KIA Complaints

While driving at speed, I heard a pop noise from the car. A few seconds later, I received notification to check vehicle electric system. The vehicle slowed down despite my increasing throttle input. I was able to limp to a parking lot where it was flat bed towed. This experience matches a previous issue I had when it was diagnosed with an ICCU failure with the same vehicle.

The contact owns a 2023 Kia Sorento. The contact stated that while driving approximately 40 MPH on several occasions, the vehicle stalled after the battery became drained. The vehicle was able to restart each time after waiting for the battery to recharge. The vehicle was taken to two different dealers on three occasions. During the first two visits, the dealer was unable to duplicate the failure. On the third visit, the failure was duplicated, but the dealer was unable to provide a cause for the failure. During a visit to the dealer, the vehicle stalled while a mechanic was driving it, and the vehicle was towed back to the dealer. The manufacturer was not notified of the failure. The failure mileage was 25,000.

SUBJECT: Engine ? Stall ? Loss of power while driving: While driving normally, the vehicle began losing power and could not accelerate properly. The engine warning light illuminated and the vehicle repeatedly entered a reduced-power condition where it could barely maintain speed. The vehicle would stall while driving and then restart after sitting. This occurred multiple times over a period of time and progressively worsened. The engine also began consuming large amounts of oil between oil changes. Eventually the engine suffered catastrophic failure and would no longer run. A dealership later stated internal engine damage was present, including a failed valve and spark plug damage. The vehicle is currently at a dealership and available for inspection. The loss of power and stalling created a safety hazard because the vehicle could not maintain normal traffic speed and could have been struck by other vehicles. The problem was confirmed by a dealership service department. Warning lights were present prior to final failure and appeared during the loss of power events.

I originally got my car 2023 from Carmax I took it in to Kia dealership to get my recalls done they kept my car for over 6 days without fixing it when I arrived I was showed a photo saying it’s after market parts on this vehicle and we can’t touch it also they stated my vehicle was dangerous to drive so I asked for documentation that my vehicle was denied and they refused also I called Kia cooperate to file a complaint to get proper documentation that my vehicle was denied they told me it was denied as well and said they can’t give me paperwork to state anything

On Saturday February 7th, while driving home, the vehicle suddenly caught fire without any warning. Within moments, the fire intensified, and I was forced to jump out of the vehicle to save my life. Shortly afterward, the vehicle exploded. The car was completely destroyed. Every item inside was charred, and I barely escaped with my life. A police report was filed. Both the manufacturer and insurance company were notified as well as the bank that the vehicle was purchased from. There were no warning lights or messages prior to. When the vehicle caught fire, all warning lights came on at the same time. Following this incident, I began researching similar cases and was alarmed to learn that fires and engine-related failures appear to be a common issue in this model. Despite this, I was never notified of any recall, safety advisory, or service campaign related to fire risks. Had I been informed, I would have taken immediate action to prevent such a catastrophic and dangerous event.

Engine would run fast and then sound like was going to stop and then it would start shaking and rumbling while driving on highway and in town. Car would stall while at a stop. Gas smells inside the car. Did not feel safe driving. Had the car towed to an independent garage on February 7th and They did an oil change, change 2 Sensors, changed all the spark plugs and changed all 4 Cylinders and on the way home from Starks garage the car was doing the same as before going to the garage with gas smells inside the car, shaking, rumbling and stalling of the engine. And the car wanting to stall while on the highway speed limit of going 60 mph. the next morning My mom and stepdad had the car towed again to another mechanic close to them at Hudson Import Automotive -Napa Auto Care and they emailed a list of problems after inspecting the car. Attaching the list of codes from a diagnostic test from Auto Zone Store # 00791 , and the Estimate for Service from Hudson Import Automotive - Napa Auto Care. Have no paperwork from Starks mechanic shop.

Re: Formal Complaint – Repeated Engine Failures and Unacceptable Service Delays Vehicle: Kia Sorento 2014 VIN: [XXX] Purchased: Fall of 2021 Current Issue: Vehicle in service at Kia of Lincolnwood since January 9, 2026 Dear Kia Consumer Affairs and Legal Department, I am writing to formally document my severe dissatisfaction with the repeated engine failures in my Kia vehicle and the complete lack of communication and urgency from both Kia of Lincolnwood (6750 N Lincoln Ave, Lincolnwood, IL 60712) and Kia's consumer support channels. This has caused significant financial hardship, disruption to my family and work, and eroded any trust in the brand. I purchased this vehicle approximately 5 years ago through CarMax. Within that time, the engine has died or stalled three times: The first failure occurred about one year after purchase, stranding me at 11:00 p.m. in rural Wisconsin during winter with my three young children in the vehicle. The second incident happened in downtown Chicago (River North), just one hour before I needed to depart for a work event in Champaign, IL, requiring a tow and last-minute rental arrangements. The most recent failure occurred at approximately 4:30 a.m. after leaving my music studio, necessitating another tow and a $50 Uber ride home. Eleven months ago, Kia of Lincolnwood replaced the knock sensor under a one-year recall warranty. Despite this, the engine issues persisted. On January 9, 2026, I brought the vehicle to Kia of Lincolnwood for the third major engine-related failure. It has now been in the shop for nearly six weeks with no meaningful updates on diagnosis, repair timeline, or resolution. I have called the dealership at least ten times seeking callbacks from my assigned service advisor (Max) or any team member. In each instance, I was either hung up on, placed on hold for over an hour, or promised a return call that never came. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

We are the 2nd owner of 2021 Kia Soul bought in July 2025. Took to a dealership for open recalls shortly after purchase. After supposedly passing the piston ring recall (NHTSA 21V259) for the next several months after it had severe oil consumption but other wise drove fine. Then immediately after our last oil change on Feb 13, 2026, less than 10 miles later the car stalled and was knocking badly. Towed to nearest dealership and after diagnostic was told engine needs replacing. Wants us to pay for it. The software update (Piston Ring Noise Sensing System or PNSS) installed during the recall visit did not fix the faulty piston rings and also failed to give any warning for the impending engine failure. We never had any check engine or oil pressure lights come on until this incident.

When parked and cutting the car on check driver assistance system come on, check and, and esc comes on. The parking brake does not go off and malfunction. When trying to move the car sometimes it still drives and sometimes the parking brake will not allow you to move until the system resets its self. There are 6 codes that appear. Started in December 2025 have taken car to the dealership 3 times and they report back because the codes are no longer present they can not fix it.

Front sunroof suddenly shattered while going down highway. Remaining glass was pushed outward and no sign of impact was seen.