2017 KIA OPTIMA Complaints

I own a 2017 Kia Optima with a major internal engine defect. Starting shortly after purchase, the car lost power and consumed fuel unusually quickly. Over time, the engine began burning excessive oil and now produces a loud knocking sound (bearing knock), indicating internal bearing failure. These symptoms are consistent with known Kia engine defects (bearing wear / piston ring failure). The defect is a serious safety concern: because of weak bearings and high oil consumption, the engine could stall, seize, or catch fire. The dealership has refused to repair or replace the engine. I am reporting this as a safety defect and request NHTSA investigation.

The contact owns a 2017 Kia Optima. The contact stated that upon routine maintenance with a local independent mechanic, it was discovered that the vehicle had low engine oil. No warning light was illuminated. The vehicle was taken to a local dealer, where it was determined that an oil consumption test was needed to determine any failure. The vehicle was not repaired. The check engine warning light was illuminated. The contact stated that engine oil was added almost every 2 weeks. The message to "Contact the Dealer" was displayed. The vehicle was towed to Team Kia of El Cajon (541 N Johnson Ave, El Cajon, CA 92020), where it was determined that there was engine oil leaking onto the catalytic converter. The contact related the failure to a Kia recall related to a connecting rod bearing failure. The manufacturer was made aware of the failure. The failure mileage was approximately 100,400.

I purchased the 2017 Optima Hybrid from Huntington Beach Hyundai on [XXX]. I made sure to double check with the dealer if the engine and hybrid battery were in good condition, in which the salesman reassured me everything is good. The car was driving okay for a while, and I had oil change and tires/alignment changed recently. Just barely 4 months in after I owned the car, the incident happened on the night of [XXX]. I was driving on the highway near the Getty going roughly 70 mph up the mountain roads while all of a sudden the "check hybrid system" warning came on in the car. The car immediately went into limp mode, and I did everything I could to slow the car to a complete stop, and stop on the freeway shoulder safely. It was a traumatizing experience to me, as this is a major safety issue with the vehicle, and other cars were travelling really fast in LA mountain areas. I had the car towed to a auto repair shop the next day, the mechanics did a deep inspection and informed me the hybrid inverter has failed. I paid $2,177 to replace the hybrid inverter with the mechanic. The mechanic also informed me while they were test driving they heard a knocking sound from the engine. I did a look up and found out there is a class settlement and safety campaigns on the engine for 2017 Optima Hybrid due to the faulty factory rod bearings, and the 150K miles extended warranty from Kia should apply to replace my faulty engine free of charge. I will be getting my car towed to Car Pros Kia in Huntington Beach on October 15th, 2025, and request the dealer to replace my engine per Kia's extended warranty. I am filing the complaint because the car is having problems after problems in barely 4 months of ownership, in which I believe I have purchased a lemon, or Huntington Beach Hyundai knowingly hid the facts the components were faulty. I have also filed a case with Kia corporate. Attached is the repair invoice for the hybrid inverter. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6

Engine is consuming a large amount of oil. Oil is gunking up spark plugs causing them to be replaced every 10-12 months. Have to add oil 3-5 times per month. This is our 2nd Kia optima and the first (2011) with seized engine in which Kia paid for replacement.

The contact owns a 2017 Kia Optima. The contact stated that while driving approximately 50 MPH, there was an abnormal knocking sound coming from the engine compartment. The contact stated that the check engine and oil warning lights illuminated and then turned off independently. The contact slowed down, and after arriving at the destination, the vehicle was towed to an independent mechanic. The contact was advised by the mechanic that there was potential engine failure and was referred to the dealer for assistance. The vehicle was towed to a dealer, and the contact was made aware that the VIN was included in NHTSA Campaign Number: 21V844000 (Engine); however, the KSDS software update was not performed prior to the engine failure, which disqualified the vehicle from the engine replacement. The vehicle was not repaired. The manufacturer was informed of the failure and advised the contact that the vehicle did not qualify for the engine replacement. The failure mileage was approximately 64,500.

Oil is burning too fast... Car has had an issue like this in the past and the problem resulted in a blown engine... Re-call was found by dealer and honored and endinge re-placed.. Car is now expierenceing this problem again... Second, steering wheel is locking when turnning fully left... Third, car smells extremely strong like gasoline when car is warming up...

I was driving the vehicle home on the freeway after just buying it. I had only driven it for about 35-40 minutes and after 5 minutes the ev battery was drained completely and the car was running in hybrid mode. The vehicle suddenly lost all its power and a warning light came on flashing saying "check hybrid system turn off engine". I was forced to put on my emergency lights and quickly move over to the side of the freeway because the car lost so much power so quickly. It felt like the engine died and when i tried hitting the gas the vehicle would jerk. ONCE I got to a safe spot on the freeway. I called AAA to get a tow, then called the dealer to tell them. My wife and I have now checked the recalls for this car and all the customer complaints. There seems to be a similarity with the engine recall and or the hybrid electrical recall. It seems like Kia is making sure to cover its tracks with the cars so it doesn't have all the 2017 models in the recalls affecting the hybrid system as well as the defects with the engine components. There is definitely a problem. But i saw in the carfax that the vehicle was inspected a lot by KIA and that is why i would like it to get inspected by a 3rd party. I would like to get the vehicle inspected by a 3rd party before taking it to a KIA dealer but I don't have a lot of money. Can you help with this at all. Please contact me asap. You have the Vin. I told you I just bought the car so I am going to either see if the dealership I bought it from will fix the problem since it broke down the day I bought it. You should be able to see we bought the car from by looking at the carfax for the Vin. And you have my permission to also be able to get my phone numbers from that dealer I really don't think KIA should get away with these hybrid/engine problems with the car. Its very unfair to the consumers. If they as a manufacturer and dealerships are doing quick fixes when doing regularly scheduled maintenance. Thats unethical.

Engine completely shut down when driving it. Had it replaced among many other things then found out it was part of a class action lawsuit. I have spent two years trying to recoup the money I lost in repairs and the cash I paid for the car.

for the past year, I have been constantly replacing the spark plugs and ignition coil in my 2017 Kia optima. Recently I have had the valve cover gasket replaced. It is a constant oil consumption issue. I have received the P1326 diagnostic code. My dealership told me that the engine cannot be replaced unless it’s knocking. This is my only mode of transportation, and I would hate for me to be stranded because I’m waiting for the engine to knock for my engine to be replaced.

I own a 2017 Kia Optima. My vehicle was brought in for the tail light recall at Lupient Kia, but the dealership only replaced a bulb and refused to replace the harnesses. I was told by the service advisor (Brad Baranowski) that my tail lights had “nothing to do with the recall” and that I would need to pay $210 for a diagnosis, even though I am still experiencing the exact defect described in the recall (shortage/failure in the harness causing tail light malfunction and warning lights). This incomplete recall repair is a safety hazard my tail lights continue to fail, and I have received tickets because of it. I request that NHTSA investigate Kia’s failure to properly complete this recall. Lupient Kia 6030 N Green Bay Ave Glendale, WI 53209 Phone: (414) 351-3000