2019 KIA NIRO Complaints

12 volt battery will suddenly and without warning loose capacity to power the vehicle operating controls and displays including remote key access, start sequence using push button start, and traction battery charging through charging port. While parked and connected to a charging station vehicle ‘died’ in place. This occurred within 10 minutes of last use of remote key to unlock doors, open doors, place shopping bags, close doors, and use driver door push button feature to relock doors. Outside air temperature was mid 20’s Fahrenheit. Traction battery was fully depleted per dashboard miles available display as vehicle driven 20 plus miles using hybrid vehicle mode just prior to parking at charging station. Vehicle was removed from charging station connection and 1.5 hours later jump started using connection under hood. After start was driven just under 4 miles to home garage where plugged into 110 volt home charger. Multimeter on 12 volt system after recharge of traction battery read over 12 volts. Appears that control system for maintaining charge on 12 volt system using traction battery has a flaw that fails to detect 12 volt battery condition and react correctly. While this occurred this time while vehicle stopped and shutoff there is potential for such to occur while vehicle in a roadway at highway speeds causing vehicle to loose all power as 12 volt system powers all operating logic. As a practicing engineer over 50 years and college instructor of engineering for about 40 years it appears that there is a software error in assuring 12 volt system intact and a failure of the software to identify potential problem, notify operator, provide a manual reboot of operating system before 12 volt system reaches failure level if it ever did. Unlike alternator equipped vehicles that show failure of alternator no such given on hybrid.

The contact owns a 2019 Kia Niro. The contact received notification of NHTSA Campaign Number: 23V534000 (Power Train) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while the vehicle was at the dealer for the scheduled recall repair, the vehicle was inspected. The contact's wife was informed that the hydraulic clutch actuator (HCA) was faulty and needed to be replaced. The contact's wife was informed that the parts were unavailable, and the repair needed to be rescheduled. The vehicle was not repaired. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 61,473. Parts distribution disconnect.

KIA NIRO 2019 SAFETY RECALL As described in the safety recall (previous page), my KIA Niro 2019 alarm went off with the following error message "Engine Overheating". Kia of America and its dealership refused to fix the problem. The car dealership -said- has no direction as to how or when to fix the problem, and the KIA consumer hotline is out of business.

Able to completely stop vehicle with light brake pedal pressure without activating the brake lights. Regenerative braking is engaged

This complaint references the open recall with the Kia reference SC276 and the NHTSA reference of 23V534. Kia has not been able to provide me with repair despite a notice from them stating a remedy is available, and appears Kia may be sending out faulty notices. I first received notice in July/August, 2023 that this recall was in process but remedy was not available. This week, I recieved a letter dated December 29, 2023 that explicitly states remedy is available (attachments will be added). However, the NHTSA website, the Kia recall website, and my local Kia dealer all as of today (01/04/24) say that remedy still is not available. I have attempted to call Kia customer care at the number on the letter, but every attempt has resulted in their system hanging up on me before I could reach anyone.

The contact owns a 2019 Kia Niro. The contact received notification of NHTSA Campaign Number: 23V534000 (Power Train) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

On 7-31-2022 while traveling on the freeway the gas engine shut down, HEV triangle came on and the information center on the car displayed "turn off car restart" on this trip it happened three times. I took the car to the dealer and they had it for a month and could not get it to act up. On 5-5-2023 it did it again twice, I called the dealer and they did not have a loaner car, they said they would let me know when they do. On the 6-30-2023 it did it eleven times. I called the dealer and they checked the car into service a mouth later 7-2023. The car has been at the dealer since then, now it is 12-2023. The dealer has not been able to get it to act up. I call KIA customer service and they told me they would not do the recall unless the dealer can repeat the problem. When this happens, I have only a limited amount of room to get the car off the road. This problem has only happened on freeways and the mountain pass with limited pull outs. This exposes me and any passenger's to a rear end collision. I feel the manufacture is playing roullet with me and my passenger's lives. All my dealer paper work is in my car a two hour trip at Sunset KIA 3317 Auburn way N Auburn WA 98002

Recall letter from KIA states "WARNING: You may experience illumination of the HEV warning light. If this occurs, pull over to a safe location and contact Kia Roadside Assistance ... to request to have your vehicle towed to the nearest authorized Kia dealership as soon as possible." This implies that the car is not safely driveable if the HEV warning light illuminates. My HEV warning light illuminated, but neither of two local Kia dealerships is willing to take responsibility since the "remedy is not available" from Kia. This means I have lost the safe use of my car for an indefinite period without any compensation from Kia.

This is a published TSB but it doesn't appear when searching for this vehicle. I have to search in google for specific phrases to find this on your website. "DRIVE UNIT INSPECTION & REPLACEMENT FOR EV MOTOR RUMBLE NOISE " Kia Niro EV: [XXX] Hyundai Kona EV: [XXX] Known issue with many customers reporting Kia and Hyundai Motor failures. But since it is not an official recall campaign, it doesn't pop up when researching Kia Niro, Soul, Hyundai Kona, Ioniq EVs. Many consumers report that service centers will gaslight, dismiss, downplay, or falsely blame on brakes, rotors, other unrelated parts. Some have reported they flat out refuse to work on their car even if they bought it there, stating that they don't have technicians trained for EV service. And when/if we are lucky enough for service departments to do repairs, the parts are on backorder. They have to replace brackets/mounts that never resolve issue until finally replacing the motor/gearbox. Often the problem comes back in a few months as the replacement parts don't actually address the root causes. This should certainly be a full recall campaign that the public is made aware of. A final note here on the problem with these extensive complicated long services, is that people are without a vehicle during the whole process. Dealerships and Manufacturers pass the buck, point the finger to each other. Dealerships don't offer loaners, they say check with Kia for rental reimbursement. No one who plans a budget for a new car payment, ever factors in $2-3000 for months of car rental payments that the Manufacturer won't pay until the service is fully finished. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Breaks seized to respond when doing a sharp break. Vehicle did not break and slid off until it hit the vehicle up front. Waiting for vehicle inspection to begin. No warning signs, lights, or prior issues happened before the incident.