2021 KIA SELTOS Complaints

Randomly started having engine issues in July 2026. Had an appt with Kia dealership and said my engine needed to be repaired with assumptions on what the problem is. They claimed it had nothing to do with the engine recall on my Kia and that it was my responsibility to pay for the repair. There has been 2 separate recalls on this car for engine issues which Kia is refusing to deal with or take care of. My car has been serviced by Kia dealership since I bought it in 2020, I also noticed in all my service receipts/reports that they were putting the wrong oil in my car and who knows if that is what caused my engine to start having issues. Car is unsafe to drive.

The contact owns a 2021 Kia Seltos. The contact stated that while driving at 45 mph the engine experienced a complete loss of automotive power, and no warning lights were illuminated. The vehicle was towed to a local dealer where it was diagnosed and the contact was advised that the engine was faulty and needed to be replaced. The contact associated the failure with NHTSA Campaign Number : 25V099000 (ENGINE AND ENGINE COOLING). The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 120,000.

While driving normally at approximately 55 mph on the highway, the vehicle suffered a sudden, catastrophic, and spontaneous structural failure of the rear driver-side suspension and drivetrain. Without striking any road debris, potholes, or other vehicles, the entire driver-side rear wheel, wheel assembly, and structural axle components completely fractured and ejected from the moving vehicle. An eyewitness at the scene explicitly confirmed the nature of the failure, stating on video that they observed the 'entire rear axle just come right out' while the vehicle was in motion. The vehicle sustained extreme structural damage, completely disabling it on a high-speed highway and creating an immediate, life-threatening situation. The vehicle is a low-mileage Certified Pre-Owned (CPO) unit with under 24,000 total miles on the odometer, indicating a severe manufacturing, material, or component fatigue defect rather than wear-and-tear. There were no warning lights or symptoms prior to the failure. The vehicle is currently being held at a recovery yard and is fully available for inspection upon request. A formal defect investigation has been initiated with the manufacturer, and the insurance provider is inspecting the sheared axle and metal components for structural forensic analysis

The contact owns a 2021 Kia Seltos. The contact stated that on March 13, 2026, the vehicle was serviced under NHTSA Campaign Number: 21V259000 (Engine); however; the spark plugs were not replaced when the vehicle was repaired. The vehicle was taken to the dealer, where it was diagnosed with a misfire in the engine associated with the spark plug. The dealer stated that the failure was not associated with the recall. The contact stated that the failure was caused by the dealer not installing new spark plugs during the recall repair. The manufacturer was made aware of the failure and stated that the recall repair was performed and was out of warranty. The failure mileage was approximately 92,000.

The contact owns a 2021 Kia Seltos. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the vehicle with the check engine warning light illuminated. The contact received notification of NHTSA Campaign Number: 25V099000 (Engine and Engine Cooling). The vehicle was taken to the dealer, where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact was informed that while the technician was attempting to start the vehicle, the engine seized, and the contact was informed that the failure was not associated with the recall. The manufacturer was made aware of the failure, and a case was filed. The vehicle was scheduled for a diagnostic test at the dealer. The failure mileage was approximately 77,500.

Purchased new, Feb, 2020. Received piston ring defect recall notice (SC209). Serviced by dealer July, 2021. In 2025, noticed engine knocking noise. Car stalling out. No warning lights. Car 3 quarts low on oil. Consumption tests proved excessive oil used. Piston ring soak (Kia's "solution") did nothing to reduce oil use. After ring soak, oil still low at 1000 mile test. I stressed my belief the engine needs replacement and a ring soak is a band aid, NOT a permanent fix. Was asked to drive 3000 miles, check the oil, and top off if necessary. The engine was noisy during this test. At the 3000 mile mark, I pulled the dipstick. Bone dry. Drove to the dealer and told them it was very low. They sent me to the lounge and said they would pull the car in and come get me. When they didn't come, I went to check, to find a service rep putting oil in my car out in the parking lot. He claimed it was only about one quart low. Then, another consumption test at 1000 miles. Low again. They wanted to do another 1000 mile check after this. They changed the oil and told me to come back at 1000 miles. When I came back, I asked to be present to witness the oil level. They took me to the lounge, said they were pulling the car into the shop, and would come get me. Again, they pulled the stick without my presence, and told me it was full. Now, they want me to do another 4000 mile test. I took the vehicle to two independent mechanics. Their borescope inspection proved engine damage. I have filed a complaint with Kia Corporate and it seems to be falling on deaf ears. I demand a full refund at this point! Kia has lost my trust, both in quality and customer service. I have all the maintenance records and a written statement regarding engine damage, along with photos from the borescope.

Car cutoff. Started back up to get off interstate. Saw smoke under hood and got it. Within 5 min sparks under the frame and then 10-15 min later flames

After getting recall work done last year regarding SC336 my sensor went off and now my car needs a new engine due to defective heat-treated Piston oil rings causing Catastrophic failure. Kia is declining responsibly because of lack of enough oil changes. They have not proved this failure was from neglect.

Just purchased a used 2021 KIA seltos with about 45k miles. I did my research and checked prior if there were any major issues. Since it showed zero recalls and received relatively good reviews I thought it would be a safe and reliable vehicle. I was wrong.I had the vehicle for only about three months when I noticed the check engine light come on while driving on the freeway. It was solid, however, I thought it was better to be safe than sorry and started to look for an exit. While driving up a freeway interchange the car suddenly started to lose speed. I pressed the accelerator but couldn’t get any power to the engine. As the car started to slow rapidly I pulled over to a narrow strip of the road. This was a dangerous stretch of the freeway because there was virtually no shoulder and cars were accelerating to merge up the rising ramp on the stack. After I came to a stop I put the car in park and turn it off. I then tried to restart the engine but had no luck. The engine would crank but would not start. I was now stuck and getting anxious as traffic began to steadily increase. Cars were flying by at high speeds less than a foot away. I had no choice but to call for a tow truck and patiently wait. I sat there praying that nobody would hit my car. I was fortunate to be safely towed to a service center.The technician performed a borescope and found severe scoring on the cylinder walls directly relating to defective piston rings. The improperly heat-treated piston rings chipped and literally carved deep grooves into the block dropping the compression causing the car to sputter and die.The engine has internal damage and will not start. Needs a new long block (Engine replacement). There is a recall on these piston rings.The dealership sent in their inspection including compression test and borescope images showing the groves and scoring on the cylinder walls. KIA is refusing to cover cost because the car is out of warranty. Safety recalls never expire with warranty!!!!!!

Car was driving absolutely fine, no dash lights no signs of distress for 1.5 years then suddenly out of the blue it made a "weird noise" -no lights on dash board, and it went away. Two days later my daughter was sitting in a fast-food line and the car just died. They had to push her out of the line. She turned the car off and when she turned it back on it started up and she drove home. We made an appointment to have it looked at but with in two days before getting to the appointment it happened again, same thing different place so she drove it home. it was looked at by Pep-Boys they told us it needs a new engine. Referred us to the recall of the Seltos 2021. We then towed it to Kia Dealership and they have confirmed it is the engine and that it needs to be replaced. The car is doing exactly what the recall was specified for and they are asking us to pay because the vin number of my daughter's car is not included in the batch of vin numbers recalled. My daughter's safety was compromised by the faulty manufacturing, the car has less than 60 thousand miles on it. We are the second owner, bought at Carvana and was certified by Carvana. I wanted to file this report to ensure all options have been explored for KIA to be held accountable for the repairs. Luckily my daughter was not hurt or endanger, but it could have easily been another story.