1999 JEEP WRANGLER Complaints

1999 JEEP WRANGLER WITH GROUND WIRE PROBLEMS **ANSWERED BY RIC WILLARD** CC THE RECALL WAS 99V117000. THE VEHICLE WAS TAKEN TO THE DEALER FOR THE RECALL. AFTER THE REPAIRS THE PROBLEM PERSISTED. THE CONSUMER REACHED BEHIND THE CLUSTER AND WHEN HE PUSHED ON ONE OF THE PLUGS THEY MOVED ABOUT AN EIGHTH OF AN INCH. THE CONSUMER THEN HEARD THE LATCHED SNAP INTO POSITION AND HE HASN'T HAD A PROBLEM SINCE. THE HEATER ALSO HAD A PROBLEM THAT THE CONSUMER THOUGHT WOULD BE CORRECTED BY RECALL BUT WAS NOT. THE SYSTEM CHANGES THE LOCATION OF THE AIR FLOW ON IT'S OWN. *NM

ALL GAUGES STOP READING AND DROP TO ZERO AND THE AIRBAG WARNING LIGHT COMES ON. HAPPENS FREQUENTLY WHEN GOING DOWNHILL AT SPEED OR HITTING A BUMP. *JB

I HAVE HAD THE EXHAUST MANIFOLD FAIL IN MY 99 TJ TWICE NOW. THE FACTORY ORIGINAL CRACKED AT ABOUT 39,000 MILES AND THE "NEW AND IMPROVED" OEM REPLACEMENT LASTED 11 MONTHS (OR 9,450 MILES). THIS IS GETTING VERY EXPENSIVE...*JB

DT*: THE CONTACT STATED THE VEHICLE'S INSTRUMENT PANEL GAUGES DIMMED COMPLETELY AFTER ILLUMINATING INTERMITTENTLY. THE DEFROSTER BLOWER STOPPED FUNCTIONING AS WELL. THERE WAS A NHTSA RECALL, # 99V117000, REGARDING THE OTHER (SCREWS). THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN.*AK

DT*: THE CONTACT STATED WHILE DRIVING 65 MPH SMOKE ERUPTED FROM THE STEERING COLUMN. THE VEHICLE WAS TAKEN TO THE DEALER WHO DETERMINED THE WIRING HARNESS NEEDED TO BE REPLACED.

DT*: THE CONTACT STATED THE VEHICLE ACCELERATED ON ITS OWN. IT WOULD ACCELERATE AT ANYTIME, WHETHER IT WAS IN IDLE OR IN MOTION. THE VEHICLE HAS BEEN OBSERVED BY THE DEALER HOWEVER THEY HAVE NOT BEEN ABLE TO CORRECT THE PROBLEM. THIS INCIDENT OCCURRED ABOUT 8 TIMES ON AVERAGE A DAY.

AT ANY SPEED MY RED AIR BAG LIGHT COMES ON AND KNOCKS OUT THE WHOLE INSTRUMENT PANEL. THIS IS THE 3RD TIME THIS HAS HAPPENED. PREVIOUS TWO TIMES THE JEEP WRANGLER 1999 WAS TAKEN TO DEALER AND APPARENTLY 'FIXED.' *NM

1ST ISSUE: THE DASH GAUGES WILL GO OFF AND ON INTERMITTENTLY. I HAVE FOUGHT WITH THIS PROBLEM FOR YEARS NOW. THE DEALER OF COURSE DOESN'T KNOW WHAT I'M TALKING ABOUT. NEVER HEARD OF IT. I HAVE COMPLETELY REMOVED THE DASH LOOKING FOR PROBLEMS. BAD GROUNDS? I CAN'T TELL WHERE. I SUSPECT THE PLUGS THE CLUSTER SLIPS INTO. I'VE TRIED TO PULL THE MOUNTS CLOSER FOR A BETTER CONNECTION. IT SEAMED TO WORK FOR A WHILE. THEN IT COMES BACK. A GOOD SOUND BEATING ON THE DASH BRINGS THEM BACK ON. AMAZING WHAT THAT PLASTIC WILL TAKE. ALL THIS STARTED AFTER THE WARRANTY EXPIRED. I REFUSE TO TAKE IT IN AND POUR MONEY AT IT TILL THEY FIGURE IT OUT. ALL I WANT IS TO KNOW HOW TO FIX THE GAUGES. I'M ABOUT READY TO CUT THE WIRES AND SOLDER THEM DIRECTLY ON. 2ND ISSUE: I BEGAN SMELLING PLASTIC BURNING OR SOMETHING. LATER THE HEATER FAN QUIT WORKING. AFTER SOME READING OF THE SERVICE MANUAL, I CHECKED A LOT OF PARTS AND FOUND THE CONTROL/SELECTOR SWITCH UNIT HEATED UP AND PARTIALLY MELTED THE WIRE PLUGGING INTO IT AS WELL AS BURNT INSIDE THE UNIT. BOUGHT ANOTHER AND REPLACED IT. WORKS GREAT NOW. ALL THE FAN POSITIONS WORK AGAIN. *JB

DT*: THE CONTACT STATED WHILE DRIVING OVER BUMPS THE ODOMETER AND SPEEDOMETER FAIL. THE AIRBAG WARNING LIGHT ILLUMINATES WHEN THE NEEDLES DROP. THE PROBLEMS OCCUR AT VARIOUS SPEEDS. UPON INSPECTION THE DEALERSHIP DETERMINED THE WIRING HARNESS NEEDS TO BE REPLACED. THERE IS A NHTSA RECALL, # 99V117000, REGARDING THE INSTRUMENT PANEL WIRING. THE VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL; HOWEVER IT IS NOT INCLUDED IN THE RECALL DUE TO THE VIN. *AK

THE GAUGES ON MY 1999 JEEP WRANGLER WORK ONLY OCCASIONALLY. I FOUND NHTSA RECALL NO. 99V117000 ON YOU WEB SITE STATING THERE WAS A RECALL ON THIS. I CONTACTED DAIMLER CHRYSLER AT 1-800-992-1997 AND THEY SAID THERE WAS NOTHING THEY COULD DO FOR ME AS MY VEHICLE WAS NOT AFFECTED. MY VIN [XXX]. WHAT GIVES?. *JB UPDATED 07/17/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)