2002 KIA OPTIMA Complaints

DOOR LOCKS WHEN USING THE DOOR HANDLE TO OPEN THE DOOR AFTER THE DOOR HAS BEEN UNLOCKED USING KEY OR KEYLESS ENTRY. SO FAR ONLY BEEN LOCKED OUT OF THE CAR, BUT CONCERNED I WILL BE LOCKED IN THE CAR AT SOME POINT. *TR

TL*THE CONTACT OWNS A 2002 KIA OPTIMA. THE CONTACT STATED THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER 03V067000 (ELECTRICAL SYSTEM:STARTER ASSEMBLY). THE MANUFACTURER INFORMED THE CONTACT THAT THE REPAIRS WERE MADE PRIOR TO THE CONTACT OWNING THE VEHICLE. WHILE THE VEHICLE WAS PARKED THE CONTACT WAS UNABLE TO TURN THE VEHICLE OFF. THE CONTACT HAD TO DISCONNECT THE BATTERY IN ORDER TO TURN THE VEHICLE OFF. THE VEHICLE WOULD ALSO STALL WHILE DRIVING. THE VEHICLE ALSO FAILED TO START INTEMITTENTLY; HOWEVER, THE FAILURES BECAME PROGRESSIVELY WORSE OVER TIME AND FAILED TO START. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING WHERE THE TECHNICIANS WERE UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS UNKNOWN.

TL*THE CONTACT OWNS A 2002 KIA OPTIMA. THE CONTACT STATED THAT THE DRIVERS SIDE DOOR WOULD NOT UNLOCK BY USING THE KEY OR THE KEYLESS ENTRY. THE CONTACT HAD TO ENTERED THROUGH THE PASSENGER SIDE OF THE VEHICLE IN ORDER TO UNLOCK THE DRIVERS SIDE DOOR. THE DEALER NOR THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE CONTACT WAS CONCERNED ABOUT THE SAFETY ISSUE BEING ADDRESSED BY THE MANUFACTURER. THE FAILURE MILEAGE WAS 25,000.

TL*THE CONTACT OWNS A 2002 KIA OPTIMA. WHILE DRIVING APPROXIMATELY 45 MPH, THE SUB FRAME SEPARATED FROM THE VEHICLE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE MECHANIC STATED THE SUB FRAME, TIE ROD, FRONT TIRE AND RIM NEEDED TO BE REPLACED. THE MANUFACTURER WAS CONTACTED AND A COMPLAINT WAS FILED. THE MANUFACTURER ALSO STATED THERE WAS A RECALL (NHTSA CAMPAIGN ID NUMBER: 09V183000 COMPONENT: SUSPENSION: FRONT) BUT THE VIN WAS NOT INCLUDED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

TL*THE CONTACT OWNS A 2002 KIA OPTIMA. WHILE THE VEHICLE WAS BEING SERVICED, THE CONTACT WAS INFORMED THAT THE FRONT SUBFRAME HAD CORRODED. THE CONTACT CALLED THE MANUFACTURER AND REFERENCED RECALL 09V183000 (SUSPENSION: FRONT) BUT WAS TOLD THAT THE VEHICLE WAS NOT INCLUDED. THE VEHICLE HAD NOT BEEN REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 109,834.

TL* THE CONTACT OWNS A 2002 KIA OPTIMA. WHILE DRIVING APPROXIMATELY 15 MPH, THE CHECK ENGINE LIGHT ILLUMINATED ON THE DASHBOARD AND THE VEHICLE STALLED. THIS BECAME A RECURRING FAILURE SO THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE IT WAS REPAIRED. THE FAILURE CONTINUED TO RECUR INTERMITTENTLY AND THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON TWO MORE OCCASIONS WHERE IT WAS REPAIRED. THE FAILURE CONTINUES. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 95,900.

