2021 KIA SOUL Complaints

What component or system failed or malfunctioned? The engine (piston rings) and catalytic converter failed. The catalytic converter is available for inspection upon request. How was safety put at risk? The engine ran low on oil without any external leak, causing warning lights and engine rattling. Low oil pressure can lead to sudden engine seizure or fire. The failed catalytic converter can clog, causing loss of power on highways and increasing the risk of a crash. Has the problem been confirmed by a dealer or independent shop? Yes. A Kia dealer found the engine 2 quarts low, with no external leak, and recommended replacing the catalytic converter at a cost of over $6,000. An independent mechanic confirmed code P0420, which indicates catalytic converter failure. Has the vehicle been inspected by the manufacturer? The vehicle was inspected by an authorized Kia dealer, but they did not complete the required inspection for Recall SC336 (defective piston oil rings). They did add the software. Were there warning lamps or other symptoms? Yes. The oil pressure warning light and other dashboard lights came on. The engine made a rattling noise. The vehicle later felt sluggish on acceleration, fuel economy dropped, and the exhaust developed a smell. The check engine light came on and later turned off, but code P0420 was stored in the system.

The car rpm fluctuated from 1000 to 5000 rpm while in cruise control going 65 mph. At a stop, thr transmission took 30 seconds to engage to low speed. The car was stuttering and bucking at 10mph to 45mph

Hi my vehicle was stolen and the police found the vehicle. The car was damaged part of the damages was a broken ignition. I am unable to fix the damages until I get paid from the kia classaction lawsuit. The car still starts and stays running. I have the key for the car but I have been starting the car was butter knife bc it's easier then the key. I made an appointment to have the oil piston ring looked at. When I brought it I. They refused to look at it bc it has a broken ignition. I don't think the safety recall has anything to do w the ignition. The car is easy to turn on and shut off. I wouldn't care if my car wasn't stalling at traffic lights. My car is going thru a lot of oil. I am not working currently. This car was purchased for me by my dad. He paid cash for it. He bought it bc I had just been diagnosed w a rare autoimmune disease. He bought it so I would have something safe and reliable to drive in. We have had nothing g but problems since day 1. All I wanted was for them to look at it so im not going to be in harms way. Idk what to do the dealership said they cant look at it until I fixed the ignition. But like I said I won't have money to do that until I get the class action lawsuit.

I am filing a complaint regarding a safety recall (NHTSA Recall 25V099) on my 2021 Kia Soul that was marked as completed, but the defect was not properly repaired. On 3/17/26, I took my vehicle to a Kia dealership to have the recall addressed. The dealership performed only a software update and diagnostic testing and marked the recall as complete. No engine repair or replacement was performed. Within approximately one week of this recall service, my engine suffered a catastrophic failure while driving, resulting in a hole in the engine block and total engine failure. This created a serious safety risk due to sudden loss of power and fire hazard. I then had the vehicle inspected by a second Kia dealership. They informed me that the engine failure was consistent with the defect described in recall 25V099 (piston oil ring failure) and that the prior recall repair did not correct the underlying issue. This indicates that the recall remedy performed on my vehicle was incomplete or ineffective, and that the vehicle was returned to me in an unsafe condition. I am concerned that other vehicles may be receiving only software updates without proper inspection or repair, which could lead to similar dangerous failures. I am requesting that this situation be investigated as a failed recall remedy and a continued safety risk. Timeline: 3/17/26: Recall repair performed (software update only) 3/29/26: Engine failed catastrophically 4/2/26: Second dealership confirmed failure related to recall defect

Manufacturer defect: Massive paint delamination/adhesion failure on the roof. Large sheets of paint are flaking off while the vehicle is in motion, creating a debris hazard for following drivers and distracting the operator. The failure has exposed the bare metal structure, which may lead to premature rusting.

Mi carro hay veces que prende la luz de la engine, lo lleve a checar y salió en la computadora que era un problema de Power Train system, que era secondary DTCs P1C28 Y P1C28000, lo busque en Google y salía que era un problema muy recurrente en Kias souls y sorentos. Que podría causar incendios

The contact owns a 2021 Kia Soul. The contact stated that while driving approximately 80 MPH, the vehicle unexpectedly stalled, with the check engine warning light illuminated. The vehicle was restarted; however, the failure reoccurred. The contact stated that while driving uphill, the vehicle failed to accelerate as needed. The vehicle was taken to the dealer, where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and case was opened. The approximate failure mileage was 41,000. The VIN was not available.

