2021 KIA K5 Complaints

AC System faulty . Cannot defog windows. Fusebox connection is malfunctioning Changed blower motor, resistor, fuse, relay. Many vehicles are having the same issue. It needs to be recalled.

Issue with electrical wiring for HVAC. Air conditioner and heater goes out with no power. You have to pop the hood and press on the fuse box to get it to come back on.

While driving on my way home from work my , brakes became extremely hard to press down on and then my service engine light came on this all occurred on 7/31/2024. So the very next day I took my vehicle to a Kia dealership which was 8/1/ 2024 to find out what was causing this to happen. The technician stated that they would have to put it on a machine and run a diagnostic on it. I asked the technician while they were doing that to change the oil. I also realized that the oil light for my vehicle has NEVER came on since I purchased the car. So the technician did the diagnostic and stated that my vacuum pump had went out but he couldn’t tell me why or how this had happened. I then took the vehicle to my parents house and left it there in the garage for a few weeks to have second opinion done. I then took it to another Kia dealership and they stated there was no vacuum to the brake booster and said there was a broken camshaft and metal pieces were in the engine and the engine needed to be replaced. Again I asked what caused all of this and no one could give me an answer. I had only had the car a 1 1/2 years and don’t understand what caused all of this and I now have a car that I can no longer drive.

Have had issues with a/c since I bought the car. Has been inspected 3 times, apparently it was just the actuator doors not working. But not I have no a/c, and my dealer refused to fix it. On reddit there's a thread going around saying fuses are melting and that it's causing everyone's a/c to not work. My fuses for this particular spot are burnt looking. This is a safety issue in regards to living in Arizona, the heat is deadly. I will be trading my car in if this isn't recalled.

Air conditioning was fine then would suddenly cycle levels by itself. One day the air stopped blower. Tested the resister, it was bad. Replaced it and less than one week later the air stopped again. Resister and blower motor test fine. Fuses and relay are fine. No ac/hest causing driving concerns with window fog.

While driving home from work, traveling on a state route at 55 mph, the cover under the engine just snapped off on the passenger side of the vehicle. It just started making a loud noise like I had blown a tire! I pulled over and noticed it was hanging down on the road. I had not hit anything, the bracket had it fully broken, it could have caused me to wreck or put any other drivers at risk for an accident. This isn’t the only Kia K5 I’ve seen with the engine dust cover hanging beneath the vehicle.

I have 2021 Kia k5 gt line I am having similar problem as other who own a Kia k5 get line 2020,2021, 2022 and 2023. Ac works one time next I turn the car off and the next time I start it up it doesn’t work anymore and now my ac does not work now and it is off completely

Purge control valve but pressure in my gas tank and it has expanded. Kia will not replace my tank. Heard 2 loud bangs going down the road I started smelling gas. Check engine light came on. Pulled over and gas is pushing up and out behind my tank flowing down my wheel well. Opened the gas cap and it sprayed gas all over me. I have 2 small children and this could have been a extremely worse situation than it was. On another note I took my car to the dealership they did the update and confirmed my gas tank had expanded. They are not replacing my tank they said bc kia has "no remedy". And tried to sell me a bunch of other services on my vehicle instead. I've contacted kia and they basically told me the same thing they at this time will not be replacing my tank. I've picked the car up they cleared the codes and the car is still running rough.

AC stopped blowing, vehicle had 62k miles. Took to an autoshop and they indicated that the AC blower and resistor needed to be replaced. I have both of these replaced, the AC work for a few minutes and then stopped again. I took it back to the same shop and the mechanic indicated that the fuse box was melted/burned (I have a picture as evidence). This is a tremendous fire hazard and we have been leaving our car parked outside of our home out of fear that it will catch fire. Their were no warning lamps whatsoever that indicated that there was a problem. Upon further online research, it appears that numerous people are having the same issue and Kia Motors has not done anythins about it, and we are having to pay thousands of dollars for repair when it is a manufacturer defect.

The blower motor goes out intermittently. I replaced the blower motor but found the problem to be much greater. Upon further inspection the fuse for the blower and wiring harness are melting into eachother at the fuse box. This issue is becoming more and more prevalent in model from the year 2021-2024 the remedy is a complete wiring harness and fuse box replacement.