2005 MERCEDES-BENZ C240 Complaints

THE GEAR SHIFT DOES NOT STAY MOUNTED IN THE CAR. IT CONSTANTLY COMES OUT OF THE BOARD. IT COMES UP WHEN I AM CHANGING GEARS.

TL* THE CONTACT OWNS A 2005 MERCEDES-BENZ C240. WHILE DRIVING AT VARIOUS SPEEDS, THE AIR BAG WARNING INDICATOR ILLUMINATED. THE CONTACT STATED THAT THE FAILURE OCCURRED ON PREVIOUS OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FRONT DRIVER SEAT BELT CONNECTION FAILED AND DISABLED THE SUPPLEMENTAL RESTRAINT SYSTEM. THE CONTACT ALSO STATED THAT THE REAR SEAT ACTUATOR FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 95,632.

THE REAR END OF THE VEHICLE IS ADHERED TO THE FRAME VIA FOUR BOLTS. ON THE LEFT ONE OF THOSE BOLTS BROKE OFF DUE TO METAL FATIGUE. THAT MEANS THE REAR END OF THE VEHICLE IS HELD ON BY THREE BOLTS. A SERIOUS SAFTEY HAZARD BECAUSE IF ONE MORE GAVE WHILE DRIVING IT COULD CAUSE AN ACCIDENT.

THE ELECTRONIC ENGINE/GEARBOX PROTECTION SWITCHED OFF THE ENGINE WHILE THE CAR IS ON THE MOVE IN A HIGHWAY. THE INCIDENCE HAPPEN TWICE IN 2011 AND 2012. FORTUNATELY, I WAS ABLE TO PULL OVER ON THE SHOULDER AND RESTART THE ENGINE WITHOUT ANY ADVERSE INCIDENCE. BUT, THE POTENTIAL FOR CATASTROPHIC INJURY AS A RESULT OF SUDDEN LOSS OF ENGINE POWER IN A HIGHWAY CONCERNS ME.

THE ELECTRONIC WARNING SIGN FOR UNLOCKED SEAT BELT COMES ON WHILE THE CAR IS MOVING, INCLUDING AT HIGH SPEED ON FREEWAYS. UNLOCKING AND RE-LOCKING THE SEAT-BELT DOES NOT FIX THE PROBLEM. THIS PROBLEM HAS BEEN OCCURRING ON AND OFF FOR A COUPLE OF YEARS AND I AM CONCERNED ABOUT THE POTENTIAL THE AIRBAG MAY NOT DEPLOY APPROPRIATELY IN CASE AN ACCIDENT/COLLISION.

THE BACK COIL SPRING BROKE AT THE SAME TIME FEW MONTHS AGO ON THE SAME SPOTE THE POWER TRAIN DRIVE ACTING UP. THE SECTION WHERE THE CRUISE CONTROL AND BLINKER IS MOUNTED ON IS LOSE THE WHOLE SECTION BUT MERCEDES SAID THEY COULDN'T MAKE SCREWED CLOSER TOGETHER STEERING GEARBOX). *TR

TL* THE CONTACT OWNS A 2005 MERCEDES BENZ C240. THE CONTACT STATED THAT A STRONG BURNING ODOR EMITTED FROM THE DRIVER'S SEAT WHILE THE HEATED SEAT FUNCTION WAS ACTIVATED. THE CONTACT INSPECTED THE SEAT AND FOUND THE SEAT TO BE SMOKING. THE VEHICLE WAS TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 74,000.

WHILE TRAVELING AT APPROXIMATELY 35 MPH THE ENGINE STALLED WITHOUT WARNING. WE HAD JUST LEFT HOME ABOUT TWO MINUTES BEFORE. WITH EXTREME DIFFICULTY IN TURNING THE STEERING WHEEL, WE DRIFTED TO THE SIDE OF THE ROAD AND THEN RESTARTED THE CAR. THIS HAS HAPPENED TWICE BEFORE, ONCE HAVING JUST REVERSED OUT OF A PARKING SPOT AND THEN DRIVING FORWARD OUT OF THE PARKING LOT AT VERY SLOW SPEED AND THEN AGAIN WHEN REVERSING OUT OF THE GARAGE. AT OTHER TIMES, WHEN FIRST STARTING UP THE CAR IN THE GARAGE AND TURNING THE KEY, THERE HAS BEEN NO IGNITION INITIALLY. *TR

WHILE DRIVING ALONG AT 45 MPH THE FRONT DRIVERS SEAT HEATING ELEMENT WAS ACTIVATED. IT WAS SWITCHED ON TO ITS HIGHEST SETTING. IN APPROXIMATELY ONE MINUTE THE FRONT SEATBACK LEFT SIDE BOLSTER CAUGHT FIRE BURNING A DIME SIZE HOLE AND BURNING THE FLEECE VEST WORN BY THE DRIVER. THE VEHICLE WAS IMMEDIATELY SLOWED TO STOP ALONG THE HIGHWAY SHOULDER AND THE DRIVER EXITED AFTER TURNING OFF THE DASH SWITCH. THE SMOLDERING STOPPED. THE SWITCH HAS SINCE REMAINED IN THE OFF POSITION AND AN APPOINTMENT WITH A MECHANIC WILL BE SCHEDULED. *TR

TL* THE CONTACT OWNS A 2005 MERCEDES-BENZ C240. THE CONTACT STATED THAT AFTER PARKING THE VEHICLE IN A RESIDENTIAL GARAGE, HE NOTICED A LARGE PUDDLE OF FUEL HAD LEAKED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY ADVISED HIM THAT THERE WAS A FRACTURE IN THE FUEL TANK THAT NEEDED TO BE REPLACED. THE FUEL TANK WAS REPLACED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 60,000. THE VIN WAS UNAVAILABLE. UPDATED 06/05/12*LJ UPDATED 06/06/12 *JS