2017 KIA OPTIMA Complaints

Car began hesitating and stalling, particularly from a stop. Engine light came on. Took the car to the KIA dealership for diagnosis. Was told by svc coordinator that the diagnosis indicated a bad knock sensor. The technician replaced the knock sensor, then test drove the car. It failed immediately. I was told that it would likely need engine replacement. After a few days, svc coordinator called and said that KIA recommended replacing the knock sensor (again) and perform a tuneup. They declined to replace the engine. The car runs in "limp home mode" (Kia's terminology), hesitates and stalls so as to make it very unsafe to operate. The engine on this car was replaced about two years ago for excessive oil consumption. There cannot be more than 30k miles on the new engine. KIA stated that there is a lifetime warranty on the replaced engines, but are apparently not going to honor the warranty. Car is serviced regularly and is in otherwise excellent condition.

My car is burning oil and oil is covering my spark plugs. Was mentioned about decarbonizing

The contact owns a 2017 Kia Optima. The contact stated she had noticed that the vehicle required more oil between oil changes. Additionally, the contact had noticed that oil was leaking underneath the vehicle. The contact stated that the low oil pressure warning light would only illuminate upon depressing the brake pedal. The vehicle was taken to an independent mechanic, where no oil leak was found, and the contact was advised to constantly check the engine oil level. The contact stated that upon checking the oil level recently, five quarts of oil needed to be added to the vehicle. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 133,000.

--- **Summary of Complaint – 2017 Kia Optima** My 2017 Kia Optima (VIN: [XXX] ) experienced sudden engine failure due to a damaged piston. There were no warning signs—no knock codes or dashboard alerts—prior to the malfunction. Despite regular maintenance and timely oil changes, Kia denied warranty coverage, leaving me with significant repair costs. This issue appears consistent with reported engine problems in similar Kia models and could represent a broader manufacturing defect. I'm submitting this report in hopes of prompting an investigation into a potential safety hazard. A recall may be necessary to prevent similar failures and protect INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Excessive oil consumption started at 61,000 miles, causing engine misfires and dangerous power loss on the road. Engine codes 1326 and P0304 were frequent. Despite numerous services, including sensor replacements, spark plugs and oil top-offs, the problem worsened. At 97,769 miles, the dealer said a full engine replacement is needed along with other pertinent repairs related to the engine are needed. The situation was life-threatening each time as they occurred while driving and I now no working vehicle after my husband's recent death. Kia dealerships acknowledged the defect but refused to replace the engine and advised that Kia Corporate was refusing, although no claim information was ever provided that they indeed contacted the corporate office. I am seeking NHTSA support in holding Kia accountable.

While driving my 2017 Kia Optima (Theta II engine) at approximately 115,900 miles, I suddenly experienced engine failure. The vehicle began to stall and produced a burning smell shortly before the engine seized completely. I had the car towed to a Kia dealership, which confirmed an internal engine failure and noted that there were no signs of external oil leaks or neglect. The failure occurred only 4,500 miles after my last oil change, which was documented and professionally completed. The Kia technician mentioned verbally that this was due to excessive oil consumption and burning — an issue I later found to be widely reported in other Kia vehicles using this engine type. The estimated repair cost is over $14,000, which is more than the value of the vehicle. Despite my warranty being expired, this type of failure appears consistent with known manufacturing defects. I am reporting this for public safety and accountability. The vehicle failed without warning and could have caused a dangerous situation on the road.

I previously submitted a report regarding engine failure in my Kia 2017, Optima. I’d like to update the complaint with new details. Upon mechanical inspection, it was confirmed that the engine bears Hyundai branding and has sustained internal damage including broken pistons and valve failure. These issues appear consistent with the known oil ring defect affecting Hyundai-manufactured engines used in Kia vehicles. Symptoms included: Engine knocking and rough idling Sudden loss of oil and reduced performance Full engine failure requiring replacement I believe my vehicle may have been missed in the recall or settlement programs and request this update be added to my case. I’m willing to provide repair estimates, diagnostic reports, and photos upon request. Thank you for investigating this issue further

My Kia optima fe 2017 has been consuming a lot of motor oil it takes a quart every 2 to 3 weeks and of if I drive it more than average it needs motor oil sooner

Engine is failing and using over 3 quarts of oil every 700-100 miles. Spark Plugs have become oil fouled and replaced all 4 spark plugs June 11th, 2024 and replaced all 4 spark plugs again January 12th, 2025. Today July 7th, 2025 Check Engine light came back on with Engine Misfire code P0303 Cylinder 3 Misfire, changing spark plugs again today. My safety is put at risk because oil consumption is a know issue with Kia GDI Engines. At any moment my car can run out of oil if it is not check every other week causing my engine to completely fail or a spark plug become Oil fouled and a spark plug needing to be replaced. In July of 2024 when this happened I was on the highway going 70 mph and my car just completed shut down. I could have been seriously injured had I not been able to pull over and only been 5 miles away from my home. I called Kia today to start an Oil Consumption test, stated I am the 2nd owner and while this is a known issue I will pay for and Upper Engine Clean which is only a band aid. This problem has been confirmed with Kia that the GDI Engines are consuming oil. I have also replaced all Engine Coolant, Coolant Temperature Senor, Thermostat as well as the PCV Valve.

Warning lights displayed for ABS and ESC systems. Had Autozone pull the OBD2 codes which indicated the left rear wheel speed sensor failed resulting in failed/disabled ABS and ESC systems. I replaced the bad rear wheel hub/sensor which corrected the problem. I no longer have that failed component. A few months later, warning lights came on again. I again had the codes pulled by Autozone and this time it was the right rear wheel speed sensor. I have the new part but have not yet replaced it so I could keep the defective part for the right wheel. The first one failed in April 2024 and the second in November 2024. This seems to be a bad design with two of the same parts failing in the same timeframe affecting two main safety features of the vehicle