KIA Complaints

I believe my car should be in the ac recall for faulty ac motor/wire harness due to my ac is only cooling on passenger side. Blowing hot on driver. I’m afraid it may catch fire as I read this can happen.

The contact owns a 2025 Kia Carnival. The contact stated that while driving at an undisclosed speed and coming to a complete stop, the vehicle shut off. There was no warning light illuminated. The vehicle was restarted and driven back to the residence. The following day, the vehicle shut off again and was restarted after several attempts. The contact had taken the vehicle to the dealer on several occasions; however, the dealer was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 34,967.

I am submitting this complaint regarding a serious safety concern involving my Kia Telluride and the recalled front power seat motor/fire hazard. We are parents of three children, and this vehicle is used to transport our family. We are extremely concerned about the potential for a vehicle fire caused by the defective seat motor and the fact that the issue has not been adequately remedied. Kia has previously issued a recall addressing the potential for the front power seat motor to overheat, melt, and potentially cause a fire. Despite the previous recall and attempted remedy, Kia has now issued another recall concerning the same or substantially similar safety issue. This raises serious concerns regarding the effectiveness of the original remedy and whether affected vehicles were actually made safe after the initial recall repair. According to information from NHTSA, vehicles affected by this issue have experienced incidents involving melted seat motors and seat fires. NHTSA has also advised owners of affected vehicles to park outside and away from structures because of the potential fire risk. As parents of three children, we find this particularly alarming. A vehicle fire is an extremely serious safety hazard, and the possibility of a fire developing in or around the seating area presents an unacceptable risk to our family. If a fire were to occur while our children were passengers, evacuating three children from the vehicle could be extremely difficult and dangerous. Our concern is not simply that the vehicle requires a repair. Our concern is that a known safety defect has already been subject to a recall and remedy, yet the safety issue has apparently continued or required another recall. Consumers who complied with the original recall should be able to reasonably rely on the manufacturer and its authorized repair facilities to have corrected the safety defect. 2024 Telluride 5XYP3DGC6RG524189

I am writing to formally report a serious, recurring safety defect involving the Heating, Ventilation, and Air Conditioning (HVAC) system in my vehicle. The system intermittently shuts off completely without warning and suffers from a malfunctioning airflow diverter. This directly impacts driver visibility due to immediate windshield fogging or the inability to de-ice during cold weather conditions. Below are the logged details of the intermittent shutdowns: July 9: System shut off 22 minutes into the drive. Local time: 07:58. Ambient temperature: 76°F. Vehicle settings: 72°F, Fan Speed 3.July 11: System shut off 34 minutes into the drive. Local time: 17:10. Ambient temperature: 92°F. Vehicle settings: Low, Full Blast. Furthermore, the airflow diverter is partially stuck on defrost mode. Air constantly blows onto the front windshield regardless of the chosen setting on the selector. This uncommanded airflow creates rapid temperature differentials on the glass, causing severe condensation and clouding the driver's line of sight during operation. These compounding HVAC failures constitute a significant safety hazard by unexpectedly distracting the driver and severely reducing visibility. I request that these issues be documented and investigated for potential safety recalls. Currently, my vehicle is in the shop with a local KIA dealership. A KIA corporate service technician is on ground and investigating the electrical and HVAC issues. Feel free to reach out for additional observational notes that I have compiled.

The contact owns a 2013 Kia Optima. The contact stated that while driving 30 MPH, the steering wheel was difficult to turn. There was an abnormal clicking sound coming from the vehicle and the vehicle was uncontrollable. The vehicle was towed to the local dealer, where it was diagnosed and determined that the coupling in the steering wheel needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and confirmed that there was no coverage under the warranty extension for the MDPS flexible coupling. The failure mileage was approximately 139,000.

The contact owns a 2026 Kia K5. The contact stated that while driving 80 MPH, the front driver's side door independently unlatched and swung open. The vehicle was taken to the dealer; however, the failure was not duplicated. The contact was informed that the door latches were being replaced. The manufacturer was not made aware of the failure. The failure mileage was approximately 15,440.

2015 KIA Sorento v6 engine failed and seized. VIN was not included in KIA extended warranty offered for this year and engine.

My car has very high oil consumption. I regularly take it for oil changes and have never missed an oil change. In between oil changes I need to put anywhere between 2-3 bottles of oil in. I have taken it in to the dealership for a couple of oil consumption tests that both failed step one so they kept it overnight and did some kind of flush or cleanse and then it passed step 2 both times. The car is good for a little while and then it starts consuming alot of oil again. Due to the high consumption of oil my catalytic converter is going bad and the engine seems very sluggish at times. I do have a yellow check engine light constantly on and the code is for the catalytic converter due to high oil comsumption. The dealership told me they can't do anything about the warning light until it starts to flash yellow instead of being solid yellow. I brought it into the dealership for that and they acknowleded my year make and model are known for excessive oil consumption which can cause the catalytic converter to go bad. They won't do anything about it because it passes step 2 of oil consumption test. but they keep giving me a hard time about just permanently fixing it under the warranty since it passes step 2 even though I am back months later for the same problem. I feel they are trying to run my warranty out so they won't have to fix it. My car now won't pass an emissions test because of the catalytic converter.

The contact owns a 2020 Kia Soul. The contact stated that while driving approximately 55 MPH, the check engine and oil warning lights illuminated, and the vehicle stalled. There was smoke coming from the engine compartment. The vehicle was pulled over to the side of the road, and two hubcaps were damaged, and the vehicle was restarted. The vehicle was taken to the residence. The contact stated that when the vehicle arrived at the residence, there was no oil inside the engine. The contact added oil to the engine, and the vehicle was taken to the dealer. The vehicle was not diagnosed. The contact stated that an oil change was performed at approximately 54,000. The manufacturer was not notified of the failure. The failure mileage was 56,375.

This is a bran new vehicle purchased and only driven by me. I have video evidence that on the morning of 8/10/26 my windshield was perfectly fine. On returning at the end of the work day there is a 2 foot long crack internal to the windshield, a stress crack, that starts where the sensor panel is. There are numerous reports of this happening to a large number of Kia Carnival owners and Kia refusing to warranty this.