1997 MERCEDES-BENZ E CLASS Complaints

SPRING PERCHES ON THE FRONT SUSPENSION HAS RUSTED AND ARE FALLING APART. THIS IS A SERIOUS SAFETY THREAT AND IF THE PERCHES BREAK WHILE DRIVING, PEOPLE CAN GET KILLED. LOCAL MERCEDES DEALERSHIP IS REFUSING TO REPAIR OR EVEN INSPECT THE PROBLEM AND IS TELLING ME THERE IS NOTHING THEY CAN DO. RUST ON THE FRAME WELD IN ANY CAR IS NOT ACCEPTABLE, I AM DEEPLY DISAPPOINTED BY THE LACK OF QUALITY AND LACK OF SUPPORT FROM MERCEDES-BENZ!!!*JB

DRIVING STRAIGHT AT ABOUT 25 MPH WHEN THE LEFT FRONT SPRING PERCH BROKE. I WAS ABLE TO STOP CAR WITH NO INJURY OR DAMAGE TO THE CAR. *NM

DT*: THE CONTACT STATED WHILE DRIVING 55 MPH ON NORMAL ROAD CONDITIONS, THE VEHICLE'S FRONT END STARTED SHAKING. THE PROBLEM WAS GETTING WORST. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP FOR INSPECTION WHO NOTIFIED THE PERCH, WHICH SUPPORTED THE COILS SPRINGS, WERE SEPARATED FROM THE STRUCTURE. THE MANUFACTURER REFERRED THE CONTACT TO A DEALERSHIP WHO ACKNOWLEDGED THE DEFECT AND NOTIFIED THE COST WOULD BE COVERED BY THE CONTACT.

DT*: THE CONTACT STATED THAT ON SEVERAL OCCASIONS, WHEN THE REAR PASSENGER WINDOW WAS OPENED, THERE WAS A RATTLING SOUND, AND A SOUND OF GLASS BREAKING. AFTER THESE INCIDENCES THE WINDOW WAS VERY DIFFICULT TO CLOSE, EVEN THOUGH THE WINDOW MOTOR WAS STILL FUNCTIONING. THE VEHICLE WAS TAKEN TO A SERVICE DEALER WHERE IT WAS DETERMINED THAT THE WINDOW REGULATOR HAD FAILED, AND WAS SUBSEQUENTLY REPLACED.

DT*: THE CONTACT STATED WHILE THE VEHICLE WAS PARKED IN THE GARAGE, THE FRONT PASSENGER SIDE COIL SPRING FELL OFF. THE VEHICLE HAS NOT BEEN SEEN BY A MECHANIC.

DT*: THE CONTACT STATED THE VEHICLE WAS MAKING A NOISE IN THE FRONT END. THE VEHICLE WAS TAKEN TO THE CONTACT'S REPAIR SHOP AND DETERMINED THE UPPER SPRING SUPPORT ON THE DRIVER'S SIDE BROKE. THE CONTACT WELDED IN A NEW UPPER SPRING SUPPORT.

WHILE DRIVING AT 35 MPH DOWN A SMALL HILL THE FRONT PASSENGER SPRING MOUNT (PERCH) ON MY 1997 E 300 DIESEL (W210) BROKE OFF CAUSING THE COIL SPRING TO FALL OFF OF THE CAR. THIS WAS AN UNBELIEVABLY DANGEROUS OCCURRANCE AND LUCKILY IT DID NOT HAPPEN WHEN I WAS GOING 65 MPH. I HAVE BROUGHT THE CAR MY AUTOBODY SHOP AND WE ARE STILL WORKING ON WHO WILL COVER THE COST OF MY REPAIRS (INSURANCE OR MB)

DT: THE CONSUMER FOUND OUT THIS MORNING THAT THE SPRING HOUSING WAS CORRODED. THE FRONT COIL SPRING HOUSING CORRODED AND BROKE AWAY FROM THE BODY ON FRONT PASSENGER'S SIDE. THIS WAS DISCOVERED BY THE CONSUMER WHILE HE WAS ROTATING HIS TIRES. HE FELT THE SPRING COULD COME OUT AND CAUSE THE LOSS OF VEHICLE CONTROL. THERE HAS BEEN NO REPAIR OR REPLACEMENT AT THIS TIME. THE CONSUMER PLANNED TO CONTACT THE DEALER THIS AFTERNOON. THERE WERE OTHER COMPLAINTS LISTED ON THE NHTSA WEBSITE AND OTHER WEBSITES AS WELL. THE MERCEDES OWNER WEBSITE HAD A NUMBER OF COMPLAINTS LISTED. THE VEHICLE IS AN E420. THE CHASSIS NUMBER W210.*AK

SPRING PERCH IS CHEAPLY WELDED TO THE WHEEL WELL ON THE MERCEDES 210 CHASSIS (1997 E420). ALL OTHER CARDS HAVE IT ATTACHED TO A SOLID BAR. MERCEDES WELDED IT TO VERY THIN SHEET METAL WHICH MERCEDES KNOWS HAS BEEN FAILING AT AN ALARMING RATE (DEALER ADMITTED THIS TO ME - THEY SEE THIS PROBLEM EVERY WEEK). 18 INCH LONG SUSPENSION SPRING POPPED OUT OF MY CAR WHILE MOVING. I COULD HAVE BEEN KILLED AS CAR IS UNCONTROLLABLE AFTER SUSPENSION GIVES OUT. INEXCUSABLE DESIGN FLAW THAT MERCEDES KNOWS IS A DAILY PROBLEM FOR ANYONE WITH THE 210 CHASSIS (AND THE HEAVIER ENGINES (420, 430 ETC.) WHERE THERE IS ADDITIONAL WEIGHT ON THE FRONT SUSPENSION). SERVICE REP AT DEALER EVEN TOLD ME THAT HE HAS SEEN IT HAPPEN ON THE HIGHWAY AND KNEW EXACTLY WHAT WAS GOING ON B/C HE SEES IT SO OFTEN. LUCKILY, THE CAR HE WITNESSED WAS ABLE TO GET TO THE BREAK-DOWN LANE/SHOULDER FOR SAFETY. THIS IS A POTENTIALLY DEADLY FAILURE OF THE SUSPENSION ON THE MERCEDES 210 CHASSIS. *NM

LOUD POP AND CAR BECAME DIFFICULT TO DRIVE. FRONT SPRING SUPPORT (PERCH) CAME LOOSE FROM THE FRAME RAIL. FRONT SUSPENSION WAS REMOVED, NEW SUPPORT WAS WELDED TO THE FRAME AND SUSPENSION REPLACED. AFTER READING OWNERS FORUMS ON THE INTERNET, IT HAS BECOME QUITE OBVIOUS THAT MANY MERCEDES BENZ W210 CHASSIS CARS (E CLASS) HAVE HAD THIS PROBLEM. APPARENTLY IT HAS TO DO WITH A SEALANT FAILING THAT ALLOWS WATER TO SIT IN THE JOINT WHERE THE SUPPORT IS WELDED TO THE FRAME.*AK