2001 KIA RIO Complaints

DRIVING IN TRAFFIC, MADE RIGHT TURN INTO DRIVEWAY AT 30 MPH AND THE ENGINE DIED, STEERING WAS NOW UNASSISTED. I ROLLED THE CAR INTO A PARKING SPOT. THE CAR STARTED UPON MY RETURN TO THE CAR. THIS HAS HAPPENED AT LEAST 6 OTHER TIMES SINCE I'VE OWNED THE VEHICLE. THE CAR HAS LESS THAN 60, 000 MILES AND HAS AMASSED NUMEROUS REPAIR ISSUES: FAILURE OF AUTOMATIC TRANSMISSION; REAR WHEEL BEARING REPLACEMENT; DEFECTIVE SIDE MIRROR THAT SCREAMS AT HIGH SPEEDS/FREEWAY DRIVING W/WINDY CONDITIONS; SUN VISORS WHICH DO NOT ADHERE TO PLACEMENT; AND WINDSHIELD WASHER PUMP FAILURE. UPON ACQUIRING THE VEHICLE THIS WAS THE FIRST PROBLEM I TOOK THE CAR IN FOR REPAIR. AND ON SUBSEQUENT VISITS, IT HAS BEEN AN ISSUE, BUT THE PROBLEM PERSISTS. *NM

DT*: THE CONTACT STATED WHILE DRIVING 40 MPH AND DEPRESSING THE CLUTCH PEDAL, THE GEAR SHIFTER WOULD NOT CHANGE GEARS AND CONTROL OF THE VEHICLE WAS LOST. IT CRASHED INTO A CURB AND THE ENGINE STALLED. THE VEHICLE WAS RESTARTED AND THE ENGINE STALLED AGAIN. THE VEHICLE WAS TOWED TO AN INDEPENDENT REPAIR SHOP WHERE THE CLUTCH PLATE WAS REPLACED AND TO ANOTHER INDEPENDENT REPAIR SHOP, WHO DETERMINED THE CLUTCH ASSEMBLY WAS DETACHED FROM THE FIRE WALL. THERE WERE REPAIRS MADE TO REATTACH THE CLUTCH ASSEMBLY. THE DEALER WAS NOT CONTACTED.

01 RIO IS A LEMON & SAFETY HAZARD. MANY MAJOR REPAIRS DONE INCLUDING THE TIMING BELT & VALVES REBUILT, NEW COOLING SYSTEM, BOTH CONTROL ARMS & BOOTS. WHEEL DEFECT RECENTLY RECALLED CAUSED EXCESS WEAR/ TEAR ON CONTROL ARMS, BOOTS, ALIGNMENT, TIRES, COSTING THOUSANDS OF AVOIDABLE REPAIRS. FUEL INTAKE DID COME LOSE, NEARLY CAUSING AN ENGINE FIRE DUE TO DEFECTIVE PART WHICH WAS RECALLED. IT CONTINUOUSLY MISFIRES, ENGINE KNOCKS, STALLS. ECM WAS RECALLED BUT DIDN'T FIX THE PROBLEM. REPLACED SPARK PLUGS & WIRES (3 TIMES IN 6 MONTHS), IGNITION COIL, SENSORS (OXYGEN, KNOCK, CRANKSHAFT, TEMP). IT STOPS FOR A 1-2 DAYS, THEN COMES BACK. ANNOYING & DANGEROUS. ALSO HAS ACCELERATION PROBLEM. AT TIMES, IT WON'T GO OVER 40 MPH & ALSO ACCELERATES BY ITSELF. BRAKES HAVE COMPLETELY FAILED, THOUGH THERE'S NO CRACK IN THE LINE, NO LEAKING FLUID. THE CAR IS A COMPLETE LEMON. ONLINE, THERE ARE HUNDREDS OF SIMILAR COMPLAINTS. DEALERS ARE AWARE BUT CONVENIENTLY CAN'T SEEM TO DIAGNOSE THE PROBLEMS ESPECIALLY MISFIRING. CONSUMERS GET NICKEL & DIMED DOING NEEDLESS REPAIRS THAT DON'T FIX THE PROBLEM. THE OPTIMA HAD SIMILAR PROBLEMS W/CRANKSHAFT POS. SENSOR WHICH WAS RECALLED, BUT DEALER DENIES ANY RELATION TO PROBLEMS WITH THE RIO. ANOTHER PROBLEM - LACK OF AVAILABILITY & HIGH COST OF PARTS. ITS BAIT/SWITCH TO SELL A CAR WITH KNOWN PROBLEMS, THEN GUESS AT NEEDLESS REPAIRS & SELL PARTS AT AN ASTRONOMICAL MARKUP. IT'S CHEAP TO BUY, BUT REPAIR COSTS MAKE IT VERY EXPENSIVE. RESEARCH SHOWS MISFIRING/ENGINE KNOCK HAS ALSO LED TO ENGINE FIRES. ALSO PROBLEMS WITH AIR BAGS. MY AIRBAG LIGHT HAS BEEN ON SINCE PURCHASED, BUT DEALER HAS YET TO FIX IT. ALSO DOOR LOCKING PROBLEMS, PEOPLE BEING LOCKED IN VEHICLES. MY DRIVERS DOOR LOCKS BY ITSELF (MANUAL LOCKS). IN CASE OF ENGINE FIRE OR ACCIDENT, A LOCK MALFUNCTION COULD CAUSE UNNECESSARY DEATH/INJURY. THESE ARE KNOWN PROBLEMS WITH HUNDREDS OF COMPLAINTS, YET KIA HAS DONE NOTHING TO ADDRESS THEM. THE 01 RIO IS A LEMON AND SAFETY HAZARD. *JB

