LINCOLN Complaints

The contact owns a 2024 Lincoln Corsair. The contact stated that upon attempting to purchase the brand-new vehicle on September 1, 2025, the dealer informed the contact that the vehicle was on a Stop Sale because the VIN was included in NHTSA Campaign Number: 25V315000 (Back Over Prevention). The contact was later contacted by the dealer and was advised that the recall repair was completed, and the vehicle could be purchased. The contact purchased the vehicle on [XXX], and picked up the vehicle three days later. The contact later received a recall notification from the Mobile App, a week after picking up the vehicle from the dealer. The dealer was contacted and confirmed that the recall repair had not been performed prior to the purchase and delivery of the vehicle. The dealer offered to pick up the vehicle to complete the recall repair; however, the contact declined. The vehicle was taken to Gordie Boucher Lincoln of West Allis (3161 S 108th St, West Allis, WI 53227); where the recall repair was performed. Upon reading the dealer's reviews online, the contact became aware that it was common for the dealer to provide false information to mislead consumers. The manufacturer was not yet notified of the issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The driver-side front window regulator failed and was replaced on October 4, 2025. The passenger-side window regulator also failed and was removed and replaced on November 21, 2025. At the time each incident, the window would not raise using the car controls and remained stuck in the down position. Two window regulator failures on opposite sides of this vehicle just seven weeks and within roughly 2,400 miles apart does not indicate typical wear. It reflects a pattern failure consistent with a component defect. At the time of the October incident, I was actively driving the vehicle and the November incident when was while the car was parked, when the window failed and would not raise. After parking and then restarting my vehicle, the window remained fully or partially down and could not be returned to a closed and secured position. This created multiple safety and security risks, including: • Inability to secure the vehicle against theft or intrusion • Exposure to weather, rain, or debris • Increased cabin noise due to broken window • Risk of vehicle damage while parked without protection. The vehicle was left parked and unsecured solely due to the window malfunction. No police or insurance inspection occurred, as the incident did not involve a collision or theft, though the vehicle was left unsecured. The failure was diagnosed and confirmed by the manufacturer, Lincoln and independent service center Firestone Complete Auto Care, who completed the repair. There was No warning lamps or dashboard messages that appeared prior to or during the failure. Both window regulator failed suddenly and without warning. In my research, numerous Aviator owners have publicly reported identical regulator failures, (Reddit and YouTube) which further reinforces that this is a systemic issue, not an isolated event.

Catalytic Converter Issues with Ford after Emissions Recall I recently had an emissions recall on my 2016 Lincoln MKX by Ford (25E02) in which the "vehicle has an emissions control system that does not account for certain in-use conditions and might not control tail pipe emissions effectively over time." Now one of the catalytic converters in the car is not working and needs to be replaced. The safety issue is the emissions being released as a result of the emissions control system not working properly for years and damaging the catalytic converter. I believe the company is aware of the issue but is refusing to include catalytic convertors in the recall. This is an environmental hazard that should fall on Ford to resolve.

2019 Lincoln MKC with 96K mileage suddenly started running rough around 30mph and I was losing power as I was entering a highway on a ramp. RPM needle was fluctuating between 2K and 3K. Immediately drove back home and towed it to Lincoln shop. They said its an issue with Coolant Intrusion into the engine compartment and would have to replace the engine block. Estimated at $11K. Extended warranty company said claim is likely to be denied as these Ecoboost 2.0L engines are notorious for these issues. It is a faulty manufacturing and there is no recall. Costing consumers thousands of dollars and also putting lives of passengers at risk.

Rear door trim came loose and fell off while driving. Had the service department at the local dealership look at the missing trim on the rear of the car and they noticed multiple of the plastic clips holding the trim on the rear were broken and remained in the area where the trim was attached.

While driving on the expressway, multiple system warning lights suddenly appeared on the dash with the message 'engine failsafe mode'. The engine immediately shut off and I lost power steering and power brakes while moving at highway speed. I was able to coast to the shoulder and the truck would not restart. The vehicle ran perfectly prior to this malfunction and there was no warning that a problem may exist. A mechanic determined that the Power Control Module (PCM) was corrupted and required reprogramming. I purchased a refurbished PCM and had it programmed by a locksmith to my VIN. The faulty PCM is still in my possession and available for inspection. This is a very dangerous condition that could have resulted in a crash. Fortunately, this malfunction occurred on a Saturday morning with light traffic during daylight hours. I am scared this will happen again in the future because the cause for the PCM failure is unknown. The towing fee, diagnosis and repair created a considerable financial expense on my behalf.

Brake failure. Pedal drops, especially when ABS is activated. Dealer diagnosed ABS control module and HCU hydraulic leak. Parts for this are on back order per dealer leaving me with a dangerous driving situation or inability to use my vehicle. No warning lamp or message displays. The fact that the parts to fix a major safety item are not available is unacceptable.

While driving vehicle the engine shut down for no apparent reason. Light came on said do not attempt to drive, not safe. Was able to get car to a safe area. Was able to restart and get the car home. Brought the car to the dealer, said battery was dead, found water in the truck where the battery is located

Ford Customer Satisfaction Programs (CSPs) 23B11/24E04 for P0420/P0430 codes they did the update and now the check engine light is on all the time and they will not replace catalytic converter

My car is currently under two recall notices however only one of the issues has been communicated to me of resolution. One being emissions control 25E02 and second being Recall 25S87 REAR BRAKE FLEXIBLE HOSE LEAK. Recall 1- emissions has been a problem for about 2 years now. Emissions are connected to my engine thus having my check engine light come on. My car failed an emissions test but was only 4 years old and the catalytic converters are not broken, have hole, anything leading to failed test, car repair fees and non-registered vehicle. The second recall is not being fixed, and I have had to replace my brake house, line and rear right brake twice this year. Lastly, I have collision warning however it does not work properly if at all. I was in a minor fender bender when I went to push on brakes the sound to warn me of a collision did not go off until after the crash! I am unsure of the process but if connected to my braking system it failed and if it is a preventative measure it sucks.