2003 MAZDA PROTEGE Complaints

MY DAUGHTER DROVE MY MAZDA PROTEGE 5 TO PICK UP MY SON AND TO RETRIEVE SOMETHING FROM A FRIEND'S HOUSE. SHE PARKED THE CAR ON THE FRIEND'S FLAT DRIVEWAY, PLACING IT IN FIRST GEAR. WHILE SHE WAS INSIDE OF THE HOUSE, THE CAR SOMEHOW POPPED OUT OF GEAR AND PICKED UP ENOUGH MOMENTUM TO ROLL ONTO THE ROAD. THE ROAD WAS A HILL, WHICH CAUSED THE CAR TO ACCELERATE. THE CAR ENDED UP STRIKING A HOUSE, CAUSING DAMAGE TO BOTH THE HOUSE AND THE SHRUBBERY OUTSIDE OF THE HOUSE. NOBODY COULD FIND ANY APPARENT PROBLEMS WITH THE CAR/TRANSMISSION. *CN

EMERGENCY BRAKE FAILS ON INCLINES--THIS HAPPENED TO ME AND A WOMAN WITH THE SAME MAKE, MODEL AND YEAR CAR SITTING NEXT TO ME AT AN INSURANCE HEARING! IT CAUSED SIGNIFICANT DAMAGE TO BOTH OUR CARS AND HER FRIEND'S PROPERTY.*CN

TL*THE CONTACT OWNS A 2003 MAZDA PROTG. THE CONTACT STATED THAT THE CHECK ENGINE LIGHT ILLUMINATED. THE MECHANIC CHECKED THE CODES AND STATED THAT THE ENGINE MISFIRED. THE CURRENT MILEAGE WAS 84,000 AND FAILURE MILEAGE WAS 80,000.

2003 MAZDA PROTEGE 5 WITH ROUGH IDLING AND OTHER ENGINE ISSUES. CONSUMER STATES THE VEHICLE HAD A ROUGH IDLE AND THAT IT WOULD HAVE TROUBLE STARTING. *KB WHEN THE MECHANIC INSPECTED THE ENGINE, HE FOUND THE SCREWS HAD PASSED THROUGH THE ENGINE AND WERE FOUND IN THE CATALYTIC CONVERTER. THE CONSUMER DISCOVERED THERE WAS AN INTAKE MANIFOLD SHUTTER AND VARIABLE TUMBLE CONTROL VALVE EMISSION RECALL FOR MAZDA PROTEGE'S, HOWEVER THE CONSUMERS VEHICLE IDENTIFICATION NUMBER DID NOT FALL WITHIN THE RANGE. *JB

TL*THE CONTACT OWNS A 2003 MAZDA PROTEGE. THE CONTACT STATED THAT THE DRIVER SIDE SEAT BELT WOULD NOT LATCH AND THE SEAT BELT WARNING INDICATOR LIGHT ILLUMINATED. THE DEALER ADVISED THE CONTACT NOT TO WORRY ABOUT THE LIGHT AS LONG AS THE BELT WOULD LATCH. HOWEVER, THE BELT NO LONGER LATCHES. THE DEALER STATED THAT THE LATCH NEEDED TO BE REPLACED. THE CURRENT AND FAILURE MILEAGES WERE 93,000.

PURCHASED A PRE OWNED 2003 MAZDA PROTEGE WITH APPROXIMATELY 50,000 MILES ON IT. I DROVE THE VEHICLE FOR ABOUT 4000 MILES BEFORE THERE WAS AN ENGINE FAILURE. THERE WERE NO EVENTS THAT LEAD UP TO THIS INCIDENT. THE ENGINE BEGAN TO MAKE A LOUD KNOCKING NOISE. I HAD IT TOWED TO THE DEALER OF PURCHASE. A SCREW ON AN THE INTAKE CAME LOOSE AND WENT INTO THE ENGINE CYLINDER. DAMAGE CAUSED THE ENGINE TO NEED TO BE REPLACED. MAZDA HAS RECALL 3005C FOR THIS PROBLEM FOR THE EXACT YEAR, MODEL, AND ENGINE AS THE ONE I PURCHASED. HOWEVER, THE VIN NUMBER WAS A FEW THOUSAND NUMBERS OUTSIDE OF THE RECALL RANGE. IM STUCK WITH A 15,000 PIECE OF JUNK. *AK

