KIA Complaints

My vehicle has a recall that says potential fire could occur yet there’s no solution for the recall. I think that is something that should be replaced immediately considering it’s 15 degrees outside and I have to run my heat in my vehicle.

My 2015 Kia Optima (VIN [XXX] ) experienced sudden engine failure and stalled while driving at approximately 90,000 miles. There was no oil pressure warning light and no knocking prior to failure. The check engine light illuminated shortly before the stall. Kia is denying engine coverage solely because an ECU/KSDS update was not performed. I was never notified of this update because Kia had an incorrect address on file for me. This failure is consistent with known Theta II connecting rod bearing defects that have resulted in recalls and warranty extensions. I believe this is a safety-related defect and am requesting review. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Took car to Kia for an oil change and car started driving weird . Rpm hand running high. Check engine light came on , took car to Kia and fuel tank was expanded . Car is still not fixed , and Kia won’t continue to pay for rental.

Engine suddenly started making a lot of clattering noise. Oil consumption has been extremely high! Mechanic stated engine needs replaced.

I am submitting a formal written complaint to supplement my existing NHTSA Safety Report ID 11702339 regarding a serious fuel system defect on my 2013 Kia Sorento. My car began experiencing sluggish starting, sputtering during acceleration, stalling at stop signs and traffic lights, and a strong fuel odor. A check engine light subsequently illuminated, and due to safety concerns, the vehicle was towed to a Kia dealership for diagnosis. The dealership confirmed and documented fuel leakage from the high-pressure fuel pressure regulator and fuel contamination in the engine oil. This defect presents a serious safety risks: increased risk of engine fire due to fuel leakage, unexpected loss of power while stopped or in traffic, and increased likelihood of a collision due to engine stalling. This vehicle previously had its engine replaced under a Kia recall in 2020, making this failure particularly concerning. Fuel system failures and post-recall engine-related defects have been the subject of multiple Kia recalls, service campaigns, and NHTSA investigations involving engine fires and fuel leaks. Despite the dealership's documented diagnosis and clear safety implications, Kia Consumer Affairs denied recall coverage and refused to assist with repair costs, stating this is not a recall-related issue. The estimated repair cost exceeds $1,700, and the vehicle remains unsafe and undrivable. Given the confirmed fuel leakage, fuel contamination of engine oil, prior recall engine replacement, repeated stalling events, and Kia's refusal to acknowledge responsibility, I respectfully request that NHTSA review this case as part of a potential defect trend, particularly involving high-pressure fuel system components on Kia Sorento vehicles with prior recall engine replacements. I am submitting this complaint to ensure this safety issue is formally documented, investigated, and considered for further action to protect consumers. Thank you for your attention to this serious safety matter

The contact rented a 2025 Kia Telluride. The contact stated that there was damage to the rear bumper upon retrieval. While using lane assist, traveling around a curve at 55 MPH, the steering wheel was pushing and pulling, and failed to turn and continued going straight; the vehicle crossed the highway and crashed into a ditch. There were no warning lights illuminated. The contact sustained injuries to his back and had bruises, but no medical assistance was provided. The vehicle was towed to a tow lot. The air bags deployed. There was no reported fire. A police report was filed. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The rental company was notified of the failure. The manufacturer was not notified OF THE FAILURE. The failure mileage was approximately 33,000. The VIN was not available.

I am submitting this complaint regarding unresolved safety recalls affecting my Kia K5: Recall SC356 and Recall SC346. I have contacted my authorized Kia dealer multiple times over the past several months, yet no remedy has been provided. Most alarmingly, I was informed today that my recall “ticket” was closed without any repairs being completed, which is unacceptable. Recall SC356 involves a damaged fuel tank check valve that can allow air to enter the tank, causing it to expand and potentially contact hot exhaust components. This defect creates a serious fire hazard and poses a risk of injury, death, or property damage. Recall SC346 involves a supplier defect where the C-pillar garnish face plate may delaminate and detach from the vehicle. According to NHTSA (25V493), a detached face plate may become a road hazard, increasing the risk of a crash. Warning signs include looseness, rattling, or wind noise. Both recalls represent clear safety risks, yet Kia and its dealer network have failed to provide a timely remedy or interim solution. Closing a recall case without performing mandated safety repairs is deeply concerning and exposes me and other road users to unnecessary danger. Due to the prolonged delay, repeated dealer contact, and continued exposure to known safety hazards, I am requesting: 1.Immediate reopening and escalation of my recall case 2.Prompt completion of all recall repairs or a clear timeline 3.Consideration of compensation or goodwill due to extended delay and safety risk

The clear coat peeled off of the driver and passenger side mirrors in the beginning of 2024. The white paint started chipping off in a one inch straight line where the red roof meets the white side panel on both sides. You can tell it is where a strip of tape was that maybe separated the two paint colors in the process of painting. This began at the end of 2024. Then in early 2025, the white paint on the hood started flaking off in random spots all over the hood of the vehicle. The paint is completely gone in those areas and the gray body is now showing through where the white paint used to be.

While driving around, the van will go into "limp mode" effecting my speed and acceleration. Then the battery will become drained and the car alarms me to "Check Hybrid System. Stop safely." It seems the hybrid system fails to switch from battery to engine when the battery gets too low, creating the alert. While the vehicle is still running, I will check the diagnostics on the dashboard and it shows no faults: "all systems normal." This is very dangerous as the vehicle can stop running at any moment and could leave me stranded in the middle of the road. I brought the vehicle into the dealership, but they were unable to recreate the problem. While the vehicle was at the dealership, they performed the HVAC control unit upgrade due to a recall. After receiving the vehicle back, this issue has persisted. I do not know if the dealership inspected the vehicle. No other company or entity has inspected the van. This issue first appeared in the first week of November 2025. The issue didn't happen again until 2 weeks later. Now the issue persists almost daily.

Today is 12/15/2025 About a month or 2 ago i was on the highway coming from South Carolina to North Carolina when the engine revved up unexpectedly without input. It has HDA2 and that was doing most of the work. The vehicle started to speed up beyond the set limit and once i hit the brakes and manually shifted i was able to regain control. Last week the vehicle made a small noise that I wasn’t sure about. I called the dealership thinking that it could be a transmission problem. When i called they didn’t seem concerned and asked me to bring it in Monday (today). I had no lights or error codes (and still don’t) on the dash and they did not recommend that I don’t drive it so i continued using the car. Last night it made a horrendous noise started revving on its own and shifting very hard ans if something was coming apart. This morning on my way to the dealership the car completely seized up at an intersection. The car has 47900 miles on it. It’s a 2025 and the transmission seems to have completely blown. Ive read online several complaints about the transmission on these vehicles and think that they may be a major concern. For a new car to have this type of issue locking up while on public roads and smoking is absolutely a hazard. My only saving grace is that it happened at an intersection and not on the highway where an accident would have been inevitable. Please look into the DCT transmission on Kia Sorentos. Particularly X-Line SX prestige models. It is a highly unsafe vehicle. Another issue that the car is having is a clicking noise on the steering column that seems to be getting much worse over time and im afraid will result in loss of steering. Im having them check it out as well. The vehicle never showed a malfunction and I’ve attached a screenshot of the app showing it in perfect health despite being undrivable. I still have no invoice and no police report was made.