2025 KIA SORENTO HYBRID Complaints

Incident #1: Car suddenly and without warning had complete loss of power, with gas engine shutting off and only using battery power. Car was traveling at 45mph in morning traffic. Pedal was pushed to the floor, but car would only go a maximum of 20mph. Warning dash lights then appeared saying "Hybrid Malfunction/Pull Over Immediately/Turn off car". I was able to pull off road and turn off car and then turn back on. Car ran normally the 2 miles back home. Incident #2: 2 days later, while driving my kids to school the car again, suddenly and without warning had complete loss of power, with gas engine shutting off and only using battery power. Again, warning dash lights: "Check Hybrid System. Stop Safely!". I did so and car ran normally back to my house (distance approx: 2.5 miles). I immediately called KIA of Beaverton and they said to have it towed right away. Once at dealer, they were unable to diagnose any issues and said that no codes showed up, but also said that the car "deleted codes". Car was in shop for 2 days and determined "car operates as designed." I picked up the car. Incident #3: 7 days later, with kids in the car, again car had complete power loss with no warning. Warning lights again told of "Check Hybrid System. Stop Safely!" Pulled over (in heavy Friday rush hour traffic) and turned off car. Turned on again, but this time car drove for less than a quarter mile before complete power loss happened again with all warning lights. This time we took video of the car not having power, all the warning lights etc. as evidence. We turned off the car and upon turning it on, it instantly had no power. We pulled car over and had to park it that night at a local business for towing. Car was towed again to Beaverton KIA. Again, dealer said they were not able to replicate problem after driving 250 miles on it. Insisted we pick up car, despite numerous comm's saying how unsafe we felt taking it. Dealer claimed KIA told them to remove .5 Qt of oil.

Was driving home from work, and suddenly all the indicator lights came on on the dash, (check engine, warring lights, indicator that the battery was critically low, etc etc.) the car notified me to safely pull off the road. I pulled off the road in limp mode, the engine would not engage when pedal was pressed, and then lost power. I was stuck in the middle of the lane on a side road in park. I turned the car off, then turned it back on and let it idle for a bit thinking it may be the battery (which is new). After several minutes drove it home and have not had any other issues. I researched this issue on the internet and there were reported similar problems exactly like this. Note. I put it on a reader at home and it did not show any codes.

While driving, have had the engine of my 25 Sorento Hybrid stop working. An emergency notice comes on the screen (see photo) stating to pull over safely. The hybrid system error message has come on 4-5 times in the last month. The vehicle will not drive more than 15-20 miles per hour and has virtually no acceleration making it very dangerous to drive in or around high speed/traffic areas. Took it to a local Kia dealership where I was told nothing was wrong and their only guess was that it was related to the battery and cold weather. The same messaged/incident has happened 2x since bringing it into the dealership. With the most recent being 1/22/26. Problem first arose on 1/9/26. There are dozens of reports of this in online threads over the past few months with Kia hybrid engines

My wife first drove the vehicle and started noticing intense fumes entering the cabin which required rolling down the windows. There were no alerts from the car at this time or engine lights. We checked to see if the exhaust got plugged and it was not. I later drove the car that same day and it would not accelerate when I tried to right turn onto a main road. The check engine light then popped on and loud alerting from the vehicle cause me to have to pull over and shut the vehicle off. We had it towed by the dealer and the last thing we heard was that gas and oil had leaked together and it would take 5 days to get the part to fix it.

Will be driving when it switches to EV mode it will have no power and go into limp mode. Can't go over 30 mph. This is now the second time this has happened. Dealership tried to say it was because of temperature. Come on.

Beginning at approximately 750 miles on a brand-new 2025 Kia Sorento Hybrid EX, the vehicle experienced a flashing Check Engine Light accompanied by severe shaking while driving, rough idling, loss of power, and loud engine/exhaust noise. The vehicle became difficult and unsafe to operate due to the vibration and reduced drivability. These symptoms appeared suddenly on November 22, less than three weeks after purchase. The vehicle was taken to the dealership on November 24. Their technician retrieved diagnostic codes P0300 (Random Misfire) and P0304 (Cylinder #4 Misfire) and identified a failed ignition coil on Cylinder #4. The coil was replaced, and the dealership reported the issue resolved. However, less than 24 hours later, with the vehicle still under 800 miles, the exact same symptoms reoccurred: heavy shaking while driving, vibration while idling, loss of power, and unstable engine operation. This indicates the underlying issue may be more serious than a single coil failure. The problem has been reproduced and confirmed by the dealership, and the vehicle is currently back in their possession for further inspection. A loaner vehicle was issued because the vehicle was not safe to drive. The sudden shaking, engine misfire, and loss of power created a significant safety risk, especially if this failure were to occur at highway speeds or while turning across traffic. Given the extremely low mileage and recurrence immediately after repair, this may indicate a broader defect affecting engine performance or ignition components in this model. The vehicle remains available for inspection by NHTSA, the manufacturer, or investigators.

Safety Concern – 2025 Kia Sorento Prestige Hybrid (VIN [XXX] ) Around October 13, 2025, my leased 2025 Kia Sorento Prestige Hybrid experienced a sudden and severe loss of power while I was driving on the highway. The vehicle was towed to the dealership, where the High Power Control Unit (HPCU), part number 36601-3DPG3, was replaced. No clear explanation of the root cause was provided. Less than a month later, on November 6, the same failure occurred again—this time in heavy highway traffic—creating a serious safety risk and increasing the chance of a collision. The vehicle is primarily driven by my wife, who regularly uses highways to transport our son. The recurring and unpredictable nature of this issue has made us feel unsafe and anxious. We are deeply concerned that another failure could lead to a serious accident or fatality. We respectfully request that the National Highway Traffic Safety Administration (NHTSA) investigate this matter as a potential safety defect. Without a clear understanding of the cause, we are documenting these incidents to encourage action. It is critical that Kia resolves this issue to protect families and maintain trust in its brand. Thank you INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Myself and many other 2025 Kia Sorrento hybrid owners have complaints of the lane keep assist system, causing the vehicle to wobble back-and-forth within the lane. Causing dizziness to drivers. Sometimes wobbling so much that it could cause an accident. Here is the link to the Reddit forum where other owners have complained of the same issue: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Dad, driving back with Daughter, noticed a brief and unusual delay between shifts, but was able to make it home fine. A few minutes later, Mom left for picking up Son after school. On the way there, she noticed sluggish acceleration, louder engine sounds/effort on acceleration and mild slopes, and there was a lag in acceleration response. After powering off the vehicle and sit in idle to recharge battery, restarted trip home and was unable to get acceleration response up the hills, doing only 20 MPH. Engine was struggling and not getting any acceleration response. No check engine lights were generated as usual. Dad called Service Manager at Kia Temecula and he said to call Kia Roadside Assistance to come tow the car to them. He also said that likely we'll be out of pocket to do any car rentals until they have a car to loan to us.

Driving on highway car would suddenly lose power.it has happened 7 times. 4 times the car told you to get off road pull to sideband leave engine running to have battery recharge.after doing this sometimes it would allow you to continue.not always sometimes would continue to have no power. car has been to 2 dealerships nothing resolved yet. they tell me to wait.