2021 KIA TELLURIDE Complaints

In December of 2025 at approximately 95,000 my 2021 Kia Telluride (VIN [XXX] ) showed the oil level was about two quarts low. My car has had regular maintenance including oil changes at Santa Fe Kia. At the next oil change appointment in March, I pointed out the oil consumption concern. At that point Kia recommended an oil consumption test be performed. The car had 96,700 miles at that point. At 97,700 Kia indicated that the oil level was fine. At 99,600 I checked the oil and discovered it was more than two quarts low. I called Santa Fe Kia to address the issue and they indicated that a quart every 1,000 miles is within Kia standards and recommended another oil consumption test which would take me over the 100,000 warranty. I called Kia customer care to address the issue. A case was opened, but they kept referring me back to the dealership to be dealt with. After researching the issue myself, I presented the well known and documented oil consumption issue amongst Kia consumers to include PCV valve and piston ring issues. I have an appointment scheduled for 4/16/26, but I am being told that I will be liable for the cost of the PCV valve replacement, compression test and oil leak test which are all known issues related to the problem. Santa Fe Kia's service manager is ignoring my request to submit an engine warranty claim citing that they didn't find a problem outside of Kia's acceptable oil consumption and Kia's customer care refuses to open a claim and keeps referring me back to the dealership. I will be at approximately 99,850 when I arrive at my appointment on 4/16/26. I am concerned that the engine has a major issue and will be told that my warranty is over by the time the issue can be determine and resolved. I am also concerned that there has already been engine damage done without noticing the high oil consumption. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Kia has 110,000 miles on it. We’ve regularly changed the oil at 3-5k mile intervals. A week ago, I heard loud knocking from the front of the car, along with loss of power. We drove it to our local Kia dealer (Kia of Bedford, OH), where upon inspection, they found cylinder bank 2 to be inoperative due to loss of oil. They found approx 2 quarts of oil in the engine - way below normal. They observed NO oil leaks. We inspected our garage and driveway floors, and there is no indication of any oil leaks. The Kia dealer said the engine needs to be replaced, at a cost of $12,700. I contacted Kia Customer Care, and they said it’s out of warranty and they won’t help. I replied back with an appeal to escalate to a higher / regional level for help. The oil had been changed at 105,000 miles. No oil leak present. Routine oil changes performed. This engine should never have had this issue at 110,000 miles. I know this is a known issue with this era of Kia engines. I’ve asked Kia to provide assistance in a repair.

Hello, I've contacted customer service for Kia America and also, customer service in Puerto Rico since I'm a resident in Puerto Rico, so that I can address the safety recall with number SC303 and also a technical service bulletin with number BOD319. However, customer service advised that they can't pull up my SUV vehicle information with the VIN provided. I'm unable to address the safety recall and the technical service bulletin since Kia can't pull up the vehicle information. My vehicle is experiencing technical failure with the intermediate shaft as described on the safety recall. Also, the sunroof is experiencing technical difficulties compatible with the information included on the TSB. I ask for your support to address the described issues, accordingly. Thank you!

I have 2 issues going on with my vehicle. The trim on the outside of my doors is coming off which I know was a recall for some telluride vehicles about this old. Also ive been having some electrical issues/hot smell like something is burning if the heated seats get turned on.

Recently our 2021 Kia Telluride, had a fluttering/metal knocking/mechanical sound and I scheduled a shop visit at our trusted local mechanic. After their inspection, they found that the oil was extremely low and there was metal shavings in the oil filter housing. This was found when absolutely no warning lights were activated that would indicate low oil level or any other engine challenges. The vehicle is maintained with regular oil changes. The vehicle only has 65k miles. Looking further into this online, it seems very similar to the Theta engine recall from Kia. No warning lights/indicator lights, well maintained vehicle with regular oil changes, and to all of a sudden consume almost all the oil and have metal shavings in the oil filter housing is extremely concerning. As of 4/6/2026 the dealer is assessing the vehicle and coming up with a plan and or further actions to be done.

Code P0087 on a Kia Telluride indicates that the fuel rail pressure is too low. This means the engine is not receiving enough fuel, often resulting in poor acceleration, stalling, rough idle, and decreased power. It is frequently caused by a faulty high-pressure fuel pump... This is the code is threw when it stalled in busy traffic on a hill. The CEL came on at this point. Then continued to stall. Before this incident, it would periodically stall while in park, or rough idle and prolonged startup. However, this was sporadic and couldn't be recreated when taken to a mechanic. We were coming back from vacation with 5 kids in the car ranging from a baby to a 12 year old. It was towed BY Kia to the nearest dealership. They claimed the recalls were addressed and the software updates cleared the codes. I came home tonight and it almost immediately started acting up again. This is a known and recognized issue in certain other vehicles (like the Sedona) and has been given an extended warranty. I'm not sure why this isn't addressed in all their GDI vehicles with these High Pressure Fuel Pumps. I'm afraid of it dying and being stranded in the heat again with young children, as well as being hit when/if it stalls.

I have 2021 Kia Telluride with 38000 miles on it. When I wash my car, I normally wash the roof and in order to do that I put one foot on 3 step ladder and one foot on the back tire. I always had a plenty space above the tire and under the fender and I could stand up on the tire while I was washing the roof. On my last wash after the harsh winter weather, I notice I can not place my foot on the tire anymore. I google the height from the bottom of the fender to the ground and I noticed is way down. I read on Google that is covered by KIA for 15 years or 180000 miles. I contacted the Riverhead Kia and they replaced the shocks. When I came out of the dealer I immediately noticed the height has not been improved. I informed the service advisor, he said that is not going to be like a new 2026 vehicle and it should be Ok. Two days later over the weekend I noticed Roaring sound and when I hit the bump it seems my chasing banging on the axle. I am planning to go back to dealer tomorrow.

I am a 2nd owner of a kia telluride and the engine failed without warning at less than 90,000 miles. No check engine light, no temp gauge, no low oil level light. No warning at all. Just failure of the "push rod bearing" ny Kia was regularly maintained and when I took it to the dealership, they told me it was down about 3.5qts of oil! Again no low oil light? It holds 7qts...9,000$ later out of my pocket after being denied a goodwill engine replacement from kia to put a new motor in. I have found many others on on-line forums who have experienced this. Please help

Sunroof mechanism failure in May 2025. Had sunroof repaired and paid out of pocket at KIA dealership. The sunroof was off track therefore the roof was exposed to elements. March 2026 sunroof mechanism has broken again. Sunroof has not been operated since repair in May 2025 for fear of getting stuck open again.

Driving on the highway when all the lights on the dashboard came on and heard a loud sound. Pulled over and noticed flames coming out. The front part of the car 911 was called. An incident report was made. The flames were out quickly. The car was towed and is at the dealership.