2023 KIA EV6 Complaints

While driving in the evening with an estimated 180 miles range remaining a "pop" noise was heard. About a minute later a vague warning message the car had not displayed before appeared. We tried to make it home but concerning (and still vague) messages kept appearing quite rapidly. The car slowed down and came to a halt and died in an intersection. This all happened within five minutes of hearing the "pop" noise. Once the vehicle died the head and taillights went off and the car would not allow the emergency flasher lights to be turned on. It would not allow it to be put into neutral to allow it to be moved out of the intersection. It also would not allow any of its doors to be locked (manually or otherwise) except for the driver's door until the vehicle was repaired one week later. We found out following that the 12 volt battery had not charged due to a DC/DC converter input voltage sensor fault related to ICCU failure. The popping noise had been a fuse. As the applicable ICCU parts were replaced by the dealership I doubt they will be available for inspection. The safety of my family was put at risk by: - the car's warnings not clearly explaining what the issue was. - the car not giving clear indication of how quickly it would die. - the car dying in a busy intersection. - the car being unable to be shifted to neutral. - the car's warning flashers not being operational when it died in the middle of the intersection at night. - us being left without warmth in outside temperatures around 6 degrees Fahrenheit. The ICCU problem was confirmed by the dealership we purchased the vehicle from. The vehicle was only inspected by the dealership acting on behalf of Kia.

With no warning except a pop, the vehicle iccu will fail and leave you stranded, very dangerous if you are driving on the parkway

The ICCU has failed twice in my EV6. It is a fairly common issue for this vehicle. I had the ICCU replaced after the first failure, but it has failed again. There was no indication something was wrong with the car until I heard a pop and then the dash indicated "Check Electrical System"

Heating system fails to generate sufficient heat to defrost windshield or prevent ice buildup in the winter, also impacts the temperature of the cabin. No error codes are generated but it appears the PTC heater is not functioning as expected.

10:00 am January 28th AFTER A DRIVE OF APPROXIMATELY 20 MILES TO THE GROCERY STORE, we parked the 2023 Kia EV6 Wind,in the parking area, then entered the store to shop. On returning, we placed the groceries in the trunk and proceeded to leave for home. The push button "START" provoked a notice on the dash that the 12 volt battery was "LOW". The drive circuits would not enable. Prior to going in the store the dash information reported the main battery was at 62%, all else is normal. We are now stuck 20 miles from home. We called KIA roadside assistance, via a cell phone. The Kia site told us it did not recognize the VIN number we had entered three separate times.. It would not proceed down the logic tree for us to be assisted by their service. We called :AAA"they sent a service truck with a jumper battery which allow us to get a small charge on the 12 volt system, enough to get us home. Immediately upon arriving I opened the hood, retrieved my "Fluke DVM" to measure battery voltage. 6.2 volts was the reading. The 12 volt battery was not charged by the voltage regulation system in our car. Fortunately, we were dressed well, being the temperature outdoors was 14*F at the time and we had access to the grocery store for safety. Yet still a major inconvenience due to breakdown. Later, I disconnected the negative battery terminal, then connected the 12 volt AGM battery charger I have purchased for home use. The battery was charged to full overnight to 13.2 volts. I removed the charger cables, then left the battery set for 12 hours disconnected from the vehicle. The voltage dropped to 12.6 volts dc, indicating a healthy battery. This morning January 29th, I called the Kia dealership to explain our problem, the scheduler has acknowledged a possible bad charge control unit, but told me if it was not a control unit problem, I would pay a fee of $135 dollars for the troubleshooting, even though the vehicle has approximately 33,000 miles. Schedule Feb 4th

ICCU failure. Was confirmed by shop car was towed to over phone. But no mention of it on invoice as of yet. I was at traffic light when I heard a pop and when I tried to go, got the warning message to pullover and the turtle icon. I made it to a towable spot. Super fortunate all in all. Can’t imagine if on highway in weather. No hints of failure before. Car was recently purchased month prior. I took it in for recall within first week, was told all good, software was updated. I kept between 20%-80% at all times, charged lvl2 at work daily and lvl1 at home sometimes. Had cheap voltage meter in car and was reading fine. Hope to get my car back soon.

While driving my Kia EV6 in the middle of a snowstorm, the vehicle experienced a sudden and severe power failure. I heard a loud popping sound from the rear of the cabin, after which the vehicle immediately entered reduced-power (limp) mode. Within approximately one minute, the vehicle shut down entirely and lost all propulsion and mobility. I was able to move the vehicle to a safe location only because I was not in traffic or on the highway at the time of the failure. Had this occurred at highway speeds or in active traffic, it would likely have resulted in a dangerous situation with a high risk of collision, especially given the severe winter weather, low visibility, and slippery road conditions. The vehicle has approximately 21,000 miles. This is the second failure of the Integrated Charging Control Unit (ICCU) in this vehicle. The vehicle was inspected by an authorized Kia dealer, who has officially diagnosed the failure as a failed ICCU and associated fuse. There were no warning lights or messages prior to the failure. The first indication of a problem was the popping sound, immediately followed by limp mode and then a complete shutdown without further warning. The vehicle is available for inspection upon request. The repeat nature of this failure, lack of advance warning, and sudden loss of propulsion represent a serious safety defect.

While changing lanes on a freeway, the car passed through a narrow strip of slush from recent snowfall. The car immediately disabled the motors, preventing acceleration and regenerative braking for nearly 50 seconds. There were no warning lights, sounds, or messages displayed on the car's gauge cluster display, either for the initial loss of propulsion or for the restoration of propulsion. This caused a loss of traction when the car eventually passed through a patch of packed snow and ice.

It seems as if the ICCU on my car failed. It will not charge and went into limp mode in order for me to drive it home a few blocks.

A small amount of snow / ice is sufficient to prevent the windshield wipers from returning all the way to the original starting position low on the windshield. For some reason this prevents them from functioning entirely - they just get stuck in a loop trying to go all the way down. I am able to lift them up manually but they won't do so under wiper motor power / while driving. I have a video that clearly shows the failure mechanics that this system won't allow me to upload.