2024 KIA EV6 Complaints

While operating my 2024 Kia EV6, the vehicle began displaying repeated warnings related to the power system and 12-volt battery. The instrument cluster first showed a “Power limited” message, followed shortly by a “Stop vehicle and check power supply” warning. At the same time, the vehicle indicated that the 12-volt battery was low, despite the high-voltage traction battery being at or near full charge. Shortly thereafter, the 12-volt battery became fully depleted, resulting in a complete loss of low-voltage electrical power. I was unable to electronically unlock the doors, and the vehicle could not be started or shifted into gear. The vehicle became immobilized and inoperable, requiring towing. This failure occurred without warning and created a safety concern, as loss of power could potentially occur while driving or leave occupants stranded and unable to access the vehicle. The vehicle had previously been serviced at a Kia dealership for known power system concerns related to the Integrated Charging Control Unit (ICCU). During that visit, the dealership applied a firmware update only and did not replace the ICCU hardware. The current failure occurred after that firmware update, suggesting the issue was not resolved. This incident represents a loss of motive power and loss of vehicle electrical systems, which could present a serious safety risk if it occurs while the vehicle is in motion or in unsafe environments. The inability to unlock doors or start the vehicle due to complete 12-volt battery depletion is particularly concerning. When roadside assistance arrived to tow the vehicle to the dealership, the vehicle’s 12-volt battery was completely depleted, preventing normal recovery procedures. A portable jump starter was temporarily connected, but the vehicle would not remain powered on long enough to complete the steps required to place the vehicle into neutral or tow mode.

on April 7, 2025, our 2024 Kia EV6 was towed away from our driveway after an ICCU failure the day before. The tow truck driver attempted to jumpstart it with a battery eliminator and he could not. He could not get it shifted into neutral and had to pull it up on the ramp with the back tires stationary, sliding up the ramp. They had it until we got it back just before April 22, and then on that day, it was towed away again because of a 12 V battery failure. If this first computer failure had happened while we were on the highway, we would have lost power in traffic. We were told that the replacement ICCU part which we received was a different model number than the first one, but I have heard on Facebook discussion groups that it is identical and just as likely to have a failure. Our Kia EV6 is a 2024 model, an extended battery version Wind AWD. Both the initial incident on April 6 and the second incident on April 21 happened just outside my garage after just backing the car out of the garage going maybe 5 mph. For some reason, the system will not let me upload a video of the first time it was towed up the ramp, only the second time when it was taken away for the 12 V battery failure, but it also would not drive in that condition. I include parts of texts with the Kia service center. It took them one week to be convinced that it was, indeed, the ICCU.

Incident took place 1/31/26. I was pulling into my driveway at approximately 5 mph. Normally, as I approach the wooden driveway gate, sensors would begin to beep and I would be prompted to stop.The car normally would stop itself if a collision was imminent. This did not take place. Instead, the car picked up speed, smashed through the gate proceeded up the driveway, smashed through the garage door and the rear wall of the garage. I was alone and uninjured, but the structure was yellow tagged and there was severe damage to the contents. Airbags were not deployed. The car was towed to Caliber body shop in Santa Monica for repairs to the body. When this has been completed it will be taken to Kia of Santa Monica for analysis of the black box and braking system.

The car his a module called the iccu that regulates the high voltage battery, battery range goes down, the iccu has been replaced with the vehicle only having 8k miles on the odometer

Driving with my wife and [XXX] child, there was a pop sound from under the car, and the car suddenly showed multiple faults, including "Check electric vehicle system”, which cleared on their own. I parked and turned the car off and on again and the faults reappeared. I started driving home, and during the drive it showed "Stop vehicle and check power supply" and audibly alarmed. As I was only half a mile from my house on local quiet roads, I made it. A few minutes later, I tried to turn on the car and some displays were off, there was no drive power, the steering wheel did not turn, the door locks were flakey, and I wasn't able to tell if I had shifted into Park or if the parking brake was engaged. When the tow truck arrived, the car was completely unresponsive and there was no way to release the parking brake or shift the car in neutral, so the car was dragged across the pavement and onto the tow truck. The failure was quick and comprehensive and could have easily caused injury. There are many highways near me with fast, busy traffic and either no emergency shoulder or a very narrow one. If my car tells me that I need to stop the vehicle, that can create a very dangerous choice between stopping somewhere less safe quickly or risking the car being completely disabled while in the travel lane while I look for a safer spot. Loss of cabin heat can easily become dangerous very quickly in the winter. Many drivers may not even understand the urgency of the warning until the car starts failing to drive. The car is at a Kia dealership for repair who confirmed an ICCU failure. See related NHTSA recall no 24V-867 and others. ICCU failures are endemic to Kia and Hyundai EVs. ICCU failures are widely discussed on many internet forums and seem much more common than the 1% failure rate claimed by Hyundai/Kia. FYI, an interesting root cause analysis was shared on a German EV forum: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Vehicle ICCU blew up while driving, causing drive train system shut down and limited speed to 10 mph.

About 10 miles from home a warning saying to check the electrical system came on the dash and the car would not go faster than about 25 miles per hour. We had to limp back home, turning the car off every few miles as it would start aggressively beeping to turn off the car. After getting it towed to the dealership, it took them several weeks to determine it was the ICCU and fuse, and I did not take possession of my car back for nearly 8 weeks. While this was under warranty, I am still currently waiting for reimbursement on the tow to the dealer and the rental I had to get for 3 days before the dealer could get me a loaner.

The engine/power of my electric EV6 died. It went into limp home mode (speed limited) briefly before dying completely. I restarted it and was able to get it to a parking spot before it died again, but I was just lucky I was on a surface street with parking. Dealership confirmed it was an ICCU failure

Whike driving down the street, the car lost power despite being charged to 95%. An alert went off on screen stating an electric system issue and then stopped in the middle of the road. Between the warning showing up, and car losing full power was less than a minute. There was no opportunity to pull over safely and the car was stuck in the middle of the street until a tow truck was able to come. Police had to direct traffic as it was blocking the only lane on a busy street.

ICCU failure while driving. Vehicle defaulted into limp-home mode and required towing to a dealership once it fully died. The issue was confirmed to be the ICCU and the part was replaced.