2016 KIA SEDONA Complaints

Rain water continually collects in both brakelight/taillight assemblies at the rear of the van. This causes the bulbs for the turn signal and brake light to burn out. This has been an issue since we purchased the vehicle in 2016. Initially, we could change the bulb(s) and they would last a while but now the passenger side bulb(s) can be replaced and burn out immediately! We have burned through dozens of bulbs since owning the van. On 6/17/25 I took the van to Valvoline in Circleville, Ohio for an oil change and replacement of the rear passenger turn signal bulb. On inspection he informed me that both brake lights were out as well as the right turn signal. He was able to replace the left brake light after dumping water out of the casing but the right side was so full of water he wouldn't even touch the bulbs because he said it would do no good. He recommended I get new casings/housing assemblies for both sides. In reading about this issue, it appears to be a problem not only for me but for many others. It was noted that several owners had holes drilled in the housing as "drain" holes and that the issue was corrected and/or improved in the later models. I believe this to be a huge safety issue due to the fact that it involves braking and turning and the increased risk of getting hit from behind.

in June 2026 sever engine knocking at startup and during slight acceleration lead us to have vehicle inspected. there were no warring lights on and no other indicators of issues. An independent mechanic as well as a Kia dealer performed inspections and indicated a lifter bearing failure due to inadequate oil delivery. at the time the oil level was within range and within 3,500 miles since the previous oil change. Dealer indicated a complete engine replacement was needed due to the bearing failure and damage to the lifters.

I am writing to report an incident with my 2016 Kia Sedona, which experienced a sudden engine failure. The failure was diagnosed with engine codes P0014 and P0018, indicating camshaft timing and crankshaft correlation issues, consistent with internal engine failure and symptoms related to the known Theta II engine defect with Kia’s of that year, including metal debris and timing issues. For many of these Kia’s the warranty was extended to 120,000 miles. My incident took place at 120,600 miles. I have maintained this vehicle responsibly, and this issue occurred with little to no warning. Though I understand the mileage technically exceeds the warranty limit, the proximity to the cutoff and the nature of the failure suggest that the defect likely developed well before the warranty threshold. I contacted Kia to request goodwill coverage for an engine replacement or the associated repairs. I believe that other customers in similar situations have received assistance under goodwill policies, especially for issues tied to known manufacturer defects, unfortunately Kia declined to open a case on my behalf.

There was a sudden loss of power while in the middle of the highway. Further inspection resulted in low oil and metal flakes in the oil filter. At the time of initial loss of power there was absolutely zero warning or indication of any issues at all.

While driving the vehicle started making a rattling sound and the engine started to fail. There were no engine lights or warning signs. The vehicle only had around 78,000 miles on it and had regular maintenance. Total engine replacement was recommended. Repair costs totaled more than the vehicle’s value. I feel it was unsafe for this to happen while driving with no warning signs of failure.

On Tuesday June 10, 2025 at approximately 11:43 am, while heading north on 75 at mile marker 148, my 2016 Kia Sedona caught fire. I initially became aware of a problem while heading southbound on 75. While listening to an audio book, my wife and I heard a sudden noise which appeared to come from the engine. I (the driver) I noticed that this noise (rattling/ ticking) only occurred when I accelerated. We pulled off at the nearest safe exit (exit 101/102 Cordele) at a Marathon gas station. I inspected the engine to see if we were low on oil or anti-freeze. I noticed that the oil was low, however we did not have any visible leaks at our home. I added 3 quarts of oil and the vehicle began making a ticking noise. I asked Siri to locate the nearest auto repair shop (Quality Auto Repair) which was approximately .5 miles away from our location. The mechanic on duty informed me that it was the engine and that because I was under 150,000 miles I could take it to a Kia dealership to have this replaced because it was a GDI engine. Instead continuing our trip south, we decided to head back toward home to take our van to a Kia dealership near our house. Approximately 42 miles into our drive back home the vehicle began to idle and then smoke came from the engine. I pulled over to the side of the road and opened the hood to investigate the potential problem and then suddenly flames came from beneath the van near the engine. I asked my wife and 14 year old daughter to exist rapidly. My wife had no issues, however we couldn't open my daughters door. She was able to successfully climb to the front and exit out of the passenger side safely. Within 10 mins or so, 70-75% of the vehicle was engulfed in flames. Prior to pulling over, none of my indicators were illuminated so there was no warning until the vehicle completely shut down. My insurance company has assessed that this is a total loss. Pics and videos are available upon request.

Odometer Fraud. The contact purchased a 2016 Kia Sedona. The contact stated that while attempting to register the vehicle, it was discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of purchase, the vehicle mileage was approximately 68,000 and at the time of registration, it was discovered that the mileage was approximately 104,000.

After driving home from work, my engine just started pouring out oil. It was all over our road and driveway. Had it towed to shop, they have stated a whole new engine is needed and suggested I report it as Kia has a lot of engine problems

Engine suddenly started knocking and shaking entire van. Engine seizing up and needs to be replaced. No prior trouble with the engine. I looked on the internet and saw that there is a petition for a recall on 2016 Sedonas. Please add me to that petition. Many van owners had engines that seized up. Since it’s a common problem for this year/make & model, there should be a recall. It’s not safe to be stuck on the side of the road with no prior warning.

On Wednesday, April 9, the van started making a noise. Then it lost power. It slowed down and then stopped. In the middle of the road. We were able to move it out of traffic. We had it towed to a service station. We were told that it was due to engine failure. I called our local Kia dealer where we bought it. He told us there were no problems with that particular engine. I looked it up online and found that that is not true. I found that this particular engine is being investigated for the same issues that I had.