2004 KIA RIO Complaints

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

TL* THE CONTACT OWNS A 2004 KIA RIO. THE CONTACT STATED THAT THE MANUAL DOOR LOCKS ON BOTH THE INTERIOR AND EXTERIOR FRONT DRIVER'S SIDE DOORS WOULD NOT RELEASE. THE CONTACT HAD TO ENTER THE VEHICLE THROUGH THE FRONT PASSENGER SIDE DOOR AND EXIT IN THE SAME MANNER. THE VEHICLE WAS NEITHER DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 21,599.

VEHICLE WAS PURCHASED USED APPROXIMATELY 2 YEARS AGO. ON THE APPROXIMATE INCIDENT DATE, THE CLUTCH PEDAL FAILED TO ACTUATE THE CLUTCH AFTER PRODUCING A LOUD NOISE. INSPECTION AT A REPAIR FACILITY REVEALED FAILURE IN SEVERAL CLUTCH COMPONENTS AND A METAL FATIGUE FAILURE IN THE CLUTCH AND BRAKE PEDAL SUPPORT BRACKET. I AM FILING THIS COMPLAINT ON BEHALF OF MY DAUGHTER FOR THE FAILED SUPPORT BRACKET, WHICH I HAVE IN MY POSSESSION.

THE CAR CAUGHT ON FIRE, KIA SAYS THEY SENT A NOTIFICATION TO THE ORIGINAL OWNER, YEARS AGO. WE FEEL THAT WE WERE ENTITLED TO A RECALL NOTICE BEFORE THE CAR BURNED DOWN. WE FEEL THIS IS NOT A SMALL RECALL, IT WAS A FIRE, A FIRE IS VERY DANGEROUS AND CAN BURN AND KILL PEOPLE. WE HAD 22 KIAS RIOS IN OUR FLEET AND NEVER RECEIVED RECALL NOTICES ON ANY OF THEM. KIA DID SEND NOTICES TO THE ORIGINAL OWNER HOWEVER THEY HAD THE INFORMATION AS TO WHICH CARS RECEIVED THE RECOMMENDED REPAIRS AND WHICH CARS NEVER CAME IN, THERE NEEDS TO BE SOME FOLLOW UP. *TR

OUR CAR CAUGHT ON FIRE. KIA SAYS THAT RECALL NOTICES WERE SENT OUT TO THE PREVIOUS OWNER TO TAKE THE CAR TO A KIA DEALER FOR REPAIRS. NOTICE WAS SENT OUT YEARS AGO (2002). KIA KNEW THAT THE REPAIRS WERE NEVER DONE BECAUSE NO DEALERSHIP HAD BILLED KIA FOR REPAIRS. FOR NINE (9) YEARS THIS CAR WAS ON THE ROAD WITHOUT A SAFETY RECALL BEING PERFORMED FOR FIRE. FOR NINE YEARS WE REGISTERED THIS CAR AND KIA MADE NO ATTEMPT TO FIND OUT WHO OWNS THE VEHICLE. KIA IS BEING VERY UNETHICAL BECAUSE THEY SAY THAT A NOTICE WAS SENT OUT (ONE NOTICE) AND NOW THEY HAVE DONE THEIR OBLIGATION. *TR

I WAS AT A STOP SIGN AND MY 2004 KIA RIO DIED , I PUSHED IT TO THE MECHANIC AND WAS TOLD THE TIMING BELT LOST ITS TEETH AND THERE IS NOW NO COMPRESSION IN 3 AND 4 , THE MILEAGE ON CAR IS 68040. I WAS TOLD BASICALLY THE ENGINE IS TOAST AND I WASN'T EVEN MOVING ,I WAS TOLD BY A COUPLE OF MECHANICS THAT THE BELT THAT KIA USED IS FAULTY . THE OWNERS MANUAL SAYS REPLACE 60,000 MILES BUT REPLACE IT 105,000 IN CALIFORNIA. HOW WOULD A BELT BE BAD IN 49 STATES EXCEPT CALIFORNIA. I FOUND ON AUTO MD .COM NHTSA ACTION #10015272 SERVICE BULLETIN # 289221 REPORT DATING JAN 1 2005 IMPROVED TIMING BELTS FOR 04 RIO AND OPTIMA . *TR

TL*THE CONTACT OWNS A 2004 KIA RIO. THE CONTACT WAS DRIVING AT VARIOUS SPEEDS. THE ENGINE COMPLETELY STALLED AND THE ENTIRE ELECTRICAL SYSTEM FAILED WITHOUT WARNING. THE ENGINE WOULD RESTART AFTER WAITING FOR APPROXIMATELY ONE MINUTE. THE FAILURE OCCURRED ON SEVERAL DIFFERENT OCCASIONS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THEY WERE UNABLE TO LOCATE THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 78,000.

THE LEFT LOWER CONTROL ARM CAME LOOSE FROM THE CAR, PULLING THE CV AXLE OUT OF PLACE. THE LEFT LOWER CONTROL ARM WAS BOLTED BACK INTO PLACE AND THE CV AXLE SHAFT WAS REPAIRED. *TR

TL*THE CONTACT OWNS A 2004 KIA RIO. WHEN THE CONTACT APPROACHED A STOP LIGHT, THE VEHICLE BEGAN ACCELERATING AND A NOISE WAS PRESENT IN THE FRONT OF THE VEHICLE. THE TRANSMISSION WAS REPLACED ON THREE OCCASIONS WITHIN THE LAST 1000 MILES. THE DEALER INFORMED THE CONTACT THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE CURRENT MILEAGE WAS 55700 AND THE FAILURE MILEAGE WAS 30000.

TL*THE CONTACT OWNS A 2004 KIA RIO. WHILE PULLING UP TO A PARKING LOT AT 20 MPH, THE VEHICLE SUDDENLY STALLED. THE CONTACT ATTEMPTED TO RESTART THE ENGINE, BUT WAS UNSUCCESSFUL. SHE WAS NEAR A TIRE SHOP AT THE TIME AND THE MECHANIC STATED THAT THE TIMING BELT FAILED. SHE HAD THE VEHICLE TOWED TO AN AUTO REPAIR SHOP AND WAS INFORMED THAT THE TIMING BELT FAILED AND THE ENGINE VALVES NEEDED TO BE REPLACED. THE MANUFACTURER STATED THAT SHE WOULD BE RESPONSIBLE FOR THE REPAIRS. THE VEHICLE IS IN THE PROCESS OF BEING REPAIRED, BUT THE CONTACT BELIEVES THAT THE TIMING BELT SHOULD NOT HAVE FAILED WITHIN FIVE YEARS. THE VIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 80,000.