WHILE DRIVING NORMALLY TO MY HOME AFTER WORK THE CAR STALLED AT A STOP LIGHT. )WHEN RESTARTED THERE WAS A LOUD CLANKING/HAMMERING NOISE FROM THE ENGINE FOR ABOUT 15 SECONDS THEN THE SOUND WENT AWAY, THE CELL LIT UP AND THE ENGINE STARTED SHAKING. WHEN CHECKED FOR CODES A MISFIRE ON CYLINDER -4 WAS FOUND. (THE SPARK PLUG ON CYLINDER 4 HAD BEEN SMASHED FLAT BY A FOREIGN OBJECT THAT CAUSED THE HAMMERING NOISE, NOTHING WAS FOUND INSIDE THE CYLINDER , USING A MAGNET. THE SPARK PLUG WAS REPLACED AND THE CAR WORKED AS NORMAL. UPON INVESTIGATION ON THE INTERNET I FOUND RECALL 3005C FOR THE VEHICLE THAT DESCRIBES MY PROBLEM AND IF NOT FIXED CAN CAUSE ENGINE FAILURE. WHEN CONTACTING MAZDA CUSTOMER ASSISTANCE THEY SAID MY VIN WAS NOT IN RANGE FOR THIS RECALL AND THAT I WOULD HAVE TO PAY FOR ANY REPAIRS BECAUSE MY CAR HAS 61000 MILES AND EVEN THOUGH THE EMISSIONS WARRANTY IS STILL ACTIVE, THE REGULAR WARRANTY IS OVER.*AK

I PURCHASED VEHICLE NEW IN JAN 04. WHILE EXITING THE FREEWAY, I FELT A "HICCUP" IN THE ENGINE AT WHICH TIME IT RAN VERY POORLY AND CHECK ENGINE LIGHT CAME. THE SERPENTINE BELT HAD ALSO JUMPED ABOUT 25% OFF DRIVE PULLEYS. I WAS TRAVELING OUT OF TOWN AT THIS TIME AND TOOK IT TO A LOCAL SERVICE STATION. TECHNICIAN IDENTIFIED PROBLEM AS AN ENGINE MISFIRE AND INSTALLED A NEW BELT. I DECIDED NOT TO HAVE SERVICE STATION PERFORM ANY ADDITIONAL DIAGNOSIS PREFERRING TAKE VEHICLE TO DEALERSHIP INSTEAD. DEALERSHIP DETERMINED THAT A SPARK PLUG HAD FAILED AND CAME APART. DEALERSHIP THEN REPLACED ALL SPARK PLUGS. VEHICLE RAN FINE. APPX 1 MONTH LATER, EXACT SYMPTOMS OCCURRED - ENGINE HICCUP, ROUGH IDLE, CHECK ENGINE LIGHT. AGAIN I TOOK TO DEALERSHIP. MASTER TECH WAS ASSIGNED TO MY VEHICLE THIS TIME AND DETERMINED CAUSE TO BE SHUTTER VALVE SCREWS HAD COME LOOSE FROM THE INTAKE MANIFOLD AND ENTERED ENGINE CAUSING DAMAGE TO SPARK PLUG. TECHNICIAN INFORMED ME OF RECALL # 3005C THAT HAD BEEN ISSUED AND THAT HE WOULD CONTACT HIS REGIONAL SERVICE MANAGER TO REQUEST THE REPAIR BE COVERED BY MAZDA. REGIONAL SVC MGR DECLINED TO COVER COSTS STATING MY SPECIFIC VIN WAS NOT IN THE EFFECTED RANGE AND THAT MY MILEAGE WAS TOO HIGH. I LOOKED UP THE RECALL AND DETERMINED THE RECALL ISSUE DATE TO BE 6/1/05. AT THAT TIME MY MILEAGE WOULD HAVE BEEN 40,000 TO 50,000 MILES. I THEN CONTACTED MAZDA USA CUSTOMER ASSISTANCE - REFERENCE NUMBER 112751060. I WAS TOLD THAT MAZDA WOULD NOT COVER THE EXPENSE BECAUSE MY VIN # WAS NOT IN THE RANGE OF EFFECTED VEHICLES. I WAS ALSO TOLD THAT VIN RANGE WAS DETERMINED BY THE NHTSA AND NOT BY MAZDA AND THAT IT WAS ILLEGAL FOR MAZDA TO PAY FOR THE REPAIR EXPENSE. I BELIEVE THIS TO BE A LIE ON THE PART OF MAZDA. I BELIEVE MAZDA IS NOT ACCEPTING ITS' RESPONSIBILITY TO THE CONSUMER BECAUSE THIS WOULD BE ADMITTING THE PROBLEM IS LARGER THAN THE ORIGINAL SCOPE AND WILL COST THE COMPANY A SUBSTANTIAL AMOUNT OF MONEY. *JB

