KIA Complaints

paint is falling off in large sheets could be a safety issue, been reported to the dealership, and no warning. I feel this is a real safety issue because it comes off in large sheets could cause and issue on the highways for flying debris

I was driving down the highway and my car made a loud bang noise. It would not accelerate over 50 mph no matter how hard I pressed the accelerator. Took to dealership and they told me I needed a new battery and charged me $365. Drove it and still won’t go over 50 mph. They kept it for a week and said it had a faulty valve that caused pressure to make the gas tank expand, pushing up back seat. Said it wasn’t a recall and would cost me $3600 to fix. Told me it was too dangerous to drive. Did research and saw that this was discovered over 2 years ago but I was never told. Now they say I have too many miles on my car to fix it. The gas fumes inside the car are intolerable and it still won’t go over 50.

The right headlight has stopped working as of 1 week ago. The car was returned to the KIA dealership for this issue as well as a hesitation while driving and a chronic bumping sound in the car while driving. The car was kept at the dealership for 3 days Sept 3,4 & 5 2025 and the headlights per the dealership were realigned. The Right headlight was on at the dealership but on Sept 6 2025 is back out. No warning showing on the dash and no warning on the dash when the light was first noticed being off. I have used all the light selector switch settings and nothing changes, moved wires on the back of the light housing, nothing. Tapped on the light front and back, nothing. My concern is the light is out so no night driving and the lack of the sensors warning the light is out. MAJOR SAFETY ISSUE.

I am writing to formally raise a safety concern regarding my vehicle’s brake and rotor system, which has experienced premature failure on two separate occasions. First Occurrence: The issue was first identified prior to reaching 11,000 miles and was addressed by the dealership after surpassing 11,000 miles. The repair involved replacement of the rotors and bolts, but notably, the brake components themselves were not replaced. Second Occurrence: Around 23,000 miles, I began to notice progressively worsening shaking and a disturbing sensation of the brakes skipping or slipping—particularly during highway downgrades. By 24,500 miles, the issue had become significantly more pronounced. I returned the vehicle to Kia of Stockton at 25,248 miles. During my visit, Ricardo from the Kia of Stockton Service Department attributed the issue to “driver error,” citing hot spots on the rotors. However, he also acknowledged that during the initial repair, only the rotors and bolts were replaced—not the brakes. Ricardo further stated that Kia could not offer any additional support beyond a 10% discount on repairs, per his manager’s directive. I explained that I live and work locally, and my driving habits do not involve long commutes or frequent stop-and-go traffic. Given this, I strongly believe the repeated brake system failure points to a potential manufacturing defect rather than user error. Ricardo agreed that if this were his own vehicle, he would be concerned as well. This issue poses a serious safety risk—not only to myself and my family, but to other drivers on the road. In addition my vehicle has also experienced powertrain issues, where it feels as if the vehicle is stuck in 1st gear. I am therefore requesting a full investigation into this matter. If necessary, I would like to initiate the process of reporting this vehicle as a potential lemon under applicable consumer protection laws. Thank you for your attention to this urgent safety concern.

At start up, vehicle’s engine will sometimes have abnormally strong vibrations/shaking, loud noises, and will only produce reduced power (vehicle struggles to accelerate). The check engine light is illuminated when this happens. I am typically able to clear it by shutting off the vehicle one to two times. I have attempted to repair this defect at least 4 times but Kia has been unable to resolve.

New updated testing for recall regarding Piston Oil Rings seems to be faulty. My engine failed with previous testing, which is consistent with the issues my engine is having. However, the new testing claims that my engine has passed even though it is evident that my engine is not in good standing and should have failed. Extreme oil consumption is the number one sign of the faulty piston oil rings, which my car does. I have to add oil every couple of weeks.

The red steering wheel with an exclamation point pops up on the dashboard and instantly I lose power steering the wheel gets really hard, it went out as I was making a turn and I almost hit the truck . I had to yank the wheel really hard to control the steering, then had to pull over turn the truck off then back on to reset the problem. This have been going on mildly for a few years now has gotten to its worst

I own 2020 Kia Sportage under 50,000 miles. I have been dealing with oil consumption problem since December 2024. My car will burn all it's oil before next oil change. I have been to H&H Kia in Papillion Nebraska and had several oil consumption tests. One in January 2025 and another in June 2025. They tell me that the car is burning oil but according to Kia not enough to to replace the engine. My last oil change was June 2025 and my milage is 49650 and my car is out of oil and my next oil change is not until 54933 miles. By the vehicle consuming oil at an undetermined rate it is impossible to tell when the oil will run dry causing the vehicle to cease to run. If this happens on the interstate or highway this could cause accidents or engine fires. It is also a safety issue leaving drivers stranded on the roadside in extreme cold or heat. Yes my problem has been confirmed by a Kia dealership but unable to get Kia to make repairs and honor the warranty Yes it has been inspected by a Kia dealership and they confirmed problem with oil consumption and that other Kia sportages are having same problems Yes the oil light comes out when the car is empty - since it burns at a fast rate there is no way of knowing if you can get the car and yourself to somewhere safe before the car shuts down.

I started the purchase process of a Kia in 2022 of July. The car was built with a faulty fuel tank and no recalls were made on the vehicle. June 27,2025 I was driving on the freeway when my car started to not accelerate my fuel tank ejected into my backseat and I was forced to jump out of my car on the freeway.

The vehicle when coming to a stop to park I press the engine off button and a car with a key symbol stays on and won’t go off and there is a beeping with screen not turning off. Have to turn car on and off numerous times to get it to turn off