2019 KIA NIRO PHEV Complaints

Within the first 6 months of owning our 2019 Kia Plugin Hybrid, we started experiencing a clunk with a lurch when accelerating from a stopped position. The issue became progressively worse over time - increasing in frequency and severity. The car has been to the Kia Lupient dealership in Brooklyn Park, MN multiple times for this issue. At our most recent visit on November 7th, 2022, the service advisor acknowledged that the issue may be due to shipping the vehicle with the wrong transmission fluid. The transmission fluid was replaced with the correct fluid. However, we experienced the issue again on December 2, 2022. Could the wrong fluid have caused permanent damage to the transmission? This Technical Service Bulletin (https://static.nhtsa.gov/odi/tsbs/2020/MC-10174520-0001.pdf) indicates that could be true. We are pursing arbitration with the dealership.

I have a used 2019 Niro PHEV. I started getting a loud jerk when starting from a full stop. At first it started happened in EV mode only but I've had it happen in Hybrid mode a couple of times ( not sure if the engine is actually working or just on for Heating). The sound and jerk can best be described as what happens when you drive a stick shift and you pull the clutch too quickly in first gear without any gas and the car jerks forward. It also feels like I've been rear ended. The car feels unsafe the drive. There were no warning lights. Dealer hasn't reproduced it yet. I just brought it in. Please see these forum posts about this issue. Many others are experiencing this: https://www.kianiroforum.com/threads/brand-new-2019-phev-loud-jerking-noise-when-starting-from-full-stop.8740/ https://www.kia-forums.com/threads/occasional-hard-loud-shift-from-start-on-new-niro-phev.342780/

The vehicle has an intermittent jerk/clunk sound when accelerating or coming to a stop. Occasionally it can feel as if the clutch is coming engaging/disengaging roughly and cause passenger's heads to shake forward. In a few instances there has been a delay when pressing on the brakes to initiate stopping before the vehicle, this momentary loss of control is alarming. It feels as if the clutch and brakes did not react to the pedal immediately. I have taken the vehicle to the Kearny Mesa Kia dealership to diagnose the issue on 3 separate occasions starting from 2 months after purchasing the vehicle. On the most recent visit they have diagnosed that dual clutch failed a calibration test - it is unclear if they performed this test on the previous visits. Repairs have not yet been performed as I am disputing the out of warranty claim by the dealership

Obnoxious eye and lung burning fumes in the car when turning the heater on. It was so from the day I bought it. Many owners have reported it also on Kia nitro forum . I drive in the cold without the heater or leave the window open to let the fumes out. It’s a health hazard and seems to relate to their heater core or it’s insulation material. Dealer and Kia claim nothing is wrong. It’s a health and safety hazard in need of immediate solution and recall. Also car’s steering column make a wheezing or rubbing noise when turning the wheel. Dealer says it’s normal. It’s not a safety hazard yet. But I have never driven or heard any other car with persistent rubbing noise it it’s inside the car’s steering column. Whatever is rubbing will eventually wear out posing failure and safety risk. A voluntary recall may be in order.

I don't know what components are involved. When attempting to move forward from a stop the car does not respond immediately. Then there is clunk noise and a lurch forward. Sometimes when this happens it feels like the car has been hit from behind. The problem began about a year ago and has been into the dealer's service center several times. I believe during one of those service visits a reset of something was done that seemed to resolve the issue for several months. The problem is intermittent. Dealer has been unable to reproduce the issue, but stated the last time the car was in for service that another customer with the same year and make was having the same symptoms and a tech that had been allowed to use the car for over a week did not experience the issue. No warning lights or codes are associated with the issue. A car that fails to move forward on a green light is in danger of being rear-ended placing the people in the vehicle and surrounding vehicles at risk of bodily injury. The vehicle has not been inspected by anyone other than service staff at the FOlsom Lake Kia dealership. On February 18, 2022, the vehicle had no power (automatic doorlocks didn't work, etc) could not be started and was towed to the dealership where it is now.

The contact owns a 2019 Kia Niro. The contact stated that while driving at night with the low-beam headlights activated, the illumination was either too bright or improperly position causing the light beam to become visibility hazards to the oncoming drivers. The contact indicated that oncoming motorist constantly flashed their lights indicating that the high-beam headlights were activated even though only the low-beam headlights were illuminated. The cause of the failure was not determined. The contact referenced the NHTSA Campaign Number: 18V771000 (Exterior Lighting). The local dealer was notified of the issue. The manufacturer was not yet contacted. The failure mileage was 50.

Received automated message that my engine may be compromised and to schedule maintenance, I took my car to the dealership service that same day. I was advised that the fuel injectors needed replaced, the car still was not working the was advised a cylinder needed to be replaced that did not correct the issues and was advised the engine needed to be replaced on my 2019 Kia Niro PHEV that has 17,801 miles. Dealership has my vehicle now for over 5 weeks With no estimated completion date.

For no apparent reason (other than a stress crack or other manufacturer or design defect), a long crack appeared in my windshield (start from the bottom left and going up and over about 20 inches). It is an interior window crack that cannot be felt from the inside or outside. Vehicle was simply parked at the time. Not caused by accident, rock or other impact. Dealer so far refused to replace the windshield under warranty although it is clear within the Basic Warranty Coverage and not excluded from coverage. Based on Google search, it appears that Kia has a long history of knowing about windshield cracks on different models, not just the Telluride which is part of class action lawsuit. Kia needs to be replacing cracked windshields like this per its Basic Warranty terms. It is a significant safety hazard.

STEERING WHEEL MAKES A LOUD SQUEALING NOISE WHEN MAKING SLOW TURNS- IN REVERSE AND MOVING FORWARD.

1. STEERING WHEEL COUPLER MAKES A GRINDING NOISE WHEN TURNING AND GETTING LOUDER EVERY DAY. DEALER CLAIMS THERE IS NOTHING WRONG. 2. TOXIC NAUSEATING AMMONIA TYPE FUME IS EMITTED FROM THE HEATER CORE WHEN THE HEATER IS TURNED ON. I HAVE TO OPEN WINDOWS TO BE ABLE TO DRIVE. DEEKER CLAIMS NOTHING IS WRONG. BOTH PROBLEMS REPORTED BY OTHER NIRO OWNER AT KIA NIRO FORUMS.