2025 KIA CARNIVAL Complaints

12V battery drains if the car is left unused for more than 3-4 days. Car needs to be jumped to start it up again. The issue occurred in August and I jumped it first time. It started happening again September and had a service appointment with Kia. They hard reset the software but the issue occured again every time I left the car unused for more than 3-4 days.

The car fails to accelerate sporadically, occurred multiple times in a 2 day period. First time was getting on an on ramp to the highway, I got up to 55 MPH then couldn’t accelerate anymore even with my foot on the gas. I dropped down to 32 MPH and had to merge onto the highway at that speed. I had a semi fly up behind me and swerve around me because I was going so slow, I’m thankful there wasn’t an accident, I had 6 passengers and it could’ve been a very bad situation. It finally gave some acceleration but even then later gave out when driving on the highway. I went from 70 to 53 MPH before I could accelerate again. Other times it happens I was on a road going 35 MPH and it wouldn’t accelerate anymore, dropped down to 26 MPH. I can only coast and pressing the gas just revs the engine, going up to 4000 RPM. It only happens when already driving, not from a dead stop (at least so far). This has happened in all 3 driving modes, Eco (happened the most in this mode), Sport and Smart mode. This has to be addressed and fixed, I’m nervous to drive the car or have my family ride in it. There were no warning lights showing and the diagnostics are stating normal. I’m taking it to a dealership today. The one detail I noticed that happened consistently was the car seemed to be stuck in a mode not being able to determine if it’s in charging, electric or hybrid mode and tries to combine them. There’s a graphic on the display that shows the power either coming from the battery to the front wheels OR from the front wheels to the battery, never arrows both ways. When this happened, there were arrows going both ways from the batteries to the front wheels and from the front wheels to the battery at the same time. Finally when I could accelerate again, the arrows were going one direction. Please report this and make Kia fix this terrible safety issue.

When the vehicle is idling, the battery refuses to charge, therefore, the car suddenly dies and makes it unsafe to pull over and dyes while driving, very dangerous and transmission doesn’t shift properly.

I was driving about 6:30ish in the morning and my whole dashboard went black and my head lights turned off couple seconds later it came back on while i am driving. I will be calling the dealership to see what can be checked.

The car gave alert of "hybrid system failure" and showed a picture of a drained battery. After about 20 seconds, we were unable to drive over 30 mph. After about 30 more seconds, the car shut off and had to be jumped to work again. Luckily we were pulling over into a parking lot when it shut off, but were blocking the entrance. This is the 4th time this has happened in a couple of months since we bought the car.

The contact owns a 2025 Kia Carnival. The contact stated that on several occasions the vehicle failed to start due to the 24-Volt battery failure. The vehicle was jump-started and operated normally, but the failure reoccurred. Additionally, the contact indicated that the emergency key failed to open the doors of the vehicle after the battery malfunction. A locksmith was called to the scene to open the doors. The cause of the failures was not yet determined. The local dealer and manufacturer were notified of the failures. The failure mileage was 600.

The 2025 Kia Carnivals have a safety systems that prompts the driver to, "Take and coffee break". The system cannot be turned off and is extremely distracting. The system prompts the driver even if the adaptive cruise control is turned off. I called Kia and they told me to take the vehicle to the dealer. The dealer was not able to turn the computer nag off either. The car makes a noise and the prompt flashes at the driver every few miles. This happens when traveling at highway speeds and in traffic. The driver has to look down from the road to see what the noise is and is greeted with the infuriating "Take a coffee break" message. It is extremely distracting and annoying to the point it induces road rage. The NTSB needs to investigate this system and require manufacturers to either allow owners to turn it off or do not include this feature in their vehicles. The next question is irrelevant because this happens on almost every highway drive. It is not a one time occurrence.

Vehicle Malfunction Report What component or system failed or malfunctioned, and is it available for inspection upon request? The vehicle's transmission and/or gear shifter system has failed to function as intended. When the gear shifter is set to "Reverse," the transmission has repeatedly shifted into "Drive" or "Neutral" instead. Concurrently, the vehicle's electronic backup camera system and audible sensor beep activate, indicating that the vehicle believes it is in reverse. The van is available for inspection upon request. How was your safety or the safety of others put at risk? My safety and the safety of others were put at risk on multiple occasions due to the vehicle shifting into the wrong gear. This has caused the van to unexpectedly lurch forward when I intended to back up. I have nearly collided with other parked vehicles and my garage door between 10 to 20 times. Has the problem been reproduced or confirmed by a dealer or independent service center? The problem has not yet been reproduced or confirmed by a dealer or service center, but it has occurred on numerous occasions and is a confirmed issue by the driver. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? To date, the vehicle and its components have not been inspected by the manufacturer, police, or insurance representatives. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? There were no warning lamps or messages displayed prior to the problem occurring. The primary symptoms of the malfunction are the vehicle shifting into "Drive" or "Neutral" instead of "Reverse," while the backup camera and an audible beep are active. These symptoms began almost immediately after the vehicle was purchased.

While driving, the vehicle intermittently fails to accelerate when the accelerator is pressed; it will only coast at about 30 mph. At the same time, the hybrid battery indicator shows a low charge that continues to drop rather than recharge. The “Check Hybrid System – Stop Safely” warning also comes on. This recurring loss of propulsion creates a significant safety risk because we cannot reach or maintain normal traffic speeds. We have taken the van to our local Kia dealership about this situation on two separate occasions; the first time it was reported no faults found bc they couldn’t replicate the problem. I was told there was a recall and it should fix the problem. The second time I was able to capture video of it happening multiple times to show the service technician. I was told it was something about the air intake system not being properly positioned. Now that the car is out of the shop, about two weeks later I’m experiencing issues where I’m unable to switch gears properly on multiple occasions as well. It’s been one thing after the next since I’ve gotten this vehicle.

The hybrid car intermittently switches into EV mode after coming to a complete stop (e.g., at a traffic signal or after briefly stopping to pick up my child). When this happens, the vehicle does not accelerate properly once back on the road and feels stuck in EV mode, unable to accelerate beyond ~45 mph. This creates a safety concern when merging or crossing intersections.