1990 MAZDA RX-7 Complaints

EXHAUST MANIFOLD IS LEAKING CARBON MONOXIDE INTO THE CABIN OF VEHICLE, CAUSING A HEALTH HAZARD. DEALER IS AWARE OF DEFECT. CONSUMER CLAIMS HE IS AWARE OF OTHER VEHICLES OF THE SAME MODEL THAT HAVE THIS DEFECT. *AK *ML

ANTI-LOCK BRAKE UNIT LEAKING BRAKE FLUID. STARTED ABOUT 5/5/97. LEAKS WITH CAR PARKED, MAY LEAK WHILE DRIVING. STARTED GRADUALLY, NOW LOSES ABOUT TWO OUNCES PER WEEK. IF BRAKE FLUID LEVEL GETS TOO LOW WHILE DRIVING, IT CAN PREVENT PROPER BRAKE OPERATION AND INCREASE THE RISK OF ACCIDENT. THE ABS UNIT IS LOCATED NEAR THE ENGINE EXHAUST AND JUST AFT OF THE RIGHT FRONT WHEEL. I SUSPECT THAT BRAKE FLUID MAY DRIP ON THE HEATED EXHAUST SYSTEM; PERHAPS THIS COULD CAUSE A FIRE. IF DRIPPING BRAKE FLUID GOT ON THE TIRE, IT COULD REDUCE TRACTION AND CONTRIBUTE TO AN ACCIDENT. ALL OF THESE POSSIBILITIES COMPRISE SAFETY HAZARDS. IN ADDITION, I HAVE CHECKED MULTIPLE SOURCES FOR USED ABS UNITS AND ALL ORIGINAL UNITS LOCATED ALSO LEAK. THIS IS APPARENTLY A COMMON PROBLEM. SOME OWNERS HAVE REMOVED AND BYPASSED THE ABS UNIT TO STOP THE LEAK. THIS IS PROBABLY ALSO UNSAFE. I SUGGEST THAT THE MANUFACTURER SHOULD REPLACE ALL SUCH DEFECTIVE ABS UNITS AS A SAFETY MEASURE.

RECEIVED NOTICE 96V173000 3 MONTHS AGO. BEEN CALLING DEALERSHIP OFF/ON EVER SINCE. BEEN INFORMED NO PARTS AVAILABLE FOR SEAT BELTS. WOULD NOTIFY WHEN BELT PARTS ARE AVAILABLE. *AK

HAD RECEIVED RECALL 996V173000 OVER 3MONTHS AGO & CONTACTED DEALER. BEEN CHECKING OFF & ON FOR 3MONTHS. CALLED LAST WEEK & WA S INFORMED NO PARTS WERE AVAILABLE, AND DID NOT KNOW WHEN THEY WOULD BE AVAILABLE FOR REPAIRS TO AUTOMATIC SHOULDER BELT. MANUFACTURER ONLY DID A SMALL AMOUNT, AND WAS NOT SURE IF HE WILL DO ANY MORE. *AK

SHOULDER BELTS BROKE TO THE POINT WERE THEY DON'T RETRACT, AND ARE LAYING IN THE BACK SEAT OF THE VEHICLE. DEALER HAS BEEN CONTACTED. *AK

VEHICLE'S HEADLIGHT LIGHT SWITCH CIRCUIT BOARD MODULE OVERHEATS AND STARTS FIRE.THE LIGHTS TURN AND OFF INTERMITENTLY WITH NO WARNING.THE HEADLIGHT SWITCH IS DEFECTIVE. *AK

THE DRIVER'S SIDE SEAT BELT RETRACTOR SOMETIMES WORKS, TOOK BACK TO DEALER AFTER RECEIVG I RECALL # 96V173000 ; DONE SEAT RETRACTOR REPAIRS, DEALER SAID IT THE LATCH THAT IS CAUSING THE PROBLEMS, NOT THE RETRACTORS. *AK

THE SEAT BELTS WILL NOT EXTEND FROM RETRACTORS. THE ACTIVE SEAT BELT STOPPED HALF WAY BETWEEN THE LOCKED AND UNLOCKED POSITION. *AK

ENGINE HAS FAILED AT 40,200 MILES BECAUSE THE APEX SEALS HAVE ERODED. VEHICLE HAS BEEN PROPERLY MAINTAINED AND GARAGE STORED.

SYCAMORE FORD MAZDA SAID THEY KNOW NOTHING ABOUT THE RECALL AND MAZDA MANUFACTURER SAID THE CONSUMER IS NOT INCLUDED, BUT HE RECEIVED NOTICE AND HIS SHOULDER BELT IS BROKEN. PLEASE DESCRIBE DETAILS. *AK