2015 KIA OPTIMA Complaints

The contact owns a 2015 Kia Optima. The contact stated while driving approximately 75 MPH, the vehicle independently decelerated to approximately 60 MPH. The contact stated that the check engine warning light was flashing. The vehicle was towed to the local dealer, but the cause of the failure was not yet determined. The contact stated that a knock sensor was installed to monitor the engine performance. The manufacturer was not yet contacted regarding the failure. The failure mileage was 70,000. The VIN was not available.

I was driving on the freeway when I noticed smoke coming out of my hood. I immediately exited the freeway, pulled over, popped the hood open, and my engine was on fire. There were no warning lamps on my dash. I don’t know which components were involved and inspection of the components after was not possible, because everything under the hood burned by the time firefighters responded.

I purchased a 2015 Kia Optima 2.4L GDI (VIN: [XXX] ) with a blown engine, which is covered under Kia’s extended engine warranty. I contacted Jim Butler Kia in Chesterfield, MO, where the last service was performed, and requested the free engine replacement under warranty. They acknowledged that the car is covered, but refused to perform the repair because the vehicle is not yet registered. I explained that I have the title in my name and proof of ownership, but cannot register the car in Missouri because it does not run and must pass safety and emissions inspection to be registered. Despite showing them the title and explaining the situation, they continue to deny warranty service. I believe this is unfair and against Kia’s warranty policy, which requires proof of ownership—not necessarily registration. I’m requesting the dealership to honor the warranty and perform the repair, as the issue is known and covered by Kia’s engine recall campaign. I am not seeking financial compensation—just proper and fair warranty service for a defect Kia already acknowledges INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2015 Kia Optima. The contact stated while driving 55-60 MPH, the engine seized. There was no warning light illuminated. The contact inspected the vehicle and became aware of a burning odor around the exterior of the vehicle. The contact attempted to start the vehicle; however, the vehicle failed to start as intended. The vehicle was towed to the residence. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 85,000.

Vehicle experienced sudden loss of power while driving when cylinder 3 completely failed (0 PSI compression). Metal particles found in oil and excessive oil consumption (1 pint/100 miles). KIA dealer diagnosed as piston rings but ignored metal in oil that suggests bearing failure covered under recall campaign. Refused proper diagnostic testing. Vehicle now unsafe to drive with failed cylinder that could cause complete engine seizure while driving. Kia had all recommended services and oil changes since acquired in 11/2016. These service records demonstrate the progression of my vehicle's engine issues, from early oil consumption problems documented by York Auto Care in July 2023 (3 quarts low) to complete cylinder 3 failure with zero compression confirmed by Kia's own diagnostic testing in May 2025. Despite this documented history and Kia's own test results showing catastrophic engine failure, they have denied warranty coverage under their engine campaign that specifically covers bearing-related failures on my 2015 Kia Optima 2.4L.

The contact owns a 2015 Kia Optima. The contact stated while driving approximately 65 MPH, the check engine warning light illuminated. The contact stated that the vehicle started to lose motive power. The contact pulled off the roadway and heard an abnormal grinding sound coming from underneath the vehicle. The contact turned off the vehicle and the vehicle was unable to be restarted. The contact had the vehicle towed to a local dealer who diagnosed the vehicle and determined that the engine needed to be replaced. The contact was advised that the following DTC were retrieved: P0076; P0079; B2519; B2521. The vehicle was not repaired. The manufacturer was informed of the failure and informed the contact that there was no recall on the VIN for the engine. The failure mileage was approximately 140,000.

I was driving on the Northbound side of the Interstate when my brakes failed when I pressed them to avoid a collision on the highway. The steering wheel malfunctioned when I tried to avoid a head-on collision with another vehicle. I couldn't control or stop the car, causing me to swerve left to right, and I then completely lost control of the vehicle. I crashed into the middle of the highway, but because my brakes had failed, the car continued at full speed into the Southbound side of the highway, causing me to wreck into a semi. The Colorado State Patrol investigated the accident. Right before I wrecked into the semi-trailer, I noticed all of the lights on the dashboard were off. My Steering wheel had fallen off completely, but the airbag never deployed even though every other airbag had deployed.

My car has less than 50,000 miles on it. I was driving at around 40 miles per hour and my engine suddenly stalled. My car was towed to the nearest repair facility and a diagnostics was completed on it revealing a seized engine. My car has been well maintained and has never been in a repair shop for any type of major repairs. This engine failure came as a complete surprise as the car gave no indication that there was a problem. Kia Motor Company has recalls on other cars with the same make, model, year and engine size as mine that have had the same exact issue as what mine has presently. However, when I look up my VIN on their website my car only shows 1 recall which is unrelated to the issue I am currently experiencing. I would like to understand why my car is not included in this recall, when my car has had, at this point, the same exact thing happen as these other cars of the same make, model, year and engine size?

Having issues with my engine, it’s throwing the code saying that my glow relay is stuck on and has something to do with the knock sensor, which is on a recall on 2015 Kia Optima, but my VIN number doesn’t seem to be one that’s on the recall list, but my engine is doing the same thing that the other ones are being recalled for.

I am contacting you regarding my 2015 Kia Optima EX (VIN: [XXX] , while driving, I experienced a sudden strong burning smell followed by heavy white smoke from the engine area. Shortly after, the engine stalled, and the vehicle had to be towed. I have verified that there are no open recalls or settlements listed for my vehicle. However, based on the known engine issues affecting similar models, I am respectfully requesting goodwill assistance from Kia to repair or replace the engine. I have always taken good care of my vehicle, and I believe this issue may be related to broader known concerns with the engine models from those years. I would appreciate your help in reviewing my case and offering any available support to resolve this issue. Thank you for your time and consideration. I look forward to your positive response. Sincerely, [XXX] Pho [XXX] ail: [X [XXX] [XXX] [XXX] SUANT TO [XXX] FOIA), 5 U.S.C. 552(B)(6) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)