2020 KIA OPTIMA Complaints

It is an oil burner and engine failed and went into limp mode less than 5 years when drove off dealership brand new.

Out of the blue I get a code for a misfire on cylinder one. Got in to head to work as normal and it was stalling and shaking so bad that I am scared to drive it. The next day the check engine light was on when I started it to seek out the issue. Car was manufactured in September 2019 but is the 2020 model year. I was told by a license mechanic this is related to an internal Kia engine issue. I contacted 800 333 4KIA to see if this was a known issue that they had a solution to. Of course I was told to self repair that my VIN is not covered under the recall. Can you tell me how Kia assumes that engine issues with the 2019s model year would have been fixed before the 2020 models were assembled? Sounds like my dream car is now my nightmare. 3rd White Kia Optima but I am likely leaving the Kia family if this requires a new engine.

I have kept up on regular oil changes and maintenance on my Kia which I bought new 5 years ago. My issues started when my car's orange check engine light came on, I experienced loss of power such as difficulty accelerating even at low speeds, especially up hill. As soon as I was able I checked my oil which and there was nothing on the dipstick. I put in 3 quarts of oil. I brought it into my usual dealership for service and let them know about the oil issue and issues with power when driving. They failed to address the root cause of the issue, they performed an oil change, engine light turned off, and they started an oil consumption test. But when I drove off the lot the issue with the power continued, and the check engine light came on again. I took my Kia to another dealership to address the car's power issue and the first oil consumption test was not completed because it was unsafe to drive. When I brought my car in, the check engine light was not on, even though there were significant power issues. The dealership was able to confirm my concern, including loss of power and evidence of oil overconsumption. They replaced my turbocharger under warranty. I then underwent a 2nd oil consumption test that indicated overconsumption at a level of 1.5 quarts per 1000 miles. Then they performed a combustion chamber cleaning per Kia guidelines and a 3rd oil consumption test. They 3rd oil consumption results indicated overconsumption at a level of 0.75 quarts per 1000 miles. Although the dealership acknowledged this is still overconsumption, it was not to a level that required Kia to replace my motor. Meanwhile, after all these tests my car is close to out of warranty, at 98.6k miles. I called Kia customer care and their "resolution" to my case was the deny me a new engine and they would not provide me anything in writing. My car's overconsumption of oil and other signs of engine failure match the complaints found in class action settlements related to other Kia models.

2020 kia optima caught on fire in gallipolis ohio after insurance paid to fix car it continues to leak oil stall and is dangerous to drive12/24/2022

Metal contamination found on VVT solenoid of 2020 kia optima 2.4L GDI engine. Firestone Autocare Confirmed metal debris in oiling system. Vehicle exhibits symptoms identical to prior theta II bearing recall SC172/SC200/SC227 but not covered under recall range.

My car has been burning oil rapidly. I’ve contacted kia over this issue and I have had several times where I have had to continually add oil. There is no leak. This is a known issue with kia motors across mechanics nationwide and there should be a recall issued. This has been at several shops and over the last few years. This motor should NOT be consuming 4 quarts of oil within 1000 miles after an oil change.

The contact owns a 2020 Kia Optima. The contact stated that the vehicle was experiencing excessive oil consumption. The vehicle was taken to Downtown Auto Care, where an oil consumption test was initiated. The mechanic added 5 quarts of oil to the engine and advised the contact to return after 3,000 miles. The contact stated that the low oil pressure warning light illuminated after 2,275 miles. The vehicle was urgently taken to Valvoline, where 3 quarts of oil were added to the engine. The dealer was notified of the failure and informed the contact that the VIN was not under recall. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 51,072.

The turbo system on the car burns oil at a rapid rate. Had to pay $4000 to replace and still continues to give me problems and check engine light. Violates lemon law. Had replaced in September but was giving me problems well before and finally took it to the dealer for repair

What component or system failed or malfunctioned, and is it available for inspection upon request? Engine failure. I’ve been reporting engine stalling since around 34,000 miles or so I purchased the car and immediately had battery issues before 25,000 miles as well. While I was driving on the road the engine stalled about 34,000 miles with me and my pregnant daughter in the car. The seatbelts jerked. The car stuutered and shut off and every light on the dashboard went insane. I purchased the car with 34 miles on it. Now…fast forward I’ve been having the car engine check, consumption oil tests performed and more since 60xxx miles or so. I’ve done everything that I’m supposed to do with returning the car for testing and every time I’m told I just need to wait until the engine fails. They clean the engine up make it look pretty after the second test and run some cleaner through then I’m back in a couple of weeks to months for the same thing. The engine valve cover has been replaced many times, spark plugs keep going out, and a ton more engine work that was done under warranty. Brain the service man told both me and my husband it’s what we have TJ deal with, at Suntrup, and doesn’t matter if I’m driving or not wait until the engine blows before Kia can replace the full engine. He said if you’re outta warranty that’ll be your issue. Well when I talked to Kia they said I better not drive it that way, with no oil in the car regardless how it’s brining and keep taking it in. But Bryan every time seems to not want to deal with it. Test after test and he said i just need TJ fault before we replace it. The service department has deemed this a bad engine ever trip. But I’m told it MUST PASS KIA TEST. However, I’m 7,000 miles outta warranty now and I’m praying they cover it because I did everything I’m supposed to do. I have every record however, Lou Fuze has failed to reproduce my records and I’ve requested them by text many times.

My engine is burning lg amounts of oil. There has been a lawsuit regarding the same issues with Kia engines (specifically up to 2019 Optimas). The Theta 2 engine lawsuit is regarding excessive oil consumption/burning, knock sensor issues, and deeper engine issues. This has been an ongoing issue for me and is ultimately affecting my engine. Kia will not cover the defects or repair expenses despite knowing the concerns with prior Kia Optima engines.