2020 KIA NIRO Complaints

Faulty EPCU and circuit board damaged from coolant leak, as described by Kia technician. Other components have been affected. Estimated $3,000 in parts left to replace. Total repair cost is looking to exceed $13,000. On last failure of car, I was driving as the Electical Vehicle Systems error occurred and the car went into neutral and when it slowed down, went into Park. Car would start and drive 10-15 feet before becoming inoperable again. Dealership says they fixed by adding coolant and they couldn't replicate the error. It took me 200 ft of driving to do it. I turned on the AC and the error happened. Could have been coincidental. Kia has declined/refused repairs because serious fault happened at 60,800 miles and they say its out of warranty. Issue had been going on for about 30,000 miles at that point with no resolution ever being reached. Car has been throwing errors and codes and repeated attempts to have Kia check my car for the recall that had been issued were ignored and i was told the recall wasnt the issue. April 29, 2023 was the first time I contacted Kia service about the Low Inverter Coolant message I was getting. Kia insisted that coolant just needed to be flushed. Coolant Issue persisted. They bled and flushed the system and put new coolant in. Issue peristed. Car was taken to dealership at least 3 or 4 times. On one occasion, technician informed me that if the coolant message goes away when you turn the car off and it doesn't constantly flash, there's no urgent issue. He was apparently misinformed. I have now had the exact thing happen to my car that the recall was meant to prevent. My car was produced in 8/20 so within recall time-frame. My car should be recalled and Kia should be made to rectify the situation. All repair documents and estimates are included in my submission.

My vehicle was the victim of attempted theft and reported to City of Cincinnati police 8/11/23. It then underwent repairs and delays before it was returned to me on 9/22/23. The left side rear door is basically detached from the system, causing the alarm to go off or not even work. The back seat lock is completely malfunctional, and there is glass remaining inside the car. I was informed by two separate Kia locations that they would contact me about repairs. On 9/29, notice attached here, I was informed that when a remedy is available, they will repair and cover the costs. No one has contacted me, and I have called multiple times over the last several months, including leaving voicemails, asking for any updates. I have phone logs I can provide as well. NOTE: The "Upload Files" button is not working below. Each time I click it, it just vanishes. This makes it impossible to attach anything.

Drive unit defect in EV motor/reduction gear. These vehicles have a manufacturing defect that causes a percentage of them to experience a loud noise while under acceleration, loudest at around 30mph. It is described as a "card in spokes", "motor rumble", "wheel of fortune", "clicking/tapping" sound. There is a TSB that Kia has released for this issue, ELE234, but Kia continually denies and obstructs owners from getting their vehicles repaired under warranty. It typically begins quietly at around 20-30k miles, gradually getting louder. Currently at 68k, Kia continues to deny repairs. It has been inspected and diagnosed several times by a Kia dealership, acknowledging the defect referenced in their own TSB, but Kia will not authorize the repair.

-Abnormal Reduction Gear and/or EV motor Rumble noise as identified in KIA TSB-234. The car is available for inspection. -Car not working properly/increasing the risk of stall or breakdown while driving and therefore increasing the risk of collision/accident. There is a loss of power and increased revolution noise from the reduction gear/EV motor increasing the incidence of vehicle failure during operation and accident, therefore increasing the incidence of property and bodily injury/damage due to known issues by KIA currently being serviced only under TSB and not as a recall. -This problem was confirmed by the dealer technician. The technician also identified that a TSB exists for the identified issue. Per technician same issue has been previously serviced by the dealership for other Niro EV customers when under 100K (warranty period). Per the technician, this problem occurred outside of the 100K and would require authorization from KIA corporate. Kia customer service was contacted and was unwilling to resolve the issue. -Yes a test drive was performed with the technician who was knowledgeable about the issue and the TSB who immediately identified the issue as the one identified in TSB-234 and informed that some vehicles in the past have been serviced for the exact same issue but require KIA Motors authorization for service outside of 100K. KIA is unwilling to provide authorization. -No prior warning signs/warning lamps, Issues started happening after 100K. The dealer was notified at the time of service of another recall on the current vehicle. No resolution was provided for the safety issue being experienced.

The contact owns a 2020 Kia Niro. The contact received notification of NHTSA Campaign Number: 23V534000 (Power Train) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2020 Kia Niro. The contact received notification of NHTSA Campaign Number: 23V534000 (Power Train) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2020 Kia Niro. The contact received notification of NHTSA Campaign Number: 23V534000 (Power Train) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2020 Kia Niro. The contact received notification of NHTSA Campaign Number: 23V534000 (Power Train) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

I have been a Lyft driver for over 2 years, and because of the mileage I put on mile personal vehicle. I had to result to renting a vehicle from Lyft Flex Drive Rental, located at 2214 Century Center Blvd Irving, TX 75062. 0n 05/15/2023 at approximately 8:15 p.m. Right after dropping off passenger, and on my way to pick up another one. The vehicle mentioned hereof suddenly blew up out of no where. My personal property in the vehicle was destroyed , and almost loss my life! However, Lyft is suggesting I pay over a thousand dollars. When it wasn't my fault the car blew up. Moreover, their stagnating me from getting back to work, and not allowing me to rent a car from Lyft Fleet . Because supposedly the car hasn't been totaled out yet. Despite it as been weeks since the incident occurred. I also took my vehicle to Lyft Flex shop for a check up the previous week before the incident occurred. My Please see photos attached! THE INSURANCE COMPANY HANDLING THE MATTER IS LIBERTY MUTUAL CLAIM # 241398210 / Phone Number: 888.638.3564

The contact owns a 2020 Kia Niro. The contact stated that after charging the battery to 80 percent, the vehicle immediately turned off while reversing out of the charging station. After restarting the vehicle and driving, the failure reoccurred. The vehicle was towed to the dealer who cleared the failure codes and tested drove the vehicle, but no failure was identified. The vehicle was not repaired. The manufacturer was not yet notified of the failure. The failure mileage was 17,972.