I HAVE A 2002 KIA OPTIMA THAT THE VIN IS NOT ONE OF THE VEHICLES THAT IS COVERED BY YOUR RECALL NHTSA CAMPAIGN ID NUMBER: 09V183000 WHICH STATES "INTERNAL CORROSION OF THE FRONT SUBFRAME. OVER TIME, SUCH SUBFRAME CORROSION NEAR THE CONNECTION TO THE LOWER CONTROL ARM CAN LEAD TO WHEEL MISALIGNMENT AND/OR OTHER NOTICEABLE STRESS IN STEERING...". YOU HAVE IT LISTED AS STATES WITH DIFFICULT WINTERS AND THE USE OF ROAD SALT. I LIVE IN LOUISVILLE, KY. NOT ONE OF THE NAMED STATES. BUT. I GUARANTEE YOU THAT THIS SAME CORROSION CAN BE CAUSED BY THE WATER COMING FROM THE AIR CONDITIONER RUNNING DIRECTLY ONTO THESE PARTS. THE BACK SIDE OF SUBFRAME HAS RUST HOLES IN IT. THIS RECALL NEEDS TO BE EXPANDED TO ANY AND ALL KIA OPTIMAS THAT HAVE THE AC WATER RUNNING THERE DUE TO MANUFACTURE DESIGN. I HAVE PICTURES THAT I CAN SEND TO YOU SHOWING THIS CORROSION. I TRIED TO GET IT ALIGNED AT A KIA STORE AND THEY SAID "LOWER CONTROL ARM BRACKET ON PASS SIDE IS RUSTED AND BROKEN. PASS SIDE WHEEL IS PUSHED BACK AND TIRES ON FRONT ARE ANGLED." HOW WAS THE 36,538 VEHICLES DETERMINED ? WAS IT FROM THE STATE THAT THE CAR WAS SOLD IN ? *TR

TL* THE CONTACT OWNS A 2002 KIA OPTIMA. SHE STATED WHILE DRIVING AT SPEEDS OF 30 MPH, THE BRAKES WERE APPLIED AND WOULD NOT ENGAGE. THE CONTACT UTILIZED THE EMERGENCY BRAKES IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR FACILITY WHERE IT WAS DISCOVERED THAT THE MASTER CYLINDER HAD FRACTURED. THE MECHANIC REPLACED THE MASTER CYLINDER AT THE OWNERS EXPENSE. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND CURRENT MILEAGES WERE 89,323. UPDATED 08/03/10. *LJ THE REAR WHEEL CYLINDERS, REAR BRAKES AND REAR DRUMS WERE REPLACED. UPDATED 10/12/10*JB

MY SON WAS DRIVING OUR 2002 KIA OPTIMA AND WHEEL ASSEMBLY FELL OFF. THE WHOLE FRAME RUSTED FROM INSIDE OUT CAUSING THE LOWER CONTROL ARM TO FALL OFF. *TR

THIS IS CONCERNING MY 2002 KIA OPTIMA, AND THE SUBFRAME RECALL THAT WAS ISSUED ON THIS CAR. . THE SUB FRAME WAS REPLACED DUE TO CORROSION BUT THE GARAGE HAS DONE SOMETHING WRONG BECAUSE THE GRINDING NOISE THAT IS COMING FROM UNDER THIS CAR IS JUST RIDICULOUS! I TOOK THE CAR BACK TO THE KIA DEALER WHO REMOVED THE RUSTED SUB FRAME AND REPLACED IT WITH THE NEW, TO FIND OUT WHY ITS MAKING THIS HORRID NOISE,OH YES THEY ALSO FORGOT TO PUT A BOLT IN. AND STILL DON'T KNOW WHY THE PART IS GRINDING SO. SO THEN I CALLED THE KIA CORPORATION TO LET THEM KNOW THAT MY CAR IS NOT RIGHT AND SOMETHING IS WRONG. AND THEY DID NOTHING BUT PUT IT ON THE COMPUTER I WAS NOT SATISFIED. NOW I HAVE TO TAKE THIS CAR TO A BODY SHOP AND PAY FOR THIS TO BE REPAIRED OUT OF MY POCKET. I KNOW THERE WAS NO PROBLEM WITH THIS BEFORE AND NO NOISE GOING INTO THE SHOP, I DON'T EXPECT THIS TO BE GOING ON NOW. I HAVE TAKEN THIS TO 2 BODY SHOPS ONE BODY SHOP WONT TOUCH IT BECAUSE IT IS A RECALL, THE OTHER WILL TAKE A LOOK AND SEE, HE THINKS THEY BROKE SOMETHING REMOVING THE SUBFRAME. IN EITHER CASE THE CAR NEEDS FIXING OF A PART THAT WAS SUPPOSED TO BE COVERED UNDER A RECALL! WHAT EVER IS WRONG WAS CAUSE BY THIS SUBFRAME. *TR