KIA Complaints

I am submitting this complaint regarding a leaking evaporator core in my 2021 Kia K5. The evaporator core failed at approximately 59,600 miles, causing the air conditioning system to stop cooling properly. The vehicle was diagnosed by a repair facility, which determined that the evaporator core was leaking refrigerant and required replacement. An evaporator core is a major HVAC component that should not fail at such low mileage under normal operating conditions. This failure affects the vehicle’s ability to properly dehumidify and defrost the windshield, which can reduce visibility and create a potential safety hazard during rain, high humidity, or cold weather conditions. I have maintained the vehicle as recommended and believe this component failed prematurely. Due to the extensive labor required to replace the evaporator core, the repair cost is significant. I am requesting that NHTSA review this issue to determine whether there is a pattern of premature evaporator core failures in 2021 Kia K5 vehicles and whether an investigation is warranted. Vehicle Information: * Year: 2021 * Make: Kia * Model: K5 * Mileage at Failure: 59,600 miles * Failure: Leaking evaporator core causing refrigerant loss and loss of air conditioning performance

Was driving down the road with zero issues known, no check engine light, and only 114K miles. There was a sudden noise that was quiet so I turned down the radio, and then within 2 seconds or so a loud bang occurred, followed by a lot of smoke. I looked in the side mirrors and noted flames coming from underneath the van. Pulled over and got my family out.

Component Malfunction & Availability The component that failed is the center infotainment and entertainment touchscreen display system on a 2024 Kia Telluride. The center screen goes completely black, remains unresponsive to touch or power controls, and fails to initialize upon starting the vehicle. It does not respond to soft pinhole hardware resets. This is a recurring failure; the original factory entertainment screen suffered a total blackout defect and was replaced under manufacturer warranty, but the replacement OEM unit suffered an identical total failure just seven months later. The vehicle and the defective infotainment assembly are fully available for inspection upon request. Safety Risks Imposed Safety is actively compromised because the total failure of the entertainment screen completely disables the backup camera and the 360-degree surround-view safety monitors. When reversing, the driver is left with a dead screen, creating an immediate blind-spot hazard and significantly increasing the risk of a pedestrian backup collision or property impact. Furthermore, the blackout prevents the driver from adjusting critical cabin climate controls, defrosters, and hands-free Bluetooth communication systems, causing severe driver distraction while trying to operate the vehicle. Reproduction & Diagnosis The problem has been reproduced and confirmed by an authorized Kia dealership service center. The initial failure was verified by dealer technicians, resulting in a full warranty replacement. The current identical failure has been documented as a reoccurring, unresolvable defect with the OEM hardware. Inspection Status The system has been inspected and diagnosed exclusively by the authorized Kia dealership service center technicians during the first warranty replacement. No further inspections have been performed by Kia corporate investigators, law enforcement, or insurance representatives. Warning Signs & Symptoms There were no warning lamps, error messages, flicker

Driving on highway at 65, traction control light, airbag light, parking light, bcw warning, all came in at the same time. I was able to pull off to the side and re start engine to clear the lights. As soon as I got up to 40 lights one by one flickered on until up to highway speed and then all flickered and dash dings. Two independent shops ran diagnostics and noted that only battery was dead. Replaced battery and the lights came back immediately.

I took my 2016 Kia Sorento to the dealership for an emissions service update as a result of a service bulliten (SC340) After recieving the car back, the transmission acts unpredictably and the throttle is erratic. This happens when started cold and continues until the engine reaches temperature. It did not do this previous to the update. It is a safetey hazard and almost caused a collision. The throttle response was sluggish, it hunted for gears and as a result I was unable to safely merge into traffic endangering myself and other drivers.

Recently had oil change . Right after B oil change engine light came on, a solid yellow light car is driving rough it’s a 2015 Kia Forte. Have an appointment Monday 7/13/2026 to have dealer to do a B diagnostic. The same place I had oil change

Twice I was making a right hand turn through a green light and an alarm sounded and the dash displayed an ”Engine Off” message. I was able to pull over and restart the car. I took it to the dealership but they were not able to replicate the incident. They told me that they tightened a few connections and sent me on my way. About three weeks later, I was driving straight at about 45mph and it shut off again. Fortunately I was again able to safely pull over and restart the car. This time I recorded it. I will return it to the dealership ASAP. I am afraid this will happen again while I am on the freeway or in heavy traffic and I won’t be as lucky as I have been.

I parked my car and it was sitting for about an hour I came back to the car and heard a humming noise found that weird but I had to drive home about 10 mins later I parked car, sound was still going even while car was off. So I thought to let it sit for another while. Came back to car sound was still on I started car and the abs, traction, & brake light came on and not even 2 mins later my car starts smoking. So immediately I shut it off and have to leave my car parked in another city because I didn’t want to risk driving it home. Fast forward to next day. I got to my car and notice the speedometer had went out. i called Kia because I read about the HECU ABS recall. the service rep assured me my car would be covered so I pay a tow to get it towed to Kia dealer where they then tell me the recall had been repaired in a year that I didn’t even own the car and they refuse to look at it or fix without a fee. With this problem being a fire hazard and a manufacturing problem I should not have to come out of pocket for Kia mistake. I will be escalating this to corporate level.

This is a follow up submission to NHTSA case #XXX. Organization Under Complaint: Hutchinson Kia, [XXX] Complaint Summary: The dealership is utilizing unfair and deceptive financial gating practices to avoid its legal obligations under a federal safety recall. The dealership refuses to look at or evaluate a vehicle subject to an urgent fire-risk HECU safety recall unless the consumer first authorizes a $189.00 diagnostic fee. The dealership refuses to give a firm, legally binding commitment that this fee will be waived for a confirmed recall component. Instead, they require the consumer to assume all financial risk upfront, stating the fee will only "likely" be waived based on their own internal, unverified findings. This creates a high-pressure trap where the consumer is forced to sign away financial rights to access a free, federally mandated safety remedy. The dealership is weaponizing a acute shortage of independent import and specialized repair facilities in the Macon, GA market. They are aware consumers have almost no local alternative venues to get an independent, affordable cross-check scan, and are using this regional monopoly to coerce consumers into signing open-ended diagnostic authorizations. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Car does not unlock with keyless key fob. This is too often an issues to overlook. Car will just keep locking and eventually nothing. I have been stuck outside in thunderstorms, a huge safety concern, rain, snow and uncomfortable situations. This causes me to be more soaked, wetting the car and fishing out my keys getting items inside wet. Key is mostly in pocket because its a keyless entry car, or in backpack. 2023 was superior.