I am writing to formally report a failure by Classic Kia of Streetsboro to provide the federally mandated safety remedy under Recall SC336 for my 2021 Kia Soul (VIN: [XXX] ). I have reason to believe the dealership has bypassed the mandatory safety protocols by intentionally omitting my documented diagnostic data—specifically Codes P0014/P0017, engine stalling, and excessive oil consumption—from the Techline Case Narrative. Evidence of Non-Compliance: 1. Improper Component Installation: Despite the documented timing failures, the dealership appears to have installed a Short Block (Part # 21102) instead of the required Long Block Assembly (Part # 21101-QQK). This leaves my oil-contaminated camshafts, valves, and VVT solenoids in the vehicle, posing a continued stalling risk. 2. Failure to Address Consequential Damage: The dealership is attempting to charge me a $99 "Customer Pay" fee for a catalytic converter back-pressure test. Under SC336, testing for consequential damage caused by a defective engine is the manufacturer's responsibility. 3. Withholding Documentation: The dealership has refused to provide the Techline Case Number or the Engine Part Number upon request, preventing me from verifying that the safety remedy was performed correctly. I will not be taking possession of the vehicle until Kia Corporate verifies that a Long Block Assembly was installed and that all diagnostic fees related to the recall symptoms are waived. This matter is currently being escalated but could definitely use your assistance. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA SAFETY COMPLAINT: RECALL SC336 (CAMPAIGN 21V-301) NON-COMPLIANCE VIN: [XXX] I. PATTERN OF RECALL EVASION Vehicle (2021 Kia Soul) was towed to Classic Kia [XXX] ) on 3/13 with documented engine stalling, knocking, and codes P0014/P0017 (VVT/Timing failure). The dealership withheld this data from Kia Techline for 13 days (3/13–3/26), delaying the safety remedy until state authorities intervened. II. MECHANICAL IMPOSSIBILITY & REMEDY VIOLATION On Saturday 3/28, the dealer claimed a full engine swap was "installed and tested" in only 6.5 hours (7:30 AM–2:15 PM). Per the SC336 mandate, a compliant Long Block assembly (Part # ending in QQK) requires extensive fluid flushes, software reflashing, and safety recalibrations that cannot be performed correctly in this window. I suspect a "Short Block" shortcut was taken, reusing contaminated components in violation of the federal safety remedy. III. FRAUD BY OMISSION & UNIFIED SAFETY HAZARD The dealership is demanding a $99 "diagnostic fee" for an exhaust back-pressure test. Under SC336, testing for "consequential damage" (clogged catalytic converter) caused by the recall defect must be covered by the manufacturer. By omitting the stalling/timing symptoms from the initial Techline report, the dealer bypassed the mandatory exhaust safety testing. Reusing oil-contaminated VVT solenoids, camshafts, and valves from the failed engine poses an immediate fire and safety hazard. IV. DEMAND FOR INVESTIGATION I request NHTSA oversight to ensure Classic Kia provides: 1. Proof of Long Block (21101-QQK) installation vs. unauthorized Short Block (21102). 2. Time-stamped DEVT and GDS Full System Scan logs from 3/28. 3. Verification that all contaminated components were replaced, as a partial remedy leaves the vehicle in a hazardous state. Reusing oil-soaked VVT/cams & skipping exhaust tests creates a fire risk. An incomplete remedy violates SC336, leaving the car a high-risk liability for fire & stalling. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S

The contact owns a 2021 Kia Soul. The contact stated that while driving approximately 40 MPH, the vehicle started losing automotive power. The message that the engine was overheating warning was flashing on the instrument panel with an audible chime. The contact pulled over but was unable to restart the vehicle. The vehicle was towed to a local dealer and was diagnosed with engine failure. The contact stated that the VIN was included in NHTSA Campaign Number: 25V099000 (Engine and Engine Cooling); and was advised by the dealer that the engine failure was not related to the recall, and the dealer refused to perform the recall repair. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was unknown.