2002 KIA OPTIMA Complaints

TL* THE CONTACT OWNS A 2002 KIA OPTIMA. THE CONTACT STATED THAT WHILE REFUELING, FUEL SPILLED OUT OF THE FUEL FILLER NECK. THE MANUFACTURER WAS CONTACTED AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V180000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 52,000.

CAR WAS MAKING STRANGE NOISE. TOOK TO MECHANIC TO HAVE CHECK. IT WAS DISCOVERED THAT THE SUBFRAME IS COMPLETELY RUSTED THROUGH ON PASSENGER SIDE AT FRAME MOUNTS AND ALMOST RUSTED THROUGH ON DRIVERS SIDE. MECHANIC DETERMINED THAT DUE TO THE SEVERITY OF PROBLEM VEHICLE IS UNSAFE TO DRIVE AND WILL NOT ALLOW BACK ON ROAD UNTIL NECESSARY REPAIRS ARE MADE. I CONTACTED KIA AND WAS TOLD THAT THIS PARTICULAR YEAR VEHICLE WAS IN A RECALL DUE TO THIS PROBLEM. HOWEVER, THIS PARTICULAR VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS ORIGINALLY PURCHASED IN THE STATE OF WEST VA, AS STATED IN THE RECALL. VEHICLE IS STILL PARKED AT MECHANICS GARAGE AND I WOULD GREATLY APPRECIATE COMMUNICATION REGARDING THIS MATTER. I WAS TOLD BY KIA REPRESENTATIVE THAT I WOULD NEED TO CONTACT YOUR ORGANIZATION. *TR

TL* THE CONTACT OWNS A 2002 KIA OPTIMA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE VEERED TO THE RIGHT IN A JERKING MOTION. THE FAILURE OCCURRED WHENEVER THE BRAKES WERE DEPRESSED. THE CONTACT STATED THAT THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS MANEUVERED TO THE SIDE OF THE ROAD. THE CONTACT NOTICED THAT THE PASSENGER'S SIDE TIRE WAS POSITIONED OUTWARDLY. ALSO, BOTH FRONT TIRES HAD PREMATURELY WORN DUE TO THE DEFECT. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER AND REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER 09V183000 (SUSPENSION). THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

THE VEHICLE WAS DRIVEN AND AT ONE POINT THERE WAS A NOTICEABLE DIFFERENCE IN STEERING AND THE CAR PULLED TO THE RIGHT. WITHIN A FEW DAYS OF THIS EVENT, THE BRAND NEW TIRES THAT WERE PURCHASED JUST A FEW MONTHS EARLIER, WORE FROM THE INNER EDGE TO ABOUT 1/3 OF THE WIDTH OF THE TIRE, EXPOSING THE BELTS. THIS CAUSED ONE TIRE TO POP, WHILE THE CAR WAS BEING DRIVEN. A SPARE WAS PLACED ON THE VEHICLE TO GET IT TO A TIRE REPAIR LOCATION AND AFTER APPROXIMATELY 30 MILES OF DRIVING, THE SPARE LOST ALL TREAD AND ALSO POPPED. THE VEHICLE WAS THEN TOWED TO THE TIRE REPAIR SHOP AND THE RUSTED AND BROKEN SUBFRAME WAS DETECTED. THE AREA WAS SO RUSTED THAT PORTIONS OF THE FRAME BROKE AND THE TIRES WERE NO LONGER RUNNING STRAIGHT. I CALLED KIA AND THEY TOLD ME ALTHOUGH THERE ARE RECALLS FOR THIS VERY PROBLEM ON KIA OPTIMAS FROM 2001 TO 2004, MY CAR WAS NOT IN THE RECALL BECAUSE I LIVE IN KANSAS. THE RECALL DOES APPLY TO KIAS IN MISSOURI, WHICH IS 15 MINUTES FROM WHERE I LIVE. THE KANSAS CITY AREA IS BOTH MISSOURI AND KANSAS AND THE AREA WHERE I LIVE. THE RUSTING IS ATTRIBUTED TO SALT USED DURING INCLEMENT WEATHER IN MISSOURI AND NOT ONLY IS THE SAME SALT USED IN KANSAS, BUT I ALSO DRIVE IN MISSOURI. THE KIA REPRESENTATIVE STILL REFUSED TO RECOGNIZE THAT MY VEHICLE SHOULD BE PART OF THE RECALL EVEN THOUGH THE EXACT SAME ISSUE THAT CAUSED OTHER KIA OPTIMAS TO BE RECALLED HAS HAPPENED TO MY VEHICLE. THE RECALL NEEDS TO BE EXTENDED TO KANSAS BECAUSE WE DEAL WITH THE SAME ELEMENTS AS MISSOURI AND IOWA WHICH ARE INCLUDED IN THE RECALL. MY SON WAS DRIVING THIS VEHICLE WHEN THE DAMAGE OCCURRED AND HE COULD HAVE SUFFERED SERIOUS INJURY IF HE HAD BEEN ON THE HIGHWAY INSTEAD OF A SIDE STREET. *TR

