2004 LINCOLN AVIATOR Complaints

THIS IS THE 3RD TIME THAT MY 2004 LINCOLN AVIATOR HAS SHUT DOWN WHILE DRIVING IT... WITH KIDS IN THE CAR. NO STEERING, NO BREAKS, AND 60 MPH DOWN THE HIGHWAY. THIS CAR IS SURE TO BE THE DEATH OF ME... I HAVE BEEN LUCKY 3 TIMES NOW, BUT WHAT ABOUT THE NEXT TIME??? VOLUNTARY SERVICE RECALL... MANUFACTURING DEFECT OF THE COIL PACKS... ISSUED BY EPA.GOV (FOUND AFTER DIGGING), REPLACEMENT OF THE COIL PACKS ARE COVERED UNTIL 120,000 MILES. FORD WILL ONLY REPLACE ONE AT A TIME, NOT ALL OF THEM, SO EACH TIME ONE IS REPLACED.. I STILL HAVE THE RISK OF ANOTHER GOING BAD. HAD FOUR REPLACED SO FAR, ANOTHER TOMORROW. I CANNOT BELIEVE THAT FORD CAN GET AWAY WITH THIS KNOWING THAT THEY ARE PUTTING PEOPLE'S LIVES IN DANGER. A CAR COMPLETELY SHUTTING DOWN WHILE DRIVING AT 60MPH BECAUSE OF A DEFECT DURING THE MANUFACTURING PROCESS DOESN'T CAUSE CONCERN FOR A RECALL... BUT A CAR SPEEDING OUT OF CONTROL DOES? WHAT HAPPENS WHEN I AM ON THE INTERSTATE NEXT TIME DURING RUSH HOUR AND I HAVE NO STEERING OR BRAKES???? *TR

TL* THE CONTACT OWNS A 2004 LINCOLN AVIATOR. WHILE DRIVING AT APPROXIMATELY 55 MPH, THE CHECK ENGINE LIGHT ILLUMINATED ON THE DASHBOARD. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THE IGNITION COIL NEEDED TO BE REPLACED. THE IGNITION COIL WAS REPLACED. APPROXIMATELY 4 MONTHS LATER THE FAILURE RECURRED. THE VEHICLE WAS AGAIN TAKEN TO AN AUTHORIZED DEALER WHERE THE IGNITION COIL WAS REPLACED. THE FAILURE CONTINUED TO RECUR ON SEVERAL OTHER IGNITION COILS, AND THE CONTACT REPLACED THEM HIMSELF. THE CONTACT STATED THAT THE FAILURE CONTINUES TO RECUR. THE FAILURE MILEAGE WAS 21,000 AND THE CURRENT MILEAGE WAS 144,000.

TL*THE CONTACT OWNS A 2004 LINCOLN AVIATOR. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 55 MPH SMOKE CIRCULATED THROUGH THE VENTS INSIDE OF THE VEHICLE; AND THE VEHICLE WAS DRIVEN TO THE SIDE OF THE ROAD. THE CONTACT STATED THE SMOKE ORIGINATED FROM THE ENGINE COMPARTMENT. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THE TECHNICIAN ADVISED THAT THE FRONT END DIFFERENTIAL HAD DETERIORATED. THE VEHICLE WAS REPAIRED AT THE OWNER'S EXPENSE. AFTER THE SERVICE REPAIR THE VEHICLE WAS TEST DRIVEN AND THE FAILURE RECURRED. THE TECHNICIAN PERFORMED FURTHER DIAGNOSIS AND REPAIRED THE VEHICLE. THE FAILURE CONTINUED TO OCCUR ON FOUR SEPARATE OCCASIONS WHICH WAS REPAIRED AT THE OWNER'S EXPENSE. THE MANUFACTURER WAS NOTIFIED OF THE FRONT END DIFFERENTIAL FAILURES AND THEY ACCEPTED LIABILITY FOR THE RADIO AND STEERING COLUMN REPAIRS THAT FAILED TO FUNCTION CORRECTLY DUE TO THE DIFFERENTIAL FAILURES. IN ADDITION, THE CONTACT STATED THAT THE FRONT TIRES WERE REPLACED IN MARCH OF 2009; AND FIVE MONTHS LATER THE TIRES HAD WORN TO THE METAL IN RESULT OF THE DEFECTIVE FRONT END DIFFERENTIAL. THE TIRES WERE REPLACED. AN INDEPENDENT MECHANIC INFORMED THE PROBLEM ORIGINATED FROM INEXPENSIVE KOREAN PARTS IN THE TRANSFER CASE. THE TRANSFER CASE AND U JOINT WERE REPLACED IN THE VEHICLE. THE CONTACT EXPRESSED ANYONE DRIVING THE VEHICLE LIFE WAS IN DANGER BECAUSE OF THE SAFETY DEFECT. THE FAILURE MILEAGE WAS 80,000. THE VIN WAS UNAVAILABLE. ALSO, THERE WAS A CRACK UNDER THE REAR LIFTGATE. THERE WAS RECALL ON THE REARLIFT. HOWEVER, THE CONSUMERS VIN WAS NOT INCLUDED. THE ENTIRE SHIFTING MECHANISM HAD TO BE REPLACED, THE STEERING WHEEL WOULD VIBRATE WHILE MAKING A TURN. UPDATED 12/17/10

