2021 KIA SOUL Complaints

Was issued a recall from kia for an oil piston ring that wasn't heat treated properly, kia told me the problem was fixed and the recall shouldn't affect me, my car was in an out of the shop for months after that, they replaced my timing belt and transmission under warranty, said i sould be fine between oil changes my car started knocking, i checked the oil and it was completely dry, no warning lights which is part of the recall fix is early detection warning light. I add oil to my car seems to run better for the day, the next morning on my way to an oil change the engine starts knocking the warning light comes on and then im on the side of the road with all my oil on the ground

The contact owns a 2021 Kia Soul. The contact stated while at a light the vehicle stalled. No warning lights were illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 25V099000 (Engine and Engine Cooling). The vehicle was taken to the local dealer, where it was determined that the valve train needed to be replaced. The vehicle was repaired, but the failure recurred. The vehicle was taken back to the local dealer, who informed the contact that the engine light was illuminated. The manufacturer was not notified. The failure mileage was approximately 82,000.

2021 Kia Soul | VIN: [XXX] | Recall SC336 (NHTSA 25V099) | Kia America Case No. XXX DEALER: Team Kia of El Cajon, 541 N. Johnson Ave, El Cajon, CA 92020 SYMPTOMS: Rapid oil consumption, abnormal engine noise, overheating, vehicle stalling at complete stops, difficulty restarting. All symptoms are explicitly documented in SC336 TSB (Rev 6, 10/21/2025) as consequences of defective piston oil rings. DEALER CONDUCT ISSUES: 1. CHARGED $280 DIAGNOSTIC FEE TO PERFORM A RECALL. Owner confirmed open recall on VIN before arrival. Dealer required $280 diagnostic payment as condition of recall service, in violation of 49 U.S.C. 30120. 2. 24-HOUR TSB PROTOCOL VIOLATION. SC336 TSB requires engine vibration inspection no sooner than 24 hours after R/O open date. R/O opened May 16 at 7:38 AM. Inspection report also dated May 16 with no timestamp. If test ran same day, PASS result is invalid under Kia's own guidelines. 3. FAILED TO OPEN REQUIRED TECHLINE CASE. SC336 TSB Page 2 states: if engine noise is present and inspection results in PASS, dealer must open a Techline case. Owner continues to experience engine noise. Dealer has not provided a Techline case number despite two written requests. 4. DEMANDING $2,500 FOR RECALL-RELATED SYMPTOMS. Dealer is attributing stalling and oil consumption to a separate camshaft issue and demanding $2,500 more. SC336 TSB documents that piston ring damage causes cascading engine damage including timing components. 5. OWNER IS [XXX] , drives for Uber. Vehicle out of service 12+ days. Lost income and rental costs incurred. Kia America corporate (Case XXX) has been copied on correspondence but has not responded. Requesting NHTSA review of this dealer's SC336 recall compliance. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2021 Kia Soul. The contact stated that upon starting the vehicle, the oil pressure sensor light was illuminated. The vehicle was making an abnormal knocking sound. The contact had to add additional oil. The vehicle was taken to an independent mechanic who informed the vehicle was related to the recall. The vehicle was towed to the local dealer, where it was diagnosed that the camshaft and timing needed to be replaced. The vehicle was not repaired. The contact stated that the vehicle was taken previously to the local dealer for NHTSA Campaign Number: 25V099000 (Engine and Engine Cooling). The manufacturer was contacted, who confirmed there was no warranty coverage. The failure mileage was approximately 126,000.

The contact owns a 2021 Kia Soul. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, who determined that one cylinder had low pressure while the other three cylinders had pressures higher than 100%. The contact was informed that the engine needed to be replaced. The vehicle was then taken to the dealer, who performed the recall repair under NHTSA Campaign Number: 25V099000 (Engine And Engine Cooling); however, the engine was not replaced. The piston ring was tested and passed. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 109,000.

The contact noticed the oil drained quickly and RPMs increased rapidly upon starting the vehicle. The approximate failure mileage was 86,100. The vehicle was taken to the dealer where the ECU was replaced twice, the piston rings were not replaced; the issue persisted. The manufacturer was notified of the issue. The approximate failure mileage was 86,100

The contact owns a 2021 Kia Soul. The contact stated while driving at approximately 25 MPH, the vehicle stalled. All of the warning lights were illuminated. The vehicle was taken to a dealer where it was diagnosed that the alternator needed to be replaced. The vehicle was repaired however, the failure persisted. The manufacturer was notified of the failure. The failure mileage was approximately 75,000.

took to kia of jackson for recall sc209a they said they would not do recall because i was a dealer ,called customer service and they said do to the fact that i was a dealer it would not be covered kia of jackson [XXX] kia customer service case [XXX] [XXX] [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

On [XXX], the check engine light illuminated. No other warning indicators activated — no low oil pressure warning, no low oil level warning, no driver alert of any kind regarding engine condition. On [XXX], at approximately 53,845 miles, the vehicle began running rough. I checked the engine oil and found the dipstick registered empty — no measurable oil in the engine. No low oil level or low oil pressure warning had been provided by the vehicle at any point prior to this discovery. I added two quarts of oil. The vehicle stalled while being driven to obtain the oil, and stalled again after the oil was added. I drove the vehicle to Jiffy Lube and had a full oil change performed. Mileage at the oil change was 53,852. I then scheduled an appointment with Gervais Kia in Lowell, Massachusetts, the nearest Kia dealer, less than one mile from my home. The earliest available appointment was approximately one week later. Because the vehicle stalled repeatedly at idle, I drove it to the dealer using both feet — keeping engine revs elevated with the accelerator while braking — to prevent stalling at stops. The vehicle is currently at Gervais Kia for diagnostic inspection. The symptoms match the failure mode documented in NHTSA recall campaign 25V-099 (Kia recall for 2021-2023 Soul and Seltos with 2.0L Nu MPI engines, piston oil ring manufacturing defect). My vehicle has the 2.0L Nu MPI engine and was manufactured at the Kia Autoland Hwaseong plant identified in the recall filing. However, my VIN does not appear in the current recall population per NHTSA VIN lookup and Kia’s recall lookup. The recall remedy includes installation of Piston-ring Noise Sensing System (PNSS) software specifically because the defect provides no driver warning before failure — consistent with my experience, in which the engine ran empty of oil with no warning whatsoever. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My 2021 Kia Soul experienced repeated overheating despite replacement of major cooling system components including the thermostat and water pump. The vehicle continued to overheat and was later diagnosed by a Kia dealership with engine damage requiring full engine replacement. This failure occurred around 105,000 miles. The symptoms and failure pattern are consistent with known issues affecting similar Kia engines, yet my VIN is not included in any recall. I am concerned this represents a broader defect that may not be fully captured in current recalls.