TL* THE CONTACT OWNS A 2002 KIA OPTIMA. THE CONTACT STATED THAT WHILE DRIVING SHE HEARD AN UNFAMILIAR SOUND COMING FROM THE UNDER CARRIAGE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS CONFIRMED THAT THE SUB FRAME WAS SEVERELY RUSTED WHICH CAUSED IT TO FAIL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE ISSUE. THE FAILURE AND CURRENT MILEAGE WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2002 KIA OPTIMA. THE CONTACT STATED THAT WHILE DRIVING 5 MPH, THE CONTACT HEARD A LOUD NOISE NEAR THE FRONT DRIVER SIDE TIRE AS THE VEHICLE DROPPED TO THE GROUND. THE VEHICLE WAS TOWED TO A MECHANIC FOR INSPECTION WHERE THEY ADVISED THAT THAT THE BALL JOINTS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE CONTACT STATED THAT HE STILL HEARD A NOISE AFTER THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED AND THEY STATED THAT THERE WAS NOTHING THAT COULD BE DONE. THE FAILURE MILEAGE WAS 85,000. UPDATED 08-03-12 *BF UPDATED 09/07/2012 *JS

UPON ROUTINE INSPECTION OF VEHICLE, MY REPAIR GARAGE NOTED THAT BRAKE LINES WERE QUITE RUSTED, AND STATED THAT THEY COULD FAIL SUDDENLY. IS THIS COMMON OR UNCOMMON IN A 10 YEAR OLD VEHICLE? *JB

TL* THE CONTACT OWNS A 2002 KIA OPTIMA. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC FOR ROUTINE SERVICE WHEN HE WAS ADVISED THAT THE SUB FRAME WAS CORRODED. THE MANUFACTURER WAS CONTACTED BUT DENIED ANY ASSISTANCE WITH THE REPAIRS BECAUSE THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 09V183000 (SUSPENSION: FRONT). THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 64,148.

MY 2002 KIA OPTIMA, VEERED OF THE SIDE OF THE INTERSTATE DUE TO A FLAT TIRE. THE TIRES HAD BEEN REPLACED THAT MORNING AND WITHIN 130 MILES ON THE HIGHWAY THE RIGHT FRONT TIRE POPPED. AS I TOOK A CLOSER LOOK I NOTICED MY WHEEL WAS SLANTED IN. I THEN HAD IT TOWED TO THE NEAREST REPAIR SHOP WHO INFORMED ME THE ENGINE CRADLE WAS RUSTED AND CORRODED. WHEN I CONTACTED KIA ABOUT THE ISSUE THEY BASICALLY SAID SORRY ABOUT YOUR LUCK. THERE IS A RECALL FOR THIS PROBLEM BUT MY VIN IS NOT INCLUDED. NO ACTION HAS BEEN TAKEN BY KIA IN ANY OF MY ATTEMPTS TO HAVE THEM RESOLVE THIS PROBLEM. I AM, AND HAVE BEEN, STRANDED OUT OF TOWN FOR 3 WEEKS NOW WAITING ON THEM TO MAKE SOME KIND OF DECISION. THEY HAVE OVERLOOKED EVERY WORD I HAVE SAID TO THEM ABOUT THE SALT IN MY LOCATION AND THE CARS PREVIOUS LOCATIONS WHICH CAUSES SUCH CORROSION TO A POORLY MAKE VEHICLE. THE CAR ORIGINATES FROM SOUTHERN CALIFORNIA WHERE SALT IS PRESENTLY IN THE AIR. IT THEN WAS REGISTERED IN OKLAHOMA AND THE TEXAS PANHANDLE, BOTH HAVING HARSH SNOWY WINTERS. THE CAR CLEARLY HAS BEEN EXPOSED TO ENOUGH SALT TO HAVE BEEN INCLUDED IN THE RECALL. THIS IS KIA'S RESPONSIBILITY, YET THEY ARE DOING NOTHING ABOUT IT. WHEN I CRASHED MY CAR INTO THE DITCH ON THE SIDE OF THE HIGHWAY, MY LIFE WAS PUT AT RISK. THERE VERY EASILY COULD HAVE BEEN A CAR TO MY LEFT OR RIGHT OR A POLE IN THAT DITCH. KIA SHOULD HAVE FIXED THIS PROBLEM IN ALL OPTIMA'S PUT OUT DURING THE YEAR OF THE RECALL. IT IS A SERIOUS DANGER TO ANY UNAWARE DRIVER OF A 2001-2004 KIA OPTIMA. LEGAL ACTION NEEDS TO BE TAKEN AGAINST KIA. *TR

TL* THE CONTACT OWNS A 2002 KIA OPTIMA. THE CONTACT STATED THE FRONT DRIVERS SIDE DOOR WOULD NOT OPEN AFTER IT WAS LOCKED. THE DRIVER WAS FORCED TO ENTER AND EXIT THE VEHICLE BY CLIMBING OUT OF THE WINDOW. THE DEALER WAS NOTIFIED; HOWEVER, THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGE WAS 43,000. ONCE THE DRIVER SIDE DOOR IS LOCKED IT CANNOT BE UNLOCKED FOR THE INSIDE OR USING A KEY FOR THE OUTSIDE. AFTER WORKING THE LOCK FOR SOMETIME IT MAY UNLOCK OR STAY LOCKED. WHAT WE DO NOW IS TO LEAVE THE CAR UNLOCKED WHICH IS NOT THE BEST IDEA. THE PROBLEM IS NOT GETTING INTO THE CAR BUT GETTING OUT. NO RECALL FROM KIA. UPDATED 10/26/2011 *LN *TR