1998 JEEP WRANGLER Complaints

AIR-CONDITIONING COMPRESSOR FAILURE AIR-CONDITIONING EVAPORATOR COIL FAILURE AIR-CONDITIONING REFRIGERANT LEAKS AND ODORS

CONSUMER STATED THE FUEL TANK HAD A CRACKED WHICH CAUSED FLUID TO LEAK OUT. THE DEALER WAS NOTIFIED. *AK THE FUEL TANK HAD LEAKED SINCE THE OWNER PURCHASED THE VEHICLE AT 39K MILES. THE FUEL TANK OVERFLOWED WHEN FILLED IN HOT WEATHER. BOTH THE FUEL TANK NUT REPLACEMENT TANK WERE DIFFICULT TO OBTAIN DUE TO SHORTAGE. THE TACHOMETER AND SPEEDOMETER HAD BECOME INOPERATIVE. THE SERVICE DEALER FOUND A POOR CONNECTION BEHIND THE CLUSTER. THE THROTTLE SENSOR DID NOT HAVE A GOOD SEAL IN WHICH MOISTURE HAD GOTTEN INTO IT. THE FUEL TANK CORRODED BADLY AND THE NEW TANK NUT WAS USELESS. THE CONSUMER REPLACED THE FUEL PUMP, FUEL FILTER, AND THE GAS TANK. THE CONSUMER REQUESTED REIMBURSEMENT. *SCC ALSO THE WATER PUMP SERPENTINE BELT, AND BATTERY WERE REPLACED. *JB

PERIODICALLY THE DASHBOARD GAUGES CUT OUT AND DO NOT FUNCTION. AT THE SAME TIME THE AIR BAG LIGHT GOES ON. PER DISCUSSION WITH A DEALER, IF THE AIRBAG LIGHT IS ON THE AIRBAG WILL NOT PROPERLY FUNCTION.*AK

1998 JEEP WRANGLER 4.0L, EXHAUST MANIFOLD CRACK AT 30,000 MILES. JEEP/CHRYSLER REFUSED TO FIX, STATING ONLY CATALYTIC CONVERTER COVERED UNDER WARRANTY. CRACK OCCURRED IN A WELD JOINING THE TWO PIPE, ALMOST 3/4 OF THE WAY AROUND THE PIPE, CAUSING COSIDERABLE NOISE, AND LOSS OF POWER. GUAGES FAIL PERIODICALLY, BUT COME BACK ON THERE OWN, AFTER A FEW MINUTES. AIR CONDITIONER DRAINS ONTO FLOOR INSIDE VEHICLE ON LONG DRIVES AND CAN EVEN SHORT OUT THE RADIO. THE STEERING COLUMN ALSO SQEALS LIKE AN OLD DOOR WHEN ITS COLD OUTSIDE.*AK

FAULTY FUEL LEVEL INDICATOR. I SUSPECT A BAD FUEL SENDING UNIT. FUEL GAUGE SHOWS APPROXIMATELY 1/4 TANK OF GAS LEFT, HOWEVER THE CAR WILL ACTUALLY BE COMPLETELY OUT OF GAS.*AK

AFTER PARKING OUR 1998 WRANGLER AT THE HOSPITAL TO VISIT MY MOTHER MY CAR WAS REPORTED ON FIRE. THE FIREMEN STATED AND WROTE A REPORT IT WAS AN ELECTRICAL FIRE. THE WRANGLER IS TOTALED AND THE INSURANCE COMPANY WILL NOT PAY THE VEHICLE OFF. WE ARE SHORT $3,000 OF THE PAY OFF. MY IMMEDIATE CONCERN IS I WAS GLAD I WAS NOT DRIVING AT THE TIME OF THE FIRE AND DID THIS HAPPEN TO OTHER OWNERS OF A WRANGLER. THIS CAR IS ONLY GOING INTO 5 YEARS OLD AND HAS HAD THE REAR END REPLACED AT OUR EXPENSE AND THE GAUGES GO ON AND OFF AND THIS WAS FIXED ONCE. WHAT CAUSED THIS ELECTRICAL FIRE? I WANT JEEP TO RESPOND TO WHY THIS HAPPENED. *TT

