2019 KIA NIRO Complaints

Hydraulic fluid is leaking onto the hydraulic clutch actuator’s circuit board, creating a potential fire hazard. The vehicle requires replacement of the dual clutch and slave cylinder. This failure occurred just over one year after Kia replaced the dual clutch and performed a full engine replacement at a Kia dealership. This condition is identical to a known safety recall affecting 2019–2022 Kia Niro vehicles involving hydraulic clutch fluid leaking onto the actuator circuit board and creating a fire risk. Although my VIN is not listed under the recall, the vehicle is the same year, make, model, and drivetrain and is exhibiting the same defect described in the recall. This appears to be a recurring safety defect involving the hydraulic clutch system.

My backup camera works intermittently, it has been tested at the dealership and supposed to be faulty, but if faulty why does it sometimes work, this causes danger when reversing the vehicle! The dealership wants $821 to replace the camera, I feel it should be a recall, as a whole bunch of Ford vehicles are recalled for the same issue! I have had several close calls even using my mirrors and looking over my shoulder, as the car has big blind spots!

Continuing and worsening motor rumbling noise and ticking/clicking at slow speeds. Spent a couple of months and without car for weeks just to have kia confirm and have gearbox changed. This has existed in some form for a couple years now.

1. Failed Component/System: EV plastic charging door does not open using the electronic unlock mechanism on the key. Unable to charge EV vehicle due to this fundamental failure. IMPORTANT: There are no manual override mechanisms provided by the manufacturer - KIA to open this charging door. This makes the EV both unsafe and unusable since it cannot be charged. 2. Safety Risk: Unable to charge an EV vehicle is a fundamental EV electrical system component failure that can create an unsafe situation since it occurs without any warning and leave the car owner stranded. The Manufacturer - KIA has not provided any manual fail safe/override mechanism to open the charging door manually. This is also a fundamental safety issue since the failure occurred without any warning lamp/other indication to the owner. IMPORTANT: Other KIA NIRO EV owners have complained about the same issue in online forums. Refer attachment - [XXX] 3. Dealer Problem Reproduction: NO since dealer demands a $299.99 diagnostic fee. Multiple attempts to contact the dealer and manufacturer KIA to waive the diagnostic fee were unsuccessful. 4. Manufacturer/Police/Insurance Inspection: No. KIA refused to deal with this issue under the KIA 10-year/100,000-Electric vehicle (EV) system warranty even though the warranty description mentions all internal parts. Reference: KIA Case No. [XXX]. NOTE: KIA does not allow the case history to be retrieved from their manufacturer portal because they have closed the case. 5. Were there any warning lamps, messages or other symptoms of the problem prior to the failure? NO 6. When did they first appear? [XXX] (approximately) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2019 Kia Niro. The contact stated that while operating the vehicle, the message "Pull Over and Shut off Engine" was displayed and a burning odor was coming from the engine compartment. After restarting the vehicle, the failure was self-corrected. The vehicle was taken to the local dealer who determined that fluid had leaked into the clutch actuator and the clutch actuator needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The contact was informed that the VIN was previously inspected as part of the NHTSA Campaign Number: 23V534000 (POWER TRAIN). The contact stated that the vehicle experienced the failure listed in the recall. The failure mileage was 35,000.

While driving an error message appeared about regenerative braking system error and the braking effectiveness was severely impaired.

The contact owns 2019 Kia Niro. The contact stated that on several occasions when the vehicle was started, the check engine warning intermittently illuminated. The contact stated that while driving and accelerating, the vehicle lost motive power momentarily. The vehicle was taken to an independent mechanic and DTC: P074A, P1921, P074A/73, and P1921-77 were retrieved. The vehicle was taken to a dealer where it a diagnosed and determined that the transmission gear actuator needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 75,000.

2019 Kia Niro DCT engaged REVERSE during manual 1?2 upshift attempt in Sport Mode, causing violent reversal. Resets with ignition cycle. Smell of burnt clutch present. Happend at 41,000mi, then 73,000mi then again today at 154,584. Believe it may be a faulty range selector, corrupted tcu logic, or both. **Canadian Recall R238 (May 2022)** for DCT clutch actuators

I am writing to formally file a complaint regarding the mishandling of a recall repair (Recall SC276) by the authorized dealership KIA of Lincolnwood, located in Illinois. In October 2024, I contacted the dealership in relation to Recall SC276. A diagnostic inspection confirmed the issue, related to the HCA system, and was supported by multiple error codes: U1010, U1011, P17ED, P17EE. I was informed that the required parts were not available at the time and would be ordered. Despite the known fire risk associated with this recall, the dealership allowed me to drive the vehicle home, which clearly contradicts the safety procedures outlined in Kia’s own recall regulations. I waited approximately two months for a follow-up, but received no communication from the dealership. I called them myself and was informed, after repeated inquiries, that the replacement part had allegedly been damaged during delivery, and that I would need to wait longer. Weeks later, I was contacted and asked to bring the vehicle in. By that time, the car could no longer operate under its own power and had to be transported to the dealership. I left it for repairs. Shockingly, within an hour I received a call saying the car was “ready for pickup.” Upon returning, I discovered that nothing had been done. The vehicle was parked exactly where I had left it. After further discussions, the dealership admitted that the repair had not been performed and the part had not been replaced. I have photographic evidence to confirm this. They assured me the part would be ordered again. My vehicle remained at the dealership from early January until late April 2025. Eventually, I was told that I must pick up the vehicle or face storage fees. Still, no repairs had been completed. This dealership has twice returned the vehicle to me without making the required safety repairs, despite the known risk of fire and potential harm to life. They also misled me about the repair status on multiple occasions.

The rear backup camera works intermittent, checked wiring and still having issues, could cause backing issues for people that don't use their mirrors