2017 KIA NIRO Complaints

The contact owns a 2017 Kia Niro. The contact stated that while driving 60 MPH on the highway, the vehicle jolted and shook abnormally. The electrical system warning light illuminated, and the vehicle lost partial power. The engine and hybrid warning lights were illuminated. The vehicle was coasted off the roadway to a gas station. The vehicle was towed to the local dealer, where it was diagnosed with a blown high-voltage fuse. The vehicle was repaired with a higher voltage fuse. The manufacturer was contacted and opened a case. The approximate failure mileage was 101,000. The VIN was not available.

-Car was leaking or burning coolant causing engine to overheat. -Car was diagnosed with: Exhaust heat exchanger is leaking coolant and needs to be replaced. After costly repair, car continued to leak coolant and overheated. -Car was taken back to the dealership and diagnosed with: Engine Assembly - Long Block - Replace | Engine long block needs replacement due to coolant in the oil. This was at a certified Kia Dealership. No insurance reps or police were involved. An engine light has come on a couple of times over the years that was interpreted to mean replacing the gas cap. After replacing the gas cap, the engine light didn't come back on. My safety was impacted as a person living in a cold, rural state to have a sudden mechanical failure where I couldn't run the heat and had to stop the car immediately.

The contact owns a 2017 Kia Niro. The contact stated that while driving at an undisclosed speed, the message "Check Hybrid System" was displayed. The vehicle was towed to the dealer, where it was diagnosed, and determined that the hydraulic clutch actuator and power assembly had failed. The dealer related the failure to Kia Safety Recall Campaign Number: SC163 (Hydraulic Clutch Actuator (HCA) Inspection, Repair or Replacement). The vehicle was repaired; however, the failure recurred. The vehicle was taken back to the dealer, where the part was replaced a second time; however, the failure persisted. The contact stated that while attempting to drive out of a parking space, the vehicle stalled and became undrivable. The vehicle was towed to Executive Kia (1164 N Colony Rd, Wallingford, CT 06492), where it was diagnosed and determined that the HCA needed to be replaced. The contact stated that the HCA failure had caused a hole in the bottom of the vehicle. The vehicle was not repaired. The contact stated that the recall repair failed to correct the failure. The manufacturer was notified of the failure, and the case was escalated to a case manager, who informed the contact that the case would fall under Goodwill assistance. The failure mileage was unknown.

The push-button locks (the plastic button that covers the electronic components) on the exterior of the driver's door and passenger's door fell off. The problem was confirmed by the Kia dealership, and attempting to push the buttons back on did not work (the buttons promptly fell back off). There was no warning that the buttons were loose before they fell off. The dealership stated that the only solution would be to replace the entire door handle.

I previously had major issues and recall 23V534000 fixed on my 2017 Kia Niro. I had issues again and took it to the local Kia dealership in Wichita, KS. They found a leak in a seal causing fluid to leak on to the clutch actuator. The service tech indicated it is related to the recall. I have spoken with Kia customer service escalations on multiple occasions. Originally they stated it was related to the recall. When I spoke when them today, on the phone they said all the parts that are affected are what were changed out previously. When they called back, they changed the story and said it is not related and they would not pay for it to be fixed, even though they previously said it was the exact thing related to the recall. When I emailed and asked for it in writing as to why it was denied, she changed the reasoning. It was nothing the same that she had told me on the phone. This is a safety issue that should be fixed by the manufacturer and they are refusing to fix it and telling me I have to pay over $5000 to fix it. Completely unacceptable.

Power sterring went out - MDPS. Car has less than 50,000 miles. This is apparently happening to many of this model & a recall was done on a very small number of vehicles for the same issue. The recall should be expanded. This is very unsafe.

When I was driving, a propulsion system warning went off. Then a malfunction in the vehicle’s powertrain/propulsion system lit up on the GPS screen. Shortly afterward, the engine began smoking, and a loud popping sound occurred simultaneously. The vehicle then experienced a sudden loss of propulsion, requiring me to pull over immediately to avoid a hazardous situation. An authorized Kia dealer subsequently diagnosed a blown head gasket with internal coolant intrusion, confirming an internal powertrain failure consistent with propulsion system malfunction, and the vehicle became inoperable. The vehicle was inspected in October and the loss-of-propulsion failure occurred in December.

The contact owns a 2017 Kia Niro. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The contact used a personal code reader and retrieved a fault code related to the evaporative emissions. The contact replaced the gas cap. The contact stated that the failure persisted. The vehicle was then taken to an independent mechanic, who diagnosed the vehicle with internal failure. The independent mechanic provided the contact with the Manufacturer's Service Action Number: SA395. The contact was informed that the failure might be related to the evaporative emissions system. The vehicle was not repaired. The contact stated that the failure persisted. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The approximate failure mileage was 135,000.

Failed/leaking coolant heat exchanger which is integrated into the rear catalytic converter assembly. This seems to be a well-known issue with 2017-2020 Kia Niros. Leaks cause overheating of the engine or no heat in the vehicle and potential blown head gaskets. This issue has been confirmed by an independent service center. Car itself gave no messages or warnings regarding the leak.

The contact owns a 2017 Kia Niro. The contact stated that while operating the vehicle, the message "Engine Overheated - Turn Engine Off" was displayed with white smoke coming from the exhaust system. Upon inspection, it was discovered that the coolant level was extremely low. The contact stated that coolant was added to the reservoir; however, hours later the coolant level was low again. The vehicle was towed to the local mechanic, who diagnosed the vehicle and determined that the head gasket was blown and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer and local dealer were not notified of the failure. The failure mileage was 112,000.