2003 KIA SORENTO Complaints

I WAS FILLING MY GAS TANK UP, AND AFTER ABOUT 2 GALLONS IT SPIT BACK OUT AT ME GOING EVERYWHERE. I HAVE TAKEN IT TO MANY MECHANICS AND THEY SAY THEY CANNOT FIND THE PROBLEM, SO BASICALLY I HAVE HAD TO CONTINUE DEALING WITH THIS ISSUE FOR 7 MONTHS OR SO. I HAVE GROWN TIRED OF IT AND DECIDED TO SEARCH THE INTERNET AND FOUND THAT MANY OTHER PEOPLE HAVE BEEN DEALING WITH THIS ISSUE ALSO. I FIND THAT THE GAS SPILLING OUT EVERYWHERE IS A SAFETY HAZARD IN MANY WAYS, BUT NO ONE CAN SEEM TO HELP ME OUT. WHAT SHOULD I DO? *TR

DRIVING CAR DOWN ROAD WHEN BRAKES WENT SOFT PULLING INTO MY DRIVEWAY WAS ABLE TO STOP BEFORE BRAKES WENT OUT FULLY. MY SON WAS PRACTICING FOR HIS ROAD TEST. CAR ALSO HAS CONTROL ISSUE DOES NOT FEEL VERY STABLE. FEELS LIKE IT WANT TO TIP OVER. NOISE IN FRONT END DEALER SAID YOU WILL GET USED TO IT. WHEN IT GETS BAD ENOUGH THEY MAY BE ABLE TO FIND IT. BIGGEST PIECE OF JUNK I HAVE EVER OWNED. WOULD NEVER BUY ANOTHER KIA. *TR

TL* THE CONTACT OWNS A 2003 KIA SORENTO. WHILE DRIVING APPROXIMATELY 75 MPH, THE VEHICLE BEGAN TO DECELERATE INDEPENDENTLY. THE CONTACT STOPPED THE VEHICLE AND REPLACED THE FUEL INJECTOR FLUID BUT THE FAILURE CONTINUED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTICS. THE MECHANIC ADVISED THAT THE FUEL INJECTORS NEEDED CLEANING. AFTER THE FUEL INJECTORS WERE CLEANED, THE FAILURE CONTINUED. THE VEHICLE WAS PREVIOUSLY INCLUDED AND REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 05V353000 (FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS). AFTER THE RECALL REPAIR, THE CONTACT EXPERIENCED A FUEL SPILL WHEN REFUELING THE VEHICLE. THE VEHICLE WAS NOT REPAIRED THE APPROXIMATE FAILURE MILEAGE WAS 33,387.

POWER BRAKE SYSTEM FAILED WHEN ATTEMPTING TO BRAKE WHILE GOING 15 MPH. TOOK VEHICLE TO SERVICE CENTER. THEY REPORTED THAT THE BRAKE LINES HAD RUSTED THROUGH CAUSING TOTAL LOSS OF BRAKE FLUID AND BRAKE SYSTEM FUNCTIONALITY. ONCE THE BRAKE LINE WAS PERFORATED IT COMPLETELY RENDERED ALL BUT THE EMERGENCY BRAKE INOPERABLE. LUCKILY I WAS ABLE TO STOP USING THE EMERGENCY BRAKE BECAUSE OF THE LOW RATE OF SPEED. HAD THIS OCCURRED AT A HIGHER RATE OF SPEED (E.G. 65 MPH) IT COULD HAVE BEEN DISASTROUS. ALL BRAKE LINES HAD TO BE REPLACED AT A COST OF $670. I'VE OWNED MANY VEHICLES IN MY LIFETIME WITH SIMILAR AGE AND MILEAGE, BUT HAVE NEVER HAD BRAKE LINES RUST THROUGH. I LIVE IN A NORTHERN CLIMATE (NY STATE), BUT THIS SHOULD NOT HAPPEN. FRIENDS OF OURS BOUGHT THEIR 2003 KIA SORENTO ONE WEEK AFTER WE DID. THEIR VEHICLE SUFFERED THE EXACT SAME BRAKE LINE RUST THROUGH AS WE DID LAS YEAR, WITH ONLY 40,000 MILES ON THE VEHICLE, SO I'M INTERESTED IN KNOWING WHAT PERCENTAGE OF SAME MAKE/MODEL VEHICLE HAS EXPERIENCED THE SAME FAILURE. *TR

TL* THE CONTACT OWNS A 2003 KIA SORENTO. THE CONTACT STATED THAT WHILE EXITING A PARKING LOT AT 10 MPH, THE BRAKES WERE DEPRESSED AND FELT SPONGY. THE VEHICLE FAILED TO RESPOND AND THE CONTACT HAD TO UTILIZE THE PARKING BRAKE TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO ADVISED THE CONTACT THAT THE BRAKE LINES WERE RUSTED AND FRACTURED, CAUSING THE LOSS OF BRAKE PRESSURE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 84,000.

DRIVING TO STORE AND HEARD NOISE. SEVERAL WARNING LIGHTS CAME ON AND I HAD NO POWER STEERING. RETURNED HOME AND FOUND CRANK PULLEY AND BROKEN CRANK PULLEY BOLT LAYING IN THE SKID PLATE. *TR

TL* THE CONTACT OWNS A 2003 KIA SORENTO. WHILE DRIVING APPROXIMATELY 35 MPH, A LOUD NOISE EMITTED FROM UNDER THE VEHICLE. THE CONTACT CONTINUED DRIVING AND THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THE REAR AXLE HAD COMPLETELY RUSTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND THEY STATED THE DEFECT WAS NOT INCLUDED IN THE SERVICE WARRANTY. THE APPROXIMATE FAILURE MILEAGE WAS 85,000. UPDATED 05/11/12 *BF THE CONSUMER STATED THE AXLE WAS REPAIRED. UPDATED 05/21/12

WHEN PUTTING GAS IN THE TANK, THE GAS BLEW BACK OUT WITH A FORCE LIKE SHAKING A SODA CAN AND OPENING IT. TODAY WAS THE 3RD AND WORST TIME. IT STARTED ABOUT 2 WEEKS AGO WITH THE FUEL JUST SPILLING OUT, BUT TONIGHT IT BLEW BACK OUT AT ME WITH SUCH A FORCE AS TO SPRAY GAS ALL OVER THE FRONT OF ME UP TO MY NECK. MY SHIRT WAS SOAKED, THE GAS WAS ALL OVER MY PANTS AND SHOES. BY THE TIME I WAS ABLE TO DRIVE HOME AND SHOWER, BURNS FROM THE GAS ON MY SKIN STARTED APPEARING ON MY CHEST. *TR

4 MONTHS AFTER PURCHASING THIS VEHICLE USED OFF DEALERSHIP LOT, I WAS HAVING 4 NEW TIRES INSTALLED FOR WINTER. WHEN I CLIMBED BACK INTO THE CAR AND TURNED OVER THE IGNITION, THE AIR BAG LIGHT HAS BEEN CONSTANTLY LIT EVER SINCE. *KB

TL* THE CONTACT OWNS A 2003 KIA SORENTO. WHILE DRIVING 40 MPH, THE CONTACT NOTICED THAT THE FRONT END OF THE VEHICLE BEGAN TO VIBRATE. THE VEHICLE WAS TAKEN TO THE DEALER, WHERE THE CRANK SHAFT PULLEY BOLT WAS REPLACED. THE FAILURE CONTINUED. THE FAILURE MILEAGE WAS 83,000 AND THE CURRENT MILEAGE WAS 107,000.