VEHICLE WAS IN OWNERS DRIVE WAY SHE PUT VEHICLE REVERSE MOVED TWO FEET AND AIR BAG PARTIALLY DEPLOYED SHE PUT THE VEHICLE IN PARK AND EXITED THE VEHICLE AND THE BAG FULLY DEPLOYED.

TL*THE CONTACT OWNS A 2004 LINCOLN AVIATOR. THE CONTACT STATED AS SHE WAS REVERSING, MILES PER HOUR WAS UNKNOWN ,THE DRIVER SIDE AIR BAG DEPLOYED. IT CONTINUED TO RUPTURE AS SHE PUT THE GEAR SHIFT IN PARK AND JUMPED OUT OF THE VEHICLE. NO ONE WAS INJURED. THE VEHICLE WAS DRIVEN TO THE DEALER AFTER THE AIR BAGS WERE TAPED. THEY INFORM HER IT WILL COST $1000 TO REPAIR THE DAMAGE. THE FORD MANUFACTURER WAS CALLED AND STATED THEY WILL GIVE AN ANSWER WITHIN THE NEXT 15 DAYS ON THEIR DECISION REGARDING THE REPAIRS.THE VEHICLE WAS STILL AT THE DEALERSHIP AT THE TIME OF THE COMPLAINT. THERE WAS ONLY ROUTINE MAINTENANCE PERFORMED ON THE VEHICLE BUT NO REPAIR DONE ON THE AIR BAGS. THE FAILURE MILEAGE WAS 70,000.

THE LIFTGATE ON THE BACK OF MY 2004 LINCOLN AVIATOR CRACKED ON ONE SIDE OF THE LINCOLN SYMBOL. TOOK IT TO LINCOLN DEALERSHIP AND WAS TOLD THAT IT WAS FROM THE COLD BECAUSE THERE WAS A WEAK SPOT THERE. WAS TOLD THAT EVEN THOUGH THEY KNEW OF THE WEAK SPOT, THAT I WOULD HAVE TO PAY TO FIX IT. AT THE TIME I DECLINED TO FIX IT. I JUST NOTICED THE OTHER DAY THAT THERE IS NOW A CRACK ON THE OTHER SIDE OF THE LINCOLN SYMBOL. I WAS TOLD IF I DON'T HAVE IT FIXED, THAT THE BACK GLASS COULD FALL OUT. SO NOW I AM GOING TO HAVE TO PAY TO HAVE A DEFECT THAT LINCOLN IS AWARE OF FIXED. THIS IS THE SECOND LINCOLN THAT I HAVE OWNED AND I DON'T THINK I WILL BE PURCHASING ANOTHER ONE AFTER THIS. *TR