I OWN A 2001 KIA RIO, I HAVE HAD NOTHING BUT PROBLEMS SINCE I PURCHASED THE CAR, THE DEALERSHIP REFUSES TO ASSIST WITH ANY OF THEM. I NO LONGER HAVE USE OF MY FRONT DOORS AND HAVE TO CLIMB THROUGH THE BACK DOOR TO GET INTO THE CAR. THIS HAS BEEN AN ON GOING PROBLEM. NOT ONLY THAT BUT THE SEAT BELTS IN THE BACK KEEP DEFRAYING AND ARE NOT SAFE. AND THE SEAT HAS METAL IN IT THAT HAS CUT THROUGH THE FABRIC ON THE SEATS. *NM

DT*: THE CONTACT STATED WHILE THE TIRES WERE BEING ROTATED AT AN INDEPENDENT REPAIR SHOP, IT WAS DETERMINED THE FRONT WHEEL BEARINGS WERE LOOSE. THE REPAIR SHOP TIGHTENED THE FRONT WHEEL BEARINGS. AFTER THE INITIAL FRONT WHEEL BEARING TIGHTENING, DURING NORMAL MAINTENANCE, THE LEFT REAR WHEEL BEARING WAS LOOSE AS WELL. THE REAR WHEEL BEARING WAS TIGHTENED BY AN INDEPENDENT REPAIR SHOP. THERE WERE NO PREVIOUS WARNING INDICATORS FOR THE WHEEL BEARING LOOSENESS. THE MANUFACTURER WAS NOTIFIED.

