2019 KIA SORENTO Complaints

Knocking noise started when pulling off the interstate. No engine light came on. No oil registered on 'dip stick'. Oil change was due at 130,449. The mileage on the car was 132,635. Had towed to Kia dealership where they said there was no test that could be done due to the vehicle being a 6 cylinder engine. They said the 'sound' points to needing an engine replacement. I inquired about a oil pressure switch test and oil consumption test due to past recalls and known engine issues. I was told due to the car being out of powertrain warrenty they would not perform such tests. I have video that shows the car is burning oil. Visible out of the exhaust. This is not something I was aware of until after this incident. These are the same issues as noted in previous recalls. Dealership said would need full engine replacement.

The contact owns a 2019 Kia Sorento. The contact stated that the oil level was constantly checked since purchasing the vehicle. The contact stated she was aware of the oil consumption because the oil had to be topped off after each oil change. The contact stated that there was no warning light illuminated. The contact had taken the vehicle to the dealer where the vehicle was purchased. The dealer performed several oil consumption tests, and confirmed that the vehicle was consuming an excessive amount of oil. The contact was informed that a local Kia dealer was contacted and informed the dealer where the vehicle was purchased, to allow the owner to drive the vehicle until the engine failed and then have the vehicle towed to the Kia dealer for evaluation. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 112,000.

I get an error message on all the forward collision and lane departure system. A mechanic has looked at this and they cannot determine the issue. They say maybe the front cameras are acting up but the car has never been in a accident that would impact the cameras. In addition the drivers mirror will not reset from the reverse setting to drive mode. When driving it needs to be manually adjusted each time in order to see.

My sorento started smelling like gas , inside & outside. Worse when I stop driving. The fuel pump pressure hose (that’s in a compartment under my backseat) is spraying fuel everywhere inside the compartment it in. The safety for myself and my grand sons that are all 2years old (3 of them) is we are inhaling the fumes from it separating steadily out under the seat their car seats are sitting on. I have not taken my vehicle to anyone but my friend after seeing a video of why a guys vehicle smelled like gas No inspection has been done by anyone I’m not even sure what steps I need to take or what to do now. There were NO messages, lights, etc., that flashed or popped up on my message center. It just all of a sudden one day started smelling like gasoline in my car. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Vehicle: 2019 Kia Sorento (VIN: [XXX] at Incident: 171,800 Description of Incident: On Sunday, August 31, 2025, at approximately 12:30 PM, my 2019 Kia Sorento experienced a sudden and catastrophic engine failure while in motion. I was driving with my two children at approximately 60 mph on Highway 111, a major highway in Palm Springs, CA. Without any warning whatsoever, no dashboard lights, sounds, or symptoms, the engine failed and the vehicle immediately lost all power. The gas pedal became completely unresponsive, and I was left to coast from highway speeds down to a natural stop. My safety and the safety of my children were severely at risk. Being in a vehicle that is unable to accelerate or even maintain speed on a major highway creates an immediate and extreme hazard for being rear-ended by other traffic moving at 60+ mph. We were a vulnerable, slow-moving obstacle with no ability to power ourselves out of a dangerous situation. The vehicle was towed to the Palm Springs Kia dealership in Cathedral City, California, where it was inspected by their service department. A certified Kia technician confirmed the cause of failure was a cracked engine valve, requiring a full engine replacement. I am the original owner of this vehicle and have a complete and documented history of performing all scheduled maintenance. This incident represents a severe safety defect, as a sudden loss of motive power in traffic places the vehicle occupants and surrounding drivers at high risk of a serious collision. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

This has to do with your investigation into the oil pan caps cracking. I had my vehicle serviced 6 months ago and KIA of York PA required me to pay for replacement. Over $150 to correct this issue that seems to be a defect.

The contact owns a 2019 Kia Sorento. The contact stated that while driving at 70 MPH, there was an abnormal knocking sound coming from the vehicle. There was no warning light illuminated. The vehicle was taken to an independent mechanic, where an oil change was performed because the engine oil level was extremely low. The contact stated that the vehicle was not due for an oil change at the time of the service. Despite the oil change, the failure worsened as the sound became increasingly louder. The vehicle was then taken to another independent mechanic and was diagnosed it with engine failure, and the contact was provided an estimate for a new engine. The manufacturer was notified of the failure but offered no assistance. The vehicle was not repaired. The failure mileage was approximately 164,000. The VIN was not available.

Adding to NHTSA Safety Issue ID # 11685509. The car was taken back to the dealership on 9/8/2025 and the maintenance department was showed were the Junction box that controls a lot of safety features could be the issue and why normal diagnostics tools used could not isolated the issue to it. Online research shows that this Junction box is a common issue and an undiagnosed issue with major safety issues. Actually the maintenance department had no clue as to were it was even located on a 2019 KIA Sonata. Please look into this issue. I am having mine replaced but it will take a week to do it. It maybe because of the unavailability because of quality fixing the issue.

The right headlight has stopped working as of 1 week ago. The car was returned to the KIA dealership for this issue as well as a hesitation while driving and a chronic bumping sound in the car while driving. The car was kept at the dealership for 3 days Sept 3,4 & 5 2025 and the headlights per the dealership were realigned. The Right headlight was on at the dealership but on Sept 6 2025 is back out. No warning showing on the dash and no warning on the dash when the light was first noticed being off. I have used all the light selector switch settings and nothing changes, moved wires on the back of the light housing, nothing. Tapped on the light front and back, nothing. My concern is the light is out so no night driving and the lack of the sensors warning the light is out. MAJOR SAFETY ISSUE.

My car is consuming oil. I was two and a half quarts down when I checked it and the oil light never came on! I'm glad I checked it when I did! The car is consuming oil and has to be checked every day to every other day. I called the local KIA dealership and of course, NO RECALLS. What do I do now?