LINCOLN AVIATOR WITH 54,000 ON IT AND HAD TO FIX THE TRANSMISSION, SHOP SAID THERE WAS SOME GROVE ON SOME PART IN THE TRANSMISSION. VERY EXPENSIVE PROBLEMS WITH LOW MILES. ALSO HAD A 2004 MERCURY MOUNTAINEER WITH 64,000 MILES, TRANSMISSION STARTED TO MAKE NOISES, ABOUT A WEEK LATER IT WOULD NOT SHIFT. SHOP SAID SOME GROVE IN SOMETHING IN THE TRANSMISSION. HAD IT FIXED FOR $3,000. LATER FOUND OUT THE TRANSMISSION WAS OUT AT 10,000 MILES BEFORE WE BOUGHT IT. *TR

TL*THE CONTACT OWNS A 2004 LINCOLN AVIATOR. SHE STATED THAT THERE WAS A CRACK ON THE SIDE OF THE TAILGATE NEAR THE LINCOLN EMBLEM. THE VEHICLE WAS REPAIRED AT HER EXPENSE; HOWEVER, THERE IS ANOTHER CRACK IN THE SAME LOCATION. HER MECHANIC STATED THAT THE CRACK IS DUE TO THE COLD WEATHER. THE DEALER STATED THAT SHE NEEDED TO HAVE THE VEHICLE INSPECTED. THE VEHICLE WILL BE REPAIRED AGAIN AT THE OWNERS EXPENSE. THE FAILURE MILEAGE WAS 30000 AND THE CURRENT MILEAGE WAS 51525. UPDATED 04/16/10. *LJ UPDATED 07/13/10.*JB

THE GEAR SHIFT SELECTOR BROKE AND I COULD NOT GET THE VEHICLE INTO A NEUTRAL POSITION WHILE DRIVING. COULD NOT TURN OFF THE IGNITION SYSTEM. *TR UPDATED 01/13/10.

EARLY THIS MORNING WAS DRIVING ON THE FREEWAY IN OUR 2004 LINCOLN AVIATOR. THERE WAS A MODERATE RAIN FALL AND ZERO NATURAL LIGHT WAS AVAILABLE. WITHOUT WARNING, THE ELECTRICAL SYSTEM, INCLUDING THE HEADLIGHTS, IN THE VEHICLE SHUT OFF. I WAS TRAVELING AT APPROX. 70 MPH AND WAS CARRYING A TOTAL OF SEVEN PEOPLE. UNABLE TO SEE, I DROVE OFF THE ROAD AND WAS HORRIFIED TO DISCOVER THAT I ALMOST RAN INTO THE GUARD RAIL. WHILE THIS SITUATION DID NOT RESULT IN ANY DAMAGE OR FATALITIES, THIS COULD HAVE EASILY BEEN A DISASTER RESULTING IN MULTIPLE DEATHS. I SPOKE TO THE LOCAL LINCOLN DEALERSHIP WHO TO MY SURPRISE, INDICATED THAT HE WAS AWARE OF SIMILAR BEHAVIOR ON A SIMILAR FORD VEHICLE. APPARENTLY, A LEAK IN THE WINDSHIELD SEAL CAN DIRECT WATER INTO THE ENGINE COMPARTMENT AND INTO THE PRIMARY ELECTRONIC CONTROL COMPUTER. I AM TAKING THE VEHICLE TO THE DEALERSHIP FOR FURTHER INVESTIGATION, HOWEVER, THIS PROBLEM IS INTERMITTENT AND WILL THEREFORE BE VERY DIFFICULT TO DIAGNOSE. THIS PROBLEM OCCURRED ANOTHER TIME A FEW MONTHS BACK, BUT THE ELECTRICAL SYSTEM CAME RIGHT BACK ON SO WE DID NOT ATTEMPT TO DIAGNOSE THE PROBLEM. I AM PARTICULARLY CONCERNED ABOUT THIS PROBLEM BECAUSE IT COULD HAVE BEEN THE CAUSE OF MULTIPLE FATALITIES AND THE CAUSE COULD HAVE EASILY BEEN ATTRIBUTED TO MY FALLING ASLEEP AT THE WHEEL. PLEASE DO SOMETHING ABOUT THIS IMPORTANT PROBLEM. THANK YOU. *TR