1998 MAZDA PROTEGE Complaints

THE OVER DRIVE LIGHT MALFUNCTIONED WHICH CAUSED THE VEHICLE TO DROP INTO A LOWER GEAR, AN THE ENGINE ACTED AS THOUGH IT WOULD STALL AND THEN BUCKED ERRATICALLY. *TS *JB

EXHAUST MANIFOLD CRACK IN 1998 MAZADA PROTEGE. RECENTLY THERE HAS BEEN A BURNING SMELL IN THE CABIN. MY MECHANIC FOUND THAT IT IS DUE TO THE EXHAUST MANIFOLD CRACK AND TOLD ME THAT IT IS A COMMON PROBLEM FOR 95-98 PROTEGE. HE THOUGHT IT MIGHT BE IN THE BULLETIN. I TOOK HIS SUGGESTION AND CALLED THE DEALER, BUT THE ANSWER WAS NEGATIVE. I AM VERY CONCERNED BECAUSE THE MONOXIDE FROM THE EXHAUST COULD POTENTIALLY KILL A PERSON IN SILENCE. I HAVE BEEN DRIVING THE CAR WITH THE WINDOW OPEN MOST TIME, JUST TO BE SAFE. I HOPE THAT MAZDA WILL PLACE A RECALL ON IT

WHILE DRIVING AT 60 MPH , VEHICLE STARTED OVERHEATING. CONSUMER HAD VEHICLE SERVICED BY A MECHANIC WHO INDICATED THAT THE HEATING CORE HAD RUSTED. PLEASE PROVIDE MORE DETAILS.

THE VEHICLE STALLS WHEN PUSHING IN THE CLUTCH. WHEN PUSHING IN THE CLUTCH, THE IDLE DROPS TO 0 AND THE CAR SHAKES BEFORE RETURNING TO IT'S NORMAL IDLE SPEED, APPROX. 500 RPM, OR IT JUST STALLS. THIS HAS CAUSED HARROWING MOMENTS WHEN PUSHING IN THE CLUTCH AND BRAKING AT HIGH SPEEDS ON EXIT RAMPS AND PULLING INTO PARKING SPOTS. IT HAS BEEN BACK TO (2) MAZDA DEALERS 3 TIMES AND EACH TIME I AM TOLD THAT IT IS THE GAS I USE, BUT THIS HAS BEEN HAPPENING FOR 40,000 MILES NOW AND IS GETTING WORSE. DT

THE CATALYTIC CONVERTER WAS REPLACED BACK IN 09/01. I WAS TOLD IT WOULD BE REPLACED FOR FREE! I LEFT PAYING $66.11 TO REPLACE CATALYTIC CONVERTER. I HAVE ALSO HAD TO REPLACE A PORTION OF THE AC UNIT ON 05/23/02. ONE MONTH LATER APPROXIMATELY 6/25/02 I THEN HEARD A LOUD EXHUST NOISE. I HAD THE VEHICLE LOOKED AT BY A FRIEND WHO FOUND THAT THE MANIFOLD HAD A SIGINIFICANTLY LARGE CRACK. MOREOVER, THE SMELL WITHIN THE PASSENGER CAMPARTMENT OF THE VEHICLE IS EXTREME TO THE POINT WHEN WE GET OUT OF THE CAR WE HAVE THE SMELL OF EXHUST FUMES IN OUR HAIR AND CLOTHES. THE SMELL IN THE CAR IS VERY OVERWHELMING, THAT WE MUST RIDE WITH THE WINDOWS OPEN FOR FRESH AIR AND LETS JUST SAY WE ONLY GET RELIEF FOR JUST A SHORT WHILE WITH THE WINDOWS OPEN BECAUSE WE LIVE IN FLORIDA AND IT IS USUALLY TOO HOT & HUMID TO HAVE THE WINDOWS OPEN DURING THE DAYTIME. ON LONGER DRIVES IT TENDS TO MAKE ME SLEEPY ALSO MY 5 YEAR OLD RIDES IN THIS VEHICLE AND HAS A HISTORY OF ASTHMA. THIS TO ME IS A GREAT HADZARD TO ALL OF OUR HEALTH ESPECIALLY TO HIS. I WONDER IF THIS IS ALL RELATED TO EACH OTHER. OR IS IT SOMETHING THAT EVERYONE HAS HAD A PROBLEM WITH? SINCERELY, [XXX]. *AK PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

COVERINGS ON DRIVER AND PASSENGER SIDE KEY LOCKS THAT PREVENT MOISTURE FROM ENTERING THE LOCK WERE MADE FROM PLASTIC. THIS PLASTIC BECOMES BRITTLE AFTER SEVERAL YEARS OF EXPOSURE AND USE AND CAN BREAK. WHEN THE PART BREAKS, PIECES FROM THE BROKEN COVER CAN EASILY BE LODGED IN THE LOCK RENDERING THE LOCK UNUSABLE (AS HAPPENED TO ME).

CAR WILL THRUST FORWARD, JERKING CAR & PASSENGERS - MANUFACTURER SAYS DETECTED IN 1996-1998 MODELS AS NORMAL.*AK

CONSUMER NOTICED THAT THE TRANSMISSION WAS NOT SHIFTING RIGHT, IT WOULD REV HIGH AND NOT SHIFT BACK DOWN WHEN SHE STEPPED ON THE GAS, CONSUMER HAD TO TAKE HER FOOT OFF THE GAS TO GET IT TO COME BACK DOWN. TOOK IT BACK TO THE DEALER, DEALER SAID A NEW TRANSMISSION WAS NEEDED AND THAT THE WARRANTY HAD EXPIRED. VEHICLE WASTHEN TAKEN TO A NATIONALLY KNOWN SERVICE SHOP FOR A SECOND OPINION AND WAS TOLD THE HYDRAULIC CLUTCH HAD COME APART, CONSUMER LETTING THEM DO THE REPAIRS BECAUSE SHE WAS NOT SATISFIED WITH INITIAL SERVICE FROM DEALER. *YD

CALIPER AND ROTOR FAILED WITH LESS THAN 30,000 MILES, DEALER SAID IT IS TYPICAL AND SAID THE PARTS USED ARE POOR. OTHER VEHICLES I OWNED EXERIENCED THIS TYPE OF FAILURE MUCH LATER IN VEHICLE LIFE (75,000 MI +). *AK

CALLED MAZDA DEALER IN REGARDS TO CRACKED EXHAUST MANIFOLD BASICALLY TOLD ME THAT SINCE IT WASN'T UNDER WARRANTY ANYMORE THERE WAS NOTHING THEY COULD DO. I HAVE CALLED 25 DIFFERENT SALVAGE YARDS IN GEORGIA AND THIS SEEMS TO BE A HOT ITEM RIGHT NOW BECAUSE I CAN'T GET ONE. TO BUY ONE FROM THE DEALER WILL COST ME OVER $300.00 . I KNOW THERE SHOULD BE A RECALL ON THIS.*AK