INSTRUMENT PANEL GAUGES AND LIGHTS GO OFF INTERMITTENTLY WHEN USING TURN SIGNAL. BLOWER POWER FAILED ALTOGETHER (MECHANIC FOUND BURNED OUT WIRING HARNESS UNDER DASHBOARD.) AIR CONDITIONER FAILED --EVAPORATOR AND COMPRESSOR. WATER LEAKS ON PASSENGER SIDE FROM FRONT WINDSHIELD (WINDSHIELD WAS REPLACED TWICE AT DEALER BUT FAILED TO FIX PROBLEM.) REAR CENTER BREAK LIGHT WIRE FAILED. HOOD LATCH BROKE OFF. *JB

A CRACKED EXHAUST HEADER CAUSED EXHAUST FUMES TO ENTER THE PASSENGER COMPARTMENT OF THE VEHICLE. *NLM

I HAVE HAD NUMEROUS PROBLEMS WITH MY JEEP WRANGLER 1998. THIS IS A PARTIAL LIST I SENT TO CHRYSLER: I BOUGHT MY JEEP WITH JUST 3600 MILES ON IT FROM A DEALER IN 1999. FROM DAY ONE I STARTED EXPERIENCING PROBLEMS. MANY OF THEM I RETURNED TO THE SERVICE DEPARTMENT. SOME THEY WERE ABLE TO FIX, OTHERS, AFTER MANY RETURN TRIPS, THEY WERE 'UNABLE TO DUPLICATE THE PROBLEM'. 1. GAUGES WOULD STOP WORKING WHILE DRIVING - I BROUGHT THE VEHICLE IN 5 TIMES BEFORE THEY WERE ABLE TO DUPLICATE AND FINALLY FIX THE PROBLEM. 2. THIS WAS ALSO TRUE OF THE BLINKERS THAT NOT ALWAYS WORKED - OR WORKED ALL AT THE SAME TIME. 3. MY HAZARDS STILL DO NOT WORK EVERY TIME. 4. THE AIR CONDITIONER GOES OUT WHEN DRIVING,VERY UNCOMFORTABLE WHEN IT IS HOT AND RAINING. 5. THE SOUND BAR HAS NEVER WORKED PROPERLY - FIRST IT WOULD ONLY COME IN SOME TIMES - NOW NEVER. 6. HEADERS ARE CRACKED - BAD. THEY HAVE BEEN WELDED SEVERAL TIMES. WHEN I WENT TO HAVE THEM WELDED IT WAS FOUND THEY WERE WELDED BEFORE MY PURCHASE - AT 3600 MIL! THEY ARE STILL CRACKED, WELDING DOES NOT HOLD. I CAN NOT GET ANYONE TO REPLACE THEM BECAUSE EVEN EXHAUST SPECIALISTS SAY IT IS TOO CUMBERSOME. THE DEALER CHARGES WAY MORE THAN I HAVE CONSIDERING THE NUMBER OF REPAIRS AND THE PRICE OF GAS - AT 12 MPG. 7. DRIVERS SEAT BELT LOCKS TIGHTLY WITH ANY AMOUNT OF PRESSURE ON THE BRAKES - IT HAS NOW GOTTEN TO THE POINT IT LOCKS JUST WHILE DRIVING. 8. WINDOWS - THE ZIPPERS BROKE ALMOST IMMEDIATELY - I PAID ALOT TO HAVE THESE REPLACED. THE BACK WINDOW NOW HAS A CUT IN IT AND IS VERY DIFFICULT TO SEE THROUGH. 9. THE TOP HAS NEVER QUITE FIT RIGHT; IT HAS ALWAYS LEAKED AND BEEN EXTREMELY NOISY - MORE SO THAN ANYONE ELSE'S THAT I KNOW. IT HAS ALSO COME APART AT THE SEAMS. THE DEALERSHIP HAS NOT BEEN OF ANY HELP. THEY WANTED TO CHARGE OUTRAGEOUS AMOUNTS JUST FOR DIAGNOSTICS, EVEN WHEN I HAD THE BEST WARRANTY. I'VE ALSO HAD PROBLEMS WITH THE DOOR MOLDING COMING OUT IMMEDIATELY, GRINDING IN THE STEERING WHEEL, GRINDING WHILE TRYING TO PUT IT IN REVERSE AND MORE. *NLM

EXHAUST HEADER CRACKED & BROKE IN TWO WILL NOT PASS STATE SAFETY INSPECTION OR EMISSION