PURCHASED CAR, 2001 KIA RIO, IN OCTOBER OF 2000. WITHIN A FEW DAYS AIRBAG LIGHT CAME ON. THIS OCCURRED SEVERAL TIMES OVER A ONE YEAR PERIOD AND HAD TO BE TAKEN BACK TO DEALER FOR REPAIR AT LEAST FOUR TIMES. RECALL WAS RECEIVED FOR FUEL SYSTEM. THIS WAS REPLACED WITHOUT PROBLEM. NEXT PROBLEM OCCURRED WITH WHEELS, WHICH WAS ALSO A RECALL. I HAD TO ORDER THE WHEELS WHICH TOOK AT LEAST A MONTH TO COME IN LEAVING ME TO DRIVE TO AND FROM WORK, 65 MILES EACH WAY, ON VIOLENTLY VIBRATING WHEELS. WHEELS WERE FINALLY REPLACED. PROBLEM OCCURRED IN WINTER 2005 WITH DOOR LATCH. DRIVER SIDE DOOR WOULD LOCK AND STAY LOCKED. VEHICLE WAS TAKEN TO ORIGINAL DEALER FOR REPAIR ONLY TO HAVE OLD PART REPAIRED WHILE BEING CHARGED FOR NEW PART AND LABOR. WITHIN A FEW DAYS, DOOR LATCH FAILED AGAIN. TOOK VEHICLE TO ANOTHER DEALER WHO ORDERED NEW PART. IN THE MEANTIME I WAITED FOR PART TO ARRIVE, AND DROVE AROUND IN A CAR WHOSE DOOR DIDN'T LOCK, LEAVING MY CAR PREY TO THIEVES, WHO STOLE THINGS CONSTANTLY FROM ME. FINALLY THIS WAS FIXED BUT, THE PASSENGER SIDE DOOR LOCK DID THE SAME THING. I LOOK THE CAR BACK TO THE DEALER WHO TOLD ME THAT THEY COULD NOT FIX IT SINCE MY WARRANTY WAS UP AND TO FIX IT WOULD COST ME $700 OR MORE. I'VE ALSO NOTICED A PROBLEM WITH THE CAR STALLING IN TRAFFIC. THIS IS A NEW PROBLEM. EXAMPLE: I STOP TO GET GAS, START THE CAR AND TURN OUT INTO TRAFFIC AND THE CAR SHUTS DOWN. DURING THE WINTER OF 2005 WHILE WAITING FOR DOOR LOCKS TO COME IN, MY DRIVER SIDE WHEEL BEARING WENT OUT. THIS WAS REPAIRED BUT SUBSEQUENTLY THE NEXT DAY AFTER REPAIR WHILE DRIVING INTO WORK, WHEEL BEARING LITERALLY CRUMBLED. HAD CAR TOWED TO DEALER WHO INFORMED ME THAT AN OLD PART WAS MISTAKENLY PUT BACK ON THE CAR. THIS WAS REPAIRED AND REPLACED WITH A NEW PART. THESE ARE ALL SAFETY AND QUALITY CONTROL ISSUES. *JB

CERTAIN PASSENGER VEHICLES MAY HAVE A MANUFACTURING FLAW THAT COULD CAUSE THE WHEELS TO CRACK UNDER LONG TERM DRIVING FATIGUE. IF CRACKS OCCUR, WHEEL NOISE AND VIBRATION WILL RESULT AND BECOME PROGRESSIVELY WORSE OVER TIME. CAMPAIGN NUMBER: 05V159000 - CALLED KIA TO SEE IF MY CAR WAS UNDER THIS RECALL AND THEY SAID ONLY CARS BUILT IN 2000. WHAT I WOULD LIKE TO KNOW IS IF WE GOT ALL THE CARS BECOUSE MY 2001 RIO IS DOING THE SAME THING THAT IS LISTED ABOVE?

CHECK ENGINE LIGHT SELDOM GOES OFF. TOOK CAR TO DEALERSHIP FOR SERVICE AND TO RESOLVE THIS PROBLEM, LIGHT WENT BACK ON IN LESS THAN 100 MILES AFTER LEAVING THE DEALERSHIP. SAME THING HAPPENED LAST TIME I TOOK IT IN. *NM

(1) THERE WERE NO EVENTS LEADING UP TO THE ENGINE FAILURE (2) FOR NO REASON WHAT SO EVER, THE ENGINE JUST SEIZED WHILE I WAS SITTING AT A STOP SIGN. THERE WAS PLENTY OF OIL AND WATER IN THE ENGINE. ALL ROUTINE MAINTENANCE HAD BEEN PERFORMED. I AM NOW BEING TOLD I WILL HAVE TO REPLACE THE ENTIRE ENGINE. I AM 14,000 MILES OVER THE 60,000 MILE WARRANTY. I HAVEN'T EVEN OWNED THIS CARE AN ENTIRE YEAR. *JB

2 YEARS AGO I NOTICED THAT THE CAR DOES NOT WANT TO START WHEN IT HAS NOT BEEN DRIVEN FOR A LONG PERIOD OF TIME (12 HRS). I TOOK THE ENGINE COVER OFF AND TRIED TO START THE CAR WITH THE REMOTE STARTER. I NOTICED THAT THERE WERE SPARKS COMING FROM THE DISTRIBUTOR AND THE SPARK PLUG WIRES. TOOK CAR IN TO DEALER AND ALL WAS DONE WAS CHANGED SPARK PLUG WIRE AND PROBLEM STILL HAPPENS. DEALER JUST WANTS TO CHANGE THE WIRE AND PLUGS. *JB