2005 LINCOLN AVIATOR Complaints

I WAS DRIVING ON A HIGHWAY 55 MPH WHEN PASSENGER REAR TOE LINK FAILED AND I LOST CONTROL OF VEHICLE. I WAS ABLE TO PULL OVER WITHOUT CRASHING. VEHICLE WAS REPAIRED AT GARAGE NEARBY.

A 6 INCH CRACK DEVELOPED AT REAR CENTER TAILGATE BODY PANEL MADE OUT OF PLASTIC BELOW THE REAR WINDOW. THERE HAD BEEN REPORTS THAT THE REAR WINDOW COULD FALL OUT AND INTERNAL TAILGATE COMPONENTS COULD BE DAMAGED DUE TO WATER ENTRY FROM THE CRACK. THIS APPEARS TO BE A COMMON PROBLEM FROM MY RESEARCH.

DRIVER SIDE AIR BAG DEPLOYED WITH NO IMPACT OF ANY KIND. CAR WAS STARTED AND AIR BAG DEPLOYED.

REAR PLASTIC LITIGATE APPLIQUE BROKE OFF HITTING A PASSENGER CAR'S WINDSHIELD. THE WINDSHIELD CRACKED. THIS THE THIRD PIECE FAILURE. THE LINCOLN WAS TRAVELING WEST ON THE DULLES GREENWAY.

WHILE PARKED AT THE GAS STATION GETTING READY TO PUMP GAS THE REAR WINDOW EXPLODED, GLASS SHATTERED EVERYWHERE, LEFT HINGE CRACKED AND FRAME AROUND LIFTGATE BEND AND CURLED UP. MY REAR LIFTGATE HAS THE SAME CRACKED AS PREVIOUSLY REPORTED. I REPLACED THE ENTIRE LIFTGATE IN 2011 & ON THE NEW LIFTGATE THE SAME CRACK CAME BACK

I HAVE THE SAME CRACKING PROBLEM WITH THE BACK GATE WHICH RESULTED IN THE BREAKING OF HINGES. ALSO A KNOWN DEFECT IN USING DEFECTIVE PARTS IN THE ENGINE SUCH AS TIMING CHAIN CASSETTES AND TENSIONER. FORD KNEW ABOUT THE PROBLEM AND ISSUED AN TECHNICAL BULLETIN ON IT BUT NEVER FIXED THE PROBLEM. THE MECHANIC TOLD ME HE REPAIRED THIS VERY FREQUENTLY FOR THIS ENGINE

OWNER OF 2005 LINCOLN AVIATOR. I WAS NOT ABLE TO GET THE GEAR SHIFT OUT OF PARK. I HAD THE AVIATOR TOWED TO A FAMILY MEMBER'S AUTOMOTIVE GARAGE AND WAS TOLD THAT I WILL NEED TO HAVE THE ENTIRE GEAR SHIFT REPLACED. UPON DOING SOME RESEARCH, IT SEEMS THAT THIS IS A VERY COMMON PROBLEM IN THIS YEAR, MAKE, AND MODEL. I HAVE READ ENDLESS TESTIMONIES FROM OTHER VEHICLE OWNERS WITH THE EXACT DISPUTE. THE PART AND LABOR WILL COST ME APPROXIMATELY $1100.00 AT MY FAMILY'S GARAGE, ONE CAN ONLY GUESS THE DOLLAR AMOUNT WILL DOUBLE AT THE LOCAL DEALERSHIP. MY CAR IS DRIVEABLE, HOWEVER, WHEN IN PARK, I WILL HAVE TO PUT MY EMERGENCY BRAKE ON. I WAS ALSO INFORMED THAT THE GEAR SHIFT, IF BUMPED, MAY MOVE OUT OF PARK EVEN WITHOUT THE KEY IN THE IGNITION. I AM APPALLED THAT FORD/LINCOLN MOTOR COMPANY HAS NOT TAKEN RESPONSIBILITY OF THE DEFECTED MECHANISM. IT IS UNACCEPTABLE AND RAISES MANY QUESTIONS ON HOW IMPORTANT VEHICLE SAFETY IS TO FORD/LINCOLN MOTOR COMPANY, NOT TO MENTION A TOTAL INCONVENIENCE FINANCIALLY! THIS IS MY FOURTH VEHICLE FROM FORD/LINCOLN MOTOR COMPANY AND I HIGHLY DOUBT I WILL PURCHASE ANOTHER BASED ON THE COMPANY'S LACK IN ADDRESSING THE MATTER. I AM A MOTHER OF ONE CHILD AND NOW DO NOT FEEL SECURE DRIVING A VEHICLE THAT I ONCE FELT VERY PROTECTED IN.

WHEN PURCHASED USED 2 YRS OLD [XXX], I NOTICED A CRACK IN THE MIDDLE OF THE LIFTGATE. I HAVE OWNED THIS VEHICLE FOR ALMOST 7YRS AND HAVE TAKEN VERY GOOD CARE OF IT, BUT I NOW HAVE 3 CRACKS IN THE LIFTGATE. IT SEEMS TO BE VERY THIN ACROSS THE BOTTOM OF THE BACK WINDOW AND EVERY TIME YOU OPEN AND CLOSE THE WINDOW, IT PUTS STRESS ACROSS THE BOTTOM OF IT. THIS SHOULD BE A RECALL BECAUSE THERE ARE A LOT OF OTHER OWNERS WITH THE SAME PROBLEM AND OBVIOUSLY THIS IS A DEFECT!! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR UPDATED 4/19/2016 *JS

I NOTICED A CRACK ON THE BACK PANEL OF MY TAILGATE. THERE WAS NO ACCIDENT OR INCIDENT AND SINCE THEN I HAVE NOTICED AT LEAST 3 OTHER CARS IN MY SMALL TOWN WITH THE SAME DEFECT. I HAVE WRITTEN TO FORD AND GOTTEN NO RESPONSE. FROM WHAT I HAVE SEEN ON THE INTERNET, THIS IS NOT AN ISOLATED PROBLEM. I FEEL THAT FORD/LINCOLN SHOULD RECALL THE AFFECTED MODELS OF CAR (INCLUDING FORD EXPLORERS) AND MAKE THESE REPAIRS. THE MECHANISM THAT KEEPS MY TAILGATE WINDOW CLOSED AND LOCKED IS ALSO BROKEN AND I THINK IT IS DIRECTLY RELATED TO THE CRACK IN THE TAILGATE. THIS COMPROMISES OUR SAFETY IN THE CAR BY MAKING THE CAR UNABLE TO BE LOCKED PROPERLY. SOMEONE COULD EASILY GET INTO THE CAR FROM THE TAILGATE AND STEAL ANYTHING IN THE CAR, STEAL THE CAR ITSELF, AND POSE AN IMMEDIATE THREAT TO OUR PERSONAL SAFETY. *TR

TL-THE CONTACT OWNS A 2005 LINCOLN AVIATOR. THE CONTACT STATED THAT WHILE STARTING THE VEHICLE, THE AIR BAG DEPLOYED INDEPENDENTLY ONTO HER FACE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 88,000. DJR