FOR OVER TWO AND A HALF YRS, MY CAR HAS HAD A ROUGH IDLING NOISE AND THE ENGINE OFTEN HESITATES AND WANTS TO TURN OFF. ON SEVERAL OCCASIONS THE ENGINE HAS HESITATED AND SHUT THE CAR OFF. VERY RECENTLY A LOUD NOISE WAS COMING FROM MY ENGINE. (YOU COULD HEAR A RATTLING NOISE) IT SOUNDED LIKE A PIECE OF METAL RATTLING AROUND IN THE ENGINE. A YEAR AGO I TOOK MY CAR INTO THE DEALERSHIP BECAUSE OF A RECALL (RECALL 3005C) TO GET IT CHECKED OUT (THIS IS WHAT THE LETTER FROM MAZDA ASKED ME TO DO) MY CAR WAS THERE ONLY TWO HOURS AND ONLY LOOKED AT MAYBE ABOUT THIRTY MINUTES. I RECEIVED AN OIL CHANGE AND THEN THEY WERE TO INSPECT IT DUE TO THE RECALL. WHEN I RETRIEVED MY CAR THEY GAVE ME A CERTIFICATE OF CORRECTION, BUT INFORMED ME THAT NOTHING HAD BEEN FIXED AND THAT THEY WERE ONLY AUTHORIZED TO INSPECT. THAT IF THE PART BROKE THAT I WOULD BE RESPONSIBLE FOR IT EVEN THOUGH IT WAS A RECALL. HERE I AM ONE YEAR LATER AND I HAD MY CAR LOOKED AT AND IT APPEARS THAT TWO OF THE SCREWS MUST HAVE COME LOOSE DUE TO THE RECALL. (THEY WERE FOUND IN MY EXHAUST) I GOT NO HELP FROM THE DEALER. I FOUND THE RECALL INSTRUCTIONS ONLINE FROM MAZDA TO THE DEALER WHICH INSTRUCTS THE DEALER TO REPLACE THE PARTS IF THEY HAVE NOT BEEN REPLACED ON ANY PREVIOUS OCCASION (WHICH WAS PROCEDURE B). AND IF IT HAS BEEN PREVIOUSLY WORKED ON THEY ARE TO PROCEED WITH PROCEDURE A WHICH INSTRUCTS THEM TO DO AN AIR COMPRESSION INSPECTION FOR INTERNAL DAMAGE AND GIVE A CERTIFICATE OF CORRECTION. THEY DID THE WRONG PROCEDURE ON MY CAR AND NEVER ACTUALLY DID WHAT NEEDED TO BE REPLACED FOR MY CAR TO BE LEGAL AND OK TO DRIVE. THEY ARE NOW AVOIDING MY CALLS AND NOT RETURNING NUMEROUS E-MAILS OR VOICE MAILS. I HAVE BEEN TRYING THE DEALER AND MAZDA THEMSELVES. ON TUES .I RECEIVED NOTHING BUT RUDE MOCKING FROM EACH PLACE TELLING ME THAT IT WAS MY PROBLEM. I HAVE BEEN TRYING EVERYDAY SINCE AND I HAVE RECEIVED NO RESPONSE. *NM UPDATED 2/23/2007 - INTAKE MANIFOLD SHUTTER AND VARIABLE TUMBLE CONTROL VALVES.*NM

TL* - THE CONTACT OWNS A 2003 MAZDA PROTG. THE CONTACT WAS DRIVING 15 MPH WHEN THE PASSENGER SIDE LOWER CONTROL ARM SPLIT IN HALF AND THE STRUT WENT THROUGH THE FENDER ALONG WITH THE UPPER CONTROL ARM. THE ROAD CONDITIONS WERE NORMAL. WHEN THE VEHICLE HIT THE GROUND BOTH AIRBAGS DEPLOYED. THE DRIVER WAS INJURED AS A RESULT. THE POLICE FILED A REPORT; HOWEVER, THE CONTACT FEELS THAT SOME OF THE INFORMATION IS INCORRECT. THE VEHICLE WAS TOWED TO THE DEALER AND WAS TOLD THAT THE FAILURE WAS CAUSED BY HITTING SOMETHING IN THE ROAD; THE CONTACT DISAGREED. THE DEALER WILL NOT COVER THE REPAIR UNDER THE WARRANTY. *AK