2006 KIA SEDONA Complaints

Driving slowly out of parking lot a loud bang was heard. Scraping noise was heard from under van, drove about 25 yards then stopped at side of road. Left rear wheel was crooked and under van the left rear lower control arm was broken in half and was dragging on ground, left rear wheel was off ground. No one was injured, no other damage to this vehicle or others. This vehicle was previously serviced on Kia Service Campaign SC102, unknown date. Would have been serious accident if this occurred at highway speeds. Both lower control arms have been replaced, parts saved for inspection. Pictures attached. Kia was notified of this, case #[XXX]. Vehicle has one owner since new. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

BOUGHT A VAN THE NEXT DAY MY BREAKS WERE METAL ON METAL. I FOUND OUT IT WAS FLOODED. THE SECOND DAY THE KEY STUCK IN THE IGNITION, THE MIDDLE SEATS GOT STUCK AND WILL NOT FOLD UP. THE DEALER SAID THEIR MECHANIC WENT ALL OVER THE VAN AND SAID IT WAS IN GOOD CONDITION. THE CALIPERS ARE IN VERY BAD SHAPE. HE SAID THEY NEED REPLACED SOON.*DT*JB

TL* THE CONTACT OWNS A 2006 KIA SEDONA. THE CONTACT STATED THAT WHILE MAKING A TURN, A POPPING NOISE OCCURRED COMING FROM THE RACK AND PINION STEERING. NO WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND WAS DIAGNOSED THAT THE RACK & PINION STEERING NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED WITH A NEW RACK & PINION HOWEVER, THE FAILURE RECURRED. THE TECHNICIAN INFORMED THE CONTACT THAT THERE WAS A PROBLEM WITH THE RACK AND PINION. THE TECHNICIAN INFORMED THE CONTACT THAT A KIA DEALER RACK & PINION WAS TESTED AND FAILED, AND WAS UNABLE TO CORRECT THE FAILURE. THE CONTACT MENTIONED THAT SIX MONTHS AGO, WHEN THE VEHICLE WAS PURCHASED, THE RACK AND PINION WAS REPLACED. NEITHER THE DEALER NOR THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 112,000. THE VIN WAS NOT AVAILABLE.

POWER STEERING PUMP HAS HAD TO BE REPLACED 4 TIMES IN PAST 4 YEARS. NEEDS REPLACEMENT ABOUT EVERY YEAR BIT LAST 2 WERE 6 MINTHS APART. SOMETHING IS CAUSING FRICTION AND RUINING PUMPS. MAKES FLUID INSTANTLY POUR OUT AND CAR IS UNCONTROLLABLE. SO DANGEROUS

WCS ERROR . AIRBAG SYSTEM ISSUE .KIA RECALLED 2015 BUT DOESNT BOTHER ON EARLIER CARS.SOMETIMES CAR DOESNT START MANY HAVE THIS ISSUES IT HAS TO DO WITH IMMOBILIZER WIRES .AND BRAKES WITH ROTORS ARE BAD EVERY 2 YEARS BREAKS AND ROTORS GET KILLED .MY CAR HAS ONLY 56856 MLS

VAN HAS JUST OVER 115XXX MILES ON IT. HAVE NOTICED THAT TRANSMISSION HAS A WHIP OR SLIP FEEL WHEN YOU TAKE FOOT OFF GAS PEDAL AND THEN REAPPLY FOOT TO GAS PEDAL. TOOK TO MY MECHANIC AND HE STATED THAT TRANSMISSION IS SHOWING WEAR. WANTED TO REPORT DUE TO POTENTIAL RECALL IN THE FUTURE.

PAINT ISSUES WITH VEHICLE. PAINT CLEAR COAT PEELS OFF. NOTICED ON MANY KIA SEDONAS SAND JUST HAD TO HAVE VAN REPAINTED DUE TO CLEAR COAT ISSUE.

PASSENGER SIDE RR CONTROL ARM RUSTED THROUGH WHICH CAUSED IT TO BEND AND CAUSED RR TIRE TO FOLD INWARD. HAD TO REPLACE RR CONTROL ARM, RR COIL SPRING AND SHOCKS ON BOTH SIDES WHICH WAS AFFECTED BY RUSTED CONTROL ARM. I BROUGHT IT IN TO REPAIR SHOP WHEN I NOTICED A LOUD THUMP WHEN GOING OVER A BUMP. THIS SHOULD BE A RECALL.

LEFT REAR LOWER CONTROL ARM HAD RUSTED AND BROKE WHILE BACKING UP IN A PARKING LOT.

I WENT TO THE DEALER KIA ORISMAN ON JUNE 22 IN THE MORNING. YOU WILL INFORM ME THAT YOU HAVE TO MAKE AN ORDER FOR PART. I CALLED AFTER A WEEK AND THE PART HAD NOT ARRIVED. IT'S BEEN TWO WEEKS AND YOU STILL WON'T CALL ME. I WANT TO SELL MY CAR AND I CAN'T.