2001 MAZDA PROTEGE Complaints

CHECK ENGINE LIGHT HAS BEEN COMING ON FOR LAST YEAR. PROBLEM IS WITH ENGINE MISFIRE/CATALYTIC CONVERTER. WE HAVE REPLACED EVERYTHING SUGGESTED: SPARK PLUGS, WIRES, CATALYTIC CONVERTER, ENGINE TUNE UP, NEW TIRES, ETC. PROBLEM WORSENING. CAR RIDING ROUGHER, WORSENING GAS MILEAGE. *JB

DT: THE CONTACT STATED THAT ONE HOUR AFTER HE PURCHASED THE VEHICLE THE CHECK ENGINE LIGHT CAME ON. HE HAD IT CHECKED BY A MECHANIC, AND IT WAS DETERMINED THAT CATALYTIC CONVERTER FAILED. IT WAS FIXED BECAUSE IT WAS UNDER WARRANTY. THE EGR VALVE NEEDED TO BE FIXED. THE MAZDA DEALERSHIP GAVE CONSUMER AN ESTIMATE FOR OVER $200.00, AND THEY WILL NOT FIX IT BECAUSE IT IS NOT COVERED UNDER THE WARRANTY. THE MAZDA DEALERSHIP WHERE HE PURCHASED THE VEHICLE SAID THEY WOULD FIX IT UNDER THE WARRANTY BUT HE HAS TO TAKE THE TIME TO BRING THE VEHICLE BACK THERE AGAIN. *AK

DT: CONTACT STATED THE AIR CONDITIONER WAS NOT WORKING WHEN PUT ON A HIGHER FAN SETTING. CONSUMER LOOKED BEHIND THE DASH AND CONNECTOR WAS STARTING TO MELT. *AK

WHILE ON A 300 MILE TRIP,\ I NOTICED A SLIGHT NOISE COMMING FROM MY REAR END. UPON MY RETURN HOME, THE NOISE GOT WORSE AND I TOOK IT TO A REPAIR SHOP AND FOUND THE BRAKE CALIPERS MALFUNCTIONED, AND A COMPLETE REAR END BRAKE JOB COSTING OVER $1,000.00 WAS REQUIRED. SINCE THE VEHICLE HAD ONLY 52,000 MILES ON IT AND WAS LESS THAN FOUR YEARS OLD I TOOK IT TO THE MAZDA DEALER, AND WAS TOLD SINCE IT WAS OUT OF WARRANTY. ALL THEY COULD DO WAS OFF $175.00 OFF THE BRAKE JOB(STILL OVER $1,000.00). ON A VEHICLE THIS NEW I FEEL THE CALIPERS SHOULD NOT HAVE FAILED. THE BRAKES STILL HAVE NOT BEEN REPLACED AS I AM STILL TRYING TO HAVE MAZDA PAY MORE OF THE COST. REPLACEMENT PARTS NEEDED ARE 2 REAR CALIPERS, 2 ROTORS, 2 SETS OF BRAKE PADS AND 2 BRAKE LINE HOSES.*AK

I HEARD A STRANGE SOUND EVERY TIME I STARTED TO ACCELERATE WHICH I FIRST THOUGHT TO BE THE CAR IN THE NEXT LANE. I DROVE ONE MORE BLOCK AND TURNED THE CORNER, BUT THE STEERING WAS LOCKING AND I HAD GREAT DIFFICULTY TURNING. I HAD THE CAR TOWED TO MY MECHANIC, COMBUSTION GASES WERE IN THE COOLING SYSTEM AND THE ENGINE HAD A CRACKED CYLINDER. THE CAR IS FOUR YEARS OLD (JUST OUT OF WARRANTY) WITH ONLY 31,483 MILES ON IT. I'M A GOOD DRIVER, 73 YEARS OLD WITH A CLEAN DRIVING RECORD AND HAVE NEVER HAD PROBLEMS WITH ANY CAR AS A RESULT OF MY DRIVING HABITS. I'VE OWNED MAZDA'S SINCE 1987 AND LOVED THEM (EVEN THIS CAR) BUT THIS WILL PROBABLY BE MY LAST. THE REPAIR REQUIRED A REBUILT ENGINE AT A COST OF $ 3,223.14.. *AK

