2002 KIA OPTIMA Complaints

TL*THE CONTACT OWNS A 2002 KIA OPTIMA. THE CONTACT STATED THAT DURING A ROUTINE OIL INSPECTION A MECHANIC DISCOVERED CORROSION ON THE FRAME. AS A CONSEQUENCE THE ENTIRE FRAME COULD COLLAPSE, WHICH INCREASED THE RISK OF SERIOUS INJURY. HE NOTIFIED THE MANUFACTURER AND WAS ADVISED BY A REPRESENTATIVE THAT THE REPAIR WAS A NON-WARRANTY ITEM, THEREFORE THEY WOULD NOT ASSUME RESPONSIBILITY. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 85,304. *LJ UPDATED 05/07/09.*JB

THERE WAS A SAFETY RECALL ON MY 2002 KIA OPTIMA REGARDING THE SUBFRAME. THE CORROSION UNDER MY CAR IS DEVASTATING. NHTSA NEEDS TO KNOW THAT THIS CORROSION PROBLEM IS EXTENSIVE AND AFFECTS MORE THEN THE SUBFRAME. KIA IS INSISTING THAT I PAY FOR THE DAMAGE THEY WILL CAUSE WHEN THEY HAVE TO REPLACE THE SUBFRAME. THIS IS A SAFETY HAZARD THAT WILL AFFECT THOUSANDS. *TR

TL*THE CONTACT OWNS A 2002 KIA OPTIMA. THE CONTACT STATED THAT THE SUBFRAME ON THE PASSENGER SIDE OF HIS VEHICLE WAS VERY RUSTY. THE VEHICLE IS UNABLE TO BE DRIVEN AND THE CONTACT HAS NO CONTROL OF THE STEERING BECAUSE THE A-ARM WAS SEPARATED FROM THE SUBFRAME. THE DEALER ACKNOWLEDGED THE FAILURES, BUT THERE ARE NO RECALLS AVAILABLE. THE FAILURE MILEAGE WAS 91,400. UPDATED 05/19/09 *BF UPDATED 05/20/09. *JB

TL*THE CONTACT OWNS A 2002 KIA OPTIMA. WHILE PERFORMING A ROUTINE OIL CHANGE, THE MECHANIC DISCOVERED THAT THE CRADLE, OR SUBFRAME, UNDERNEATH THE VEHICLE WAS RUSTING OUT. THE MECHANIC STATED THAT ANY MAJOR BUMP COULD CAUSE THE DRIVETRAIN TO COLLAPSE AND POTENTIALLY CAUSE DANGEROUS DRIVING CONDITIONS. HE ALSO STATED THAT THE ENTIRE FRAME COULD COLLAPSE AND SEPARATE THE ENGINE COMPARTMENT FROM THE VEHICLE. THE MANUFACTURER STATED THAT THE FRAME WOULD NOT BE COVERED UNDER WARRANTY AND THEY COULD NOT ASSIST WITH THE REPAIRS. THE FAILURE AND CURRENT MILEAGES WERE 85,304. UPDATED 05/06/09. *LJ UPDATED 05/07/09.*JB

2002 KIA OPTIMA SUB FRAME IS ALL RUSTED OUT DEALER SAYS TOTAL SUSPENSION IS ABOUT TO FAIL NEED TO BE REPLACED THIS IS THE ONLY THING ON THE CAR THAT IS RUSTED OUT. *TR

OUR 2002 KIA OPTIMA EXPERIENCED STEERING PROBLEMS WHICH I THOUGHT COULD BE CORRECTED WITH A BASIC FRONT END ALIGNMENT. REPAIR FACILITY INFORMED US THAT THE VEHICLE COULD NOT BE ALIGNED BECAUSE THE SUB-FRAME HAD RUST DAMAGE. THE SUB-FRAME ON THE PASSENGER SIDE HAD A "GOLF SIZE" HOLE IN IT AND THE WELDING JOINTS WERE COMPLETELY ROTTED THROUGH. THE VEHICLE ONLY HAD 70,000 MILES AND WAS ALWAYS WELL MAINTAINED. OIL CHANGES AND INSPECTIONS WERE PERFORMED AT KIA DEALERSHIPS AND THE DEFECT WAS EITHER NOT DETECTED OR NEVER REPORTED TO US PRIOR TO THE EXPIRATION OF THE WARRANTY. THE DEALER AND KIA MOTORS WERE CONTACTED ABOUT THE ISSUE; KIA DID REPLACE THE SUB-FRAME UNIT (EST COST $1,500) BUT WOULD NOT COVER THE COST FOR LABOR ($655). I BELIEVE A BIGGER PROBLEM EXIST WITH THIS DEFECT AND A RECALL SHOULD BE CONSIDERED TO PREVENT INJURY TO DRIVERS. REVIEWING PREVIOUS COMPLAINTS, THIS SAME DEFECT HAS BEEN REPORTED ON THREE VIN #'S. *TR

WAS LOCKED INSIDE VEHICLE. AFTER CLIMBING OUT WINDOW, WAS LOCKED OUT OF VEHICLE. THE DOOR WOULD UNLOCK WITH KEY THEN WHEN YOU TRY TO OPEN DOOR IT LOCKS ITSELF, EVEN WITH KEY STILL IN DOOR. WHEN THIS HAPPENS DOOR WILL NOT OPEN BY MANUAL USE OF LOCKS EITHER. *TR

AFTER BUYING THE VEHICLE FROM A AUTO DEALER BETWEEN JULY 2 AND JULY 5 ...THIS VEHICLE BEGAN TO HAVE MANY PROBLEMS LIKE THE AUDIO RECEIVER SWITCH FROM RADIO TO CD ON ITS OWN,DOORS LOCKS ON ITS OWN,RPM RUNS TO 4000 GOING 45MPH AFTER A HARD JERK ASSUMING THAT I WAS HIT BY A OTHER CAR THE AIR BAG LIGHT CAME ON AFTER THAT 2 HARD JERKS WHILE DRIVING,,(THEY DIDN'T EVEN DEPLOYED) CAN NOT PUMP GAS DUE TO FUEL KEEPS OVER FLOWING WHEN ITS BARELY EMPTY ....ITS BEEN A LIVING ?!@#$% AND I'M STILL PAYING FOR THE CAR....IS IT LEGAL FOR A DEALERSHIP TO SELL A VEHICLE LIKE THIS. *TR

2002 KIA OPTIMA, WE HAVE ONLY HAD THE CAR LESS THAN 2 YEARS AND IT HAS 2 FIST SIZE RUST HOLES IN FRAME ONE EACH SIDE BY A-ARMS, DUE TO THESE DEFECTS TIRES WEARING QUICKLY AND NEEDS AIR CONTINUALLY TO BE PUT IN THEM. HANDLING WORSENING AND MAKING THUMPING NOISE IN FRONT END, CAN NOT DRIVE OVER 35-40 MPH. CALLED KIA AND THEY SAID THEY WOULD NOT DO ANYTHING ABOUT THIS PROBLEM. READ WHERE HYUNDAI AND KIA ARE MADE BY SAME COMPANY AND THIS HAS BEEN A PROBLEM WITH THE 1999 TO 2002 MODELS. FEEL THIS IS THEIR RESPONSIBILITY TO MAKE RIGHT BEFORE SOMETHING HAPPENS AND THERE IS AN ACCIDENT. NEED INFORMATION ON WHO TO CONTACT AND HOW TO GET THIS TAKEN CARE OF. *TR

I TOOK MY 2002 KIA OPTIMA IN FOR A TUNE UP, THEY FOUND A BROKEN WATER PUMP, 5 CRACKS IN THE MANIFOLD. IT TOOK KIA 3 TIMES TO FIND THE PROBLEM. AFTER I PICKED UP THE CAR IT STILL HAD A PROBLEM TOOK IT BACK TWICE BEFORE THEY FOUND IT WAS A SENSOR PROBLEM THIS CAR IS NOT A SAFE VEHICLE. *TR