVE ELECTRICAL CONNECTOR CAUSED ALL THE GAUGES TO FAIL AND AIR BAGS TO SHUT DOWN. *AK *ML