WHILE DRIVING APPROXIMATELY 30 MPH DRIVER HEARD A LOUD KNOCKING NOISE COMING FROM THE FRONT. THE CHECK ENGINE LIGHT APPEARED ON THE DASHBOARD, AND VEHICLE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT THE ENGINE NEEDED TO BE REPLACED. *AK

WHILE DRIVING MY MAZDA PROTEGE TO WORK WHEN AUTOMATIC TRANSMISSION WOULD NOT SHIFT DOWN INTO FIRST GEAR. AFTER SHIFT TO NEUTRAL AND BACK TO DRIVE, TRANS SHIFTED TO FIRST GEAR. DROVE NORMALLY FOR NEXT 15 MILES TO WORK. WHEN LEAVING FOR LUNCH, TRANSMISSION FAILED COMPLETELY AFTER 15 SECONDS IN DRIVE. CAR IS 3 YRS 3 MONTHS OLD, WAS BOUGHT NEW AND HAD 53,000 MILES AT TIME OF FAILURE. CAR HAD BEEN CAREFULLY MAINTAINED ACCORDING TO MANUFACTURER'S SCHEDULE. DEALER'S SERVICE REP SAID CAR WAS OUT OF WARRANTY, AND WOULD NOT CONSIDER ANY ASSISTANCE DUE TO FACT THAT THE CAR HAD NOT BEEN MAINTAINED THERE. I CONTACTED AREA MANUFACTURER'S REP AND WAS TOLD SAME THING. TRIED ONE LAST TIME TO GET HELP BY CALLING DEALER'S SERVICE MANAGER - HE WAS ABLE TO GET MAZDA TO PAY FOR HALF OF A REBUILT TRANSMISSION (ABOUT $800), BUT BY THIS TIME (10 DAYS AFTER THE EVENT) I HAD ALREADY HAD THE CAR REPAIRED (REBUILT TRANS INSTALLED) AT ANOTHER SHOP, SO THE ASSISTANCE OFFER WAS WITHDRAWN. TOTAL REPAIRS COST ME $1835 (AS OPPOSED TO $2650 FROM MAZDA), AND CAR WAS OUT OF SERVICE FOR 9 DAYS. TRANSMISSIONS SHOULD NOT FAIL AT 53,000 MILES. THE TRANS SHOP I DEALT WITH SAID THEY SEE MAZDA PROTEGES AND 626S QUITE OFTEN WITH THIS SAME PROBLEM. I AM TRYING TO PURSUE COMPLETE REIMBURSEMENT OF MY OUT-OF-POCKET COSTS, AND WILL CONTINUE TO DO SO.*AK

TREAD SEPARATION PROBLEM INVOLVING KUMHO ECSTA 711 TIRES.*MR THE VEHICLE FAILED THE VIRGINIA AUTO SAFTY INSPECTION DUE TO A VIOLATION INVOLVING THE TWO FRONT KUMHO TIRES. THE INSPECTOR EXPLAINED THAT THE TREAD WAS SEPARATING FROM THE TIRE DUE TO (HIS OPINION) A SHIFTING OF THE BELTS. *NM

INTERMITTENTLY WHILE DRIVING 40 TO 50 MPH VEHICLE JERKED. VEHICLE WOULD NOT STALL, BUT WOULD LOSE SPEED AND POWER. DEALER EXAMINED THE VEHICLE FOUR TIMES, AND INFORMED THE CONSUMER THAT THERE WAS NOTHING WRONG WITH THE VEHICLE. *AK

VEHICLE WAS INVOLVED IN A 3 CAR FRONTAL COLLISION. UPON IMPACT, FRONTAL AIR BAGS FAILED TO DEPLOY. DRIVER HEAD IMPACTED THE STEERING WHEEL, CAUSING SEVERE HEADACHES. *AK