2016 KIA SORENTO Complaints

To Whom It May Concern, I am submitting a formal safety complaint regarding my Kia Sorento and a recurring brake light failure that poses a serious risk to my safety and the safety of my children. After every single oil change, without exception, my brake lights stop functioning properly. This has happened repeatedly and consistently. Most recently, immediately after an oil change, both brake lights went out. I replaced the bulbs, but the issue did not resolve. Instead, the lights are now stuck on continuously, which strongly suggests a failure related to the brake light switch or associated electrical components—not normal wear and tear. This pattern is extremely concerning. The fact that the failure occurs every time the vehicle is serviced indicates either a defect in the design or a component that is highly susceptible to failure during routine maintenance. Brake lights are a fundamental safety feature. When they fail, other drivers are not alerted when I am slowing down or stopping, putting me, my children, and everyone around me at risk of a serious rear-end collision. I understand that brake light switch failures have been a known issue in Kia vehicles in the past, including recalls for similar defects. Given the repeated nature of this problem and the safety implications, I do not believe I should be responsible for the cost of repairs for what appears to be a known or recurring defect. I am requesting that this issue be formally investigated and that Kia be required to repair or replace the faulty brake light switch and any related components at no cost to me. Additionally, I ask that this matter be reviewed to determine whether further action, including a broader recall or service campaign, is necessary to protect other drivers. This is an ongoing and dangerous issue that has now occurred multiple times. I should not have to worry that a routine oil change will leave my vehicle unsafe to drive. I urge you to take this complaint seriously and act quic

My car has only 68,800 miles and the dealer is telling me I need a new engine assembly i reached out to the kia corporate because I am the 2nd owner and I have had this car for 8 years and I have taken it for all the oil changes and maintenence to the dealer and have read on the website this year of car is known for it engine problems I had submitted a request for a goodwill repair for kis to replace my engine since this Cleary has to be a defect of some king with the low mileage I have on this car and I have been turned down for assistance

The contact owns a 2016 Kia Sorento. The contact stated that while his wife was driving, the battery, check engine, and oil warning lights were simultaneously illuminated. The driver reported hearing a low rattling sound and observed smoke coming from the engine compartment. The contact stated that the dealer declined to service the vehicle because the knock sensor was not installed by the previous owner. The vehicle was towed to a local dealer, where it was diagnosed with a connecting rod bearing failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 98,000.

3 to 4 months ago my truck steering wheel light with an exclamation point will appear and my steering wheel will lock up and it is hard to steer unless I cut the truck off and back on, it is so dangerous that it went out when I was in the middle of a turn that I almost ran into a truck. I cannot get this issue fixed because my warranty ran out. So what am I to do. It's terribly scary. I Haven't had it checked put i had a paper from Kia headquarters for it to be fixed free of charge within the warranty date but it has expired and I can't get it done. Something to do with the electric power steering

Shifter Lock is engaged and would not shift from park unless I bypass the lock by pressing the release. It was a recall item, I had it replaced, but if failed a few days later. I called the dealership, I told them about the problem. They told me they replaced it and I could bring it in for a $200 diagnoses fee, but it would not be covered as it was replaced already. I was made to feel like I was the one that was causing it to fail. I have the paperwork but am not sure on the accurate date.

My 2016 Kia Sorento with 2.4L GDI Theta II engine began consuming excessive oil despite regular documented oil changes. At approximately 86,000 miles, the engine failed and requires full long block replacement. The vehicle has been at a Kia dealership for 5 months while I went back and forth with Kia Corporate. I was quoted over $8,000 for replacement. Kia has declined assistance. This appears consistent with known oil consumption and bearing failure issues in the 2.4L Theta II engines. This failure occurred without warning and creates a safety concern due to potential engine stall while driving.

Dear Sir or Madam, I am submitting a formal safety complaint to the National Highway Traffic Safety Administration regarding my Kia Sorento. Over the past six months, this vehicle has required replacement of the engine, transmission control module (TCM), and the entire transmission. Although the engine and transmission were replaced at no cost to me, the extent of these major repairs within such a short period raises serious concerns about the vehicle’s overall safety and reliability. In mid-January, shortly after picking up the vehicle from the dealership following the transmission replacement, the vehicle suddenly stalled while I was driving through an intersection. The engine lost power without warning, leaving me stopped in active traffic. To get the vehicle moving again, I had to shift into park, turn the engine completely off, and then restart it before it would drive again. This unexpected loss of power in the middle of an intersection created a dangerous situation with oncoming traffic approaching. Thankfully, my children were not in the vehicle at the time. After repeated major component failures and this stalling incident, I no longer feel safe driving this vehicle. A vehicle that loses power without warning poses a serious risk to the driver, passengers, and other motorists. I respectfully request a thorough investigation into this matter, including whether there are known defects, recalls, or related complaints involving this model. I am prepared to provide repair records and documentation upon request. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The engine stalled while driving on the expressway. Myself and my daughter and her friend were in the car. The vehicle started right back up, and I was able to drive the car home (less than 2 miles away). The following day, my wife got an oil change, and went on the expressway, and the engine stalled again causing her to have to navigate the car, with no engine power, to the side of the highway and wait for myself and a tow truck. Both times were very dangerous. We had the vehicle towed to a mechanic, who said the crank shaft & rods and bearings for the engine look like they failed and seized up, causing the engine to complete lock up and stall, requiring a full engine replacement. Kia is refusing replacement saying we are not covered by the previous complaints and concerns, stating our vehicle is not covered specifically, stating that the 3.3L engines were not covered under the previous recall/extended warranty offered on engines in the same yr/make/model as our vehicle. The check engine light came on, and there was a slight knocking sound as the car was idling just before the engine stall, and as the engine stalled, the oil lamp and the battery light came on. This happened both times. The symptoms appeared just before complete engine failure. We get the vehicle serviced at Kia, and had the oil changed by Strickland Brothers the day of. We were concerned that the engine light came on due to potential of the oil needing to be changed. We do not have any electronic files or reports for this issue yet.

Steering has a "sticky feeling". While driving, when you try to turn steering wheel a fraction to one side or the other there is resistance and then a release which results in in oversteering that has to be corrected. When trying to correct the oversteering, there is again resistance and then release with oversteering again. So it constantly goes back and forth. There is a string of posts on [XXX] " with owners of the Kia Sorento having this same issue. Not only is this annoying but also unsafe. This has been going on since about summer of 2025. I do not driver this vehicle very often or I would have gotten on this issue sooner. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Our 2016 Kia Sorento had 96k miles on it, my 2.4 Liter, V4 GDI engine. I was driving it to my house on the streets, when the vehicle it completes died on me in the middle of the streets, it won't turn on, had it tow to my house. Made an appointment to take it to body shop on 2/12/2026, when it died while driving it to the auto shop, won't turn on, had it tow to auto shop. It has been burning oil for quite a while, keep putting engine oil very often. Auto shop confirmed vehicle found no codes, inspect engine oil, engine oil is very dark, manually rotated engine crankshaft, found engine seized. Vehicle has internal engine damage, possible connecting to the rods and bearings damage. Estimated repair is 9